2003 Ford F-150 Recalls & Safety Report
The following open safety recalls are on record with the U.S. NHTSA for the 2003 Ford F-150. Recalls apply to specific VINs and build ranges. Check your VIN to confirm which affect your vehicle.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING Critical safety
Summary: FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
Risk: AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
Remedy: FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
NHTSA campaign # 11V385000 · Manufacturer: FORD MOTOR COMPANY · Reported: 2011-07-29 · Engine/Fuel
EXTERIOR LIGHTING:HEADLIGHTS Critical safety
Summary: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
NHTSA campaign # 09E025000 · Manufacturer: DOPE, INC. · Reported: 2009-05-11
EXTERIOR LIGHTING Critical safety
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
NHTSA campaign # 09E012000 · Manufacturer: SABERSPORT · Reported: 2009-04-07
EXTERIOR LIGHTING:HEADLIGHTS Critical safety
Summary: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
NHTSA campaign # 08E050000 · Manufacturer: K2 MOTOR CORPORATION · Reported: 2008-08-11
EQUIPMENT:ELECTRICAL Critical safety
Summary: CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Risk: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Remedy: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
NHTSA campaign # 07E066000 · Manufacturer: CEQUENT ELECTRICAL PRODUCTS · Reported: 2007-08-28 · Electrical
VEHICLE SPEED CONTROL Critical safety
Summary: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
NHTSA campaign # 07V336000 · Manufacturer: FORD MOTOR COMPANY · Reported: 2007-08-03
VEHICLE SPEED CONTROL Critical safety
Summary: ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Risk: OVERHEATING COULD RESULT IN SMOKE, BURN, OR AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017, 05V388, AND 06V286)
NHTSA campaign # 07V078000 · Manufacturer: FORD MOTOR COMPANY · Reported: 2007-03-06
EXTERIOR LIGHTING:HEADLIGHTS Critical safety
Summary: CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
NHTSA campaign # 06E067000 · Manufacturer: MAXZONE AUTO PARTS CORPORATION · Reported: 2006-08-01
FUEL SYSTEM, GASOLINE Critical safety
Summary: CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Risk: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
NHTSA campaign # 06E056000 · Manufacturer: UFI FILTERS USA · Reported: 2006-06-13 · Engine/Fuel
EXTERIOR LIGHTING:HEADLIGHTS Critical safety
Summary: CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
NHTSA campaign # 06E052000 · Manufacturer: SABRY LEE, INC. · Reported: 2006-06-12
STEERING:GEAR BOX:SHAFT PITMAN Critical safety
Summary: ON CERTAIN PICKUP TRUCKS, THE PITMAN ARM TO STEERING GEAR RETAINING NUT WAS NOT FULLY TIGHTENED TO THE REQUIRED SPECIFICATION.
Risk: IF THE PITMAN ARM TO GEARBOX ATTACHMENT NUT LOOSENS, A NOISE AND A LOOSE FEEL IN THE STEERING COULD OCCUR. IF THE CONDITION PROGRESSED AND SERVICE WAS NOT SOUGHT, THE NUT COULD BACK OFF COMPLETELY AND THE PITMAN ARM COULD SEPARATE FROM THE GEAR CAUSING A LOSS OF STEERING. IF THE WARNING IS NOT HEEDED AND STEERING IS LOST, A CRASH MAY RESULT.
Remedy: DEALERS WILL TIGHTEN THE PITMAN ARM RETAINING NUT TO SPECIFICATIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 1, 2003. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
NHTSA campaign # 03V349000 · Manufacturer: FORD MOTOR COMPANY · Reported: 2003-09-22 · Steering
Recall summary
This 2003 Ford F-150 has 11 open recalls on record with the U.S. NHTSA.
By affected component
- EXTERIOR LIGHTING:HEADLIGHTS — 4 recalls
- VEHICLE SPEED CONTROL — 2 recalls
- FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING — 1 recall
- EXTERIOR LIGHTING — 1 recall
- EQUIPMENT:ELECTRICAL — 1 recall
- FUEL SYSTEM, GASOLINE — 1 recall
- STEERING:GEAR BOX:SHAFT PITMAN — 1 recall
By severity
- Critical safety — 11
Most recent recall reported: 2011-07-29.
Recall data is sourced from the U.S. National Highway Traffic Safety Administration (NHTSA).
Frequently asked questions
Does the 2003 Ford F-150 have open recalls?
Yes — there are 11 open NHTSA safety recalls on record for the 2003 Ford F-150. Recalls apply to specific VIN and build ranges, so check your exact VIN to confirm which affect your vehicle.
How do I check if a recall applies to my exact VIN?
This page lists recalls at the model level. Enter your 17-character VIN on our free VIN lookup to see which recalls apply to your specific car and to monitor it for new ones.
Who pays for a recall repair?
Safety recall repairs are performed free of charge by a franchised dealer for the affected make — the manufacturer covers the cost. Start by confirming your VIN is affected, then contact a dealer.
About this report
SaveVIN surfaces open recalls published by the U.S. National Highway Traffic Safety Administration (NHTSA). A model-level page lists every recall reported for the model; your specific VIN determines which apply to your car. Enter your VIN above for a VIN-precise report and to monitor it for new recalls.
Data source: U.S. NHTSA (nhtsa.gov). SaveVIN surfaces public recall data and is not affiliated with or endorsed by NHTSA.