6 open recalls
The following open safety recalls are on record with the U.S. NHTSA for the 2020 Volvo XC60. Recalls apply to specific VINs and build ranges — check your VIN to confirm which affect your vehicle.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
NHTSA campaign #: 25V179000 · Reported: March 24, 2025 · Electrical
Consequence: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy: Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
NHTSA campaign #: 23V001000 · Reported: Jan. 5, 2023 · Steering
Consequence: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
Remedy: Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.
NHTSA campaign #: 21V716000 · Reported: Sept. 15, 2021 · Brakes
Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
NHTSA campaign #: 21V414000 · Reported: June 2, 2021 · Electrical
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
NHTSA campaign #: 20V503000 · Reported: Aug. 25, 2020 · Visibility
Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
NHTSA campaign #: 20V144000 · Reported: March 12, 2020
SaveVIN surfaces open recalls published by the U.S. National Highway Traffic Safety Administration (NHTSA). A model-level page lists every recall reported for the model; your specific VIN determines which apply to your car. Enter your VIN above for a VIN-precise report and to monitor it for new recalls.