Recalls › Volkswagen › 2005 Passat
2005 Volkswagen Passat Recalls & Safety Report
The following open safety recalls are on record with the U.S. NHTSA for the 2005 Volkswagen Passat. Recalls apply to specific VINs and build ranges. Check your VIN to confirm which affect your vehicle.
ENGINE AND ENGINE COOLING:ENGINE Critical safety
Summary: The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Risk: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Remedy: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
NHTSA campaign # 14E007000 · Manufacturer: The Gates Corporation · Reported: 2014-03-07 · Engine/Fuel
FUEL SYSTEM, GASOLINE:DELIVERY Critical safety
Summary: VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Risk: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
NHTSA campaign # 08V156000 · Manufacturer: VOLKSWAGEN OF AMERICA, INC · Reported: 2008-04-07 · Engine/Fuel
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH Critical safety
Summary: ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Risk: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
NHTSA campaign # 07V063000 · Manufacturer: VOLKSWAGEN OF AMERICA, INC · Reported: 2007-02-20 · Brakes
FUEL SYSTEM, DIESEL Critical safety
Summary: ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
NHTSA campaign # 04V586000 · Manufacturer: VOLKSWAGEN OF AMERICA, INC · Reported: 2004-12-15 · Engine/Fuel
Recall summary
This 2005 Volkswagen Passat has 4 open recalls on record with the U.S. NHTSA.
By affected component
- ENGINE AND ENGINE COOLING:ENGINE — 1 recall
- FUEL SYSTEM, GASOLINE:DELIVERY — 1 recall
- EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH — 1 recall
- FUEL SYSTEM, DIESEL — 1 recall
By severity
- Critical safety — 4
Most recent recall reported: 2014-03-07.
Recall data is sourced from the U.S. National Highway Traffic Safety Administration (NHTSA).
Frequently asked questions
Does the 2005 Volkswagen Passat have open recalls?
Yes — there are 4 open NHTSA safety recalls on record for the 2005 Volkswagen Passat. Recalls apply to specific VIN and build ranges, so check your exact VIN to confirm which affect your vehicle.
How do I check if a recall applies to my exact VIN?
This page lists recalls at the model level. Enter your 17-character VIN on our free VIN lookup to see which recalls apply to your specific car and to monitor it for new ones.
Who pays for a recall repair?
Safety recall repairs are performed free of charge by a franchised dealer for the affected make — the manufacturer covers the cost. Start by confirming your VIN is affected, then contact a dealer.
About this report
SaveVIN surfaces open recalls published by the U.S. National Highway Traffic Safety Administration (NHTSA). A model-level page lists every recall reported for the model; your specific VIN determines which apply to your car. Enter your VIN above for a VIN-precise report and to monitor it for new recalls.
Data source: U.S. NHTSA (nhtsa.gov). SaveVIN surfaces public recall data and is not affiliated with or endorsed by NHTSA.