2024 Ford Explorer Problems & Owner Complaints

Forward Collision Avoidance 3

“have been getting a warning coming up saying pre-collision sensor not available sensor blocked over 100 times brought it to the dealership and they said that the bracket for the sensor is broken due to road debris, impact or snow and ice buildup with no evidence of any damage”
NHTSA complaint #11746055, 2026

“pre-collision warning light comes up, saying sensor blocked and sensor is not blocked. Brought it to the local dealership found that the cruise control module bracket is damaged no visible damage or strikes to the bumper dealership says not under warranty, and Ford is aware of a widespread issue with the bracket snapping on the sensor behind the front bumper”
NHTSA complaint #11741974, 2026

“This vehicle has a 360 camera system that was not included, despite is being included in the component package that is standard for this vehicle. I contacted the dealer directly, informed them that there are cameras installed on the vehicle, but only the rear camera is operational. Further investigation into the matter revealed that Ford apparently "recalled" the camera systems on the Explorer for the 2023 models, but has not distributed any information to its dealers. Now I have a forward facing camera that is not operational, but the vehicle's warning system continually advises me there i…”
NHTSA complaint #11595059, 2024

Suspension 3

“The contact owns a 2024 Ford Explorer. The contact stated while parked upon inspecting the vehicle, he noticed the driver's side and passenger side struts failed. The vehicle was taken to a dealer where it was diagnosed that both front struts needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure and offered no assistance. The approximate failure mileage was 11,103.”
NHTSA complaint #11635284, 2025

“Purchased new from dealer. At 3500 miles, noticed rattling and clunking noise under front end, more noticeable at speeds less than 35. Took to dealer who diagnosed as worn struts, saying shocks and struts need to be replaced, but they need to order parts. When asked if safe to drive, was told "yes", but "avoid potholes". Now waiting to hear from dealer when parts come in. They stated it would take 4 to 5 hours to repair/replace.”
NHTSA complaint #11635531, 2024

“The contact owns a 2024 Ford Explorer. The contact stated while driving approximately 30-40 MPH in cold weather, the vehicle started making an abnormal clunking and rattling sound near the wheels. The contact was unable to determine the source of the noise. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 24V091000 (SUSPENSION, STEERING). The vehicle was taken to the local dealer, where it was diagnosed that the front struts were worn and needed to be replaced. The dealer recommended that the contact not drive the vehicle. The…”
NHTSA complaint #11633176, 2024

Unknown Or Other 3 1 fire

“Deputy was going to an incident and after arrival at the scene the patrol car began to smoke, and flames were seen within the wheel well. Deputy was not in the vehicle when the fire was discovered, and Fire responded and extinguished the flames - but not before major damage to the engine compartment.”
NHTSA complaint #11671520, 2025 · fire

“Inner fender liners are getting rubbed through by the tires creating large holes and exposing wiring harnesses and other components to the tire/wheel well area. We have seen this on about 5-6 of these same vehicles now.”
NHTSA complaint #11629159, 2024

“This vehicle has a 360 camera system that was not included, despite is being included in the component package that is standard for this vehicle. I contacted the dealer directly, informed them that there are cameras installed on the vehicle, but only the rear camera is operational. Further investigation into the matter revealed that Ford apparently "recalled" the camera systems on the Explorer for the 2023 models, but has not distributed any information to its dealers. Now I have a forward facing camera that is not operational, but the vehicle's warning system continually advises me there i…”
NHTSA complaint #11595059, 2024

Visibility/Wiper 3

“Rear windshield wiper doesn't work. Earlier model years have been recalled for wiper motor issues.”
NHTSA complaint #11730556, 2026

“Visual blurry defect in windshield glass in driver side”
NHTSA complaint #11696723, 2024

“There is a distortion in the front windshield affecting my ability to see the front right corner of my vehicle. I was leaving a restaurant in the dark and the distortion affected the headlights to the point it didn’t appear there were any on the right side of the vehicle. In daylight, that area of the windshield is so distorted I’ve missed vehicles coming from the right and developed it migraines while driving. The defect was reported to the dealership and they reported it to the manufacturer in August, they have been going back and forth since, most recently being denied due to ‘orange peel’.…”
NHTSA complaint #11623413, 2024

Electrical System 2

“The center display went blank and a/c controls under it would not work. Stopped vehicle and pushed ignition button to off and waited 1 minute and pushed ignition back to on on and display was still blank. Got to destination and pushed ignition to off. The next day when I got into vehicle and pushed ignition button to on the display worked.”
NHTSA complaint #11746112, 2026

“• Driver seat not setting its memory for the driver , and will move on its own and go all the way to dash while setting in it or all the way back . Has happened multiple times and also twice while driving. • Safety at risk could have made me wreck my vehicle if I hadn’t pulled over and the seat stopped what it was doing front and back. • yes , been checked by dealership (4) times in service department. •yes, every code on the dash has appeared and lasted a total 20 minutes and car went into limp mode. Couldn’t turn car on or off. First happen in Dec 2025. There has been multiple issues wit…”
NHTSA complaint #11711981, 2025

Seats 2

“• Driver seat not setting its memory for the driver , and will move on its own and go all the way to dash while setting in it or all the way back . Has happened multiple times and also twice while driving. • Safety at risk could have made me wreck my vehicle if I hadn’t pulled over and the seat stopped what it was doing front and back. • yes , been checked by dealership (4) times in service department. •yes, every code on the dash has appeared and lasted a total 20 minutes and car went into limp mode. Couldn’t turn car on or off. First happen in Dec 2025. There has been multiple issues wit…”
NHTSA complaint #11711981, 2025

“The headrest on the third row is locked in the upright position and won't fold down. I've looked online and it seems to happen in every ford explorer in the current generation, 2020+. I see hundreds of complaints online. Across the forums and reddit.”
NHTSA complaint #11700304, 2025

Steering 2

“Purchased new from dealer. At 3500 miles, noticed rattling and clunking noise under front end, more noticeable at speeds less than 35. Took to dealer who diagnosed as worn struts, saying shocks and struts need to be replaced, but they need to order parts. When asked if safe to drive, was told "yes", but "avoid potholes". Now waiting to hear from dealer when parts come in. They stated it would take 4 to 5 hours to repair/replace.”
NHTSA complaint #11635531, 2024

“The contact owns a 2024 Ford Explorer. The contact stated while driving approximately 30-40 MPH in cold weather, the vehicle started making an abnormal clunking and rattling sound near the wheels. The contact was unable to determine the source of the noise. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 24V091000 (SUSPENSION, STEERING). The vehicle was taken to the local dealer, where it was diagnosed that the front struts were worn and needed to be replaced. The dealer recommended that the contact not drive the vehicle. The…”
NHTSA complaint #11633176, 2024

Air Bags 1

“The contact owns a 2024 Ford Explorer. The contact stated that while driving 65 MPH, the contact struck a deer with the front of the vehicle. There was no property damage reported. The vehicle came to a stop shortly afterwards. The contact stated that the air bags had not deployed. The vehicle was towed to a local dealer. There was no warning light illuminated. The vehicle was not destroyed. No injuries were reported. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.”
NHTSA complaint #11691606, 2025

Back Over Prevention 1

“This vehicle has a 360 camera system that was not included, despite is being included in the component package that is standard for this vehicle. I contacted the dealer directly, informed them that there are cameras installed on the vehicle, but only the rear camera is operational. Further investigation into the matter revealed that Ford apparently "recalled" the camera systems on the Explorer for the 2023 models, but has not distributed any information to its dealers. Now I have a forward facing camera that is not operational, but the vehicle's warning system continually advises me there i…”
NHTSA complaint #11595059, 2024

Engine 1

“• Driver seat not setting its memory for the driver , and will move on its own and go all the way to dash while setting in it or all the way back . Has happened multiple times and also twice while driving. • Safety at risk could have made me wreck my vehicle if I hadn’t pulled over and the seat stopped what it was doing front and back. • yes , been checked by dealership (4) times in service department. •yes, every code on the dash has appeared and lasted a total 20 minutes and car went into limp mode. Couldn’t turn car on or off. First happen in Dec 2025. There has been multiple issues wit…”
NHTSA complaint #11711981, 2025

Lane Departure 1

“The contact owns a 2024 Ford Explorer. The contact stated while driving 65-70 MPH on two occasions, the Lane Keep Assist malfunctioned and the vehicle veered out of the intended lane. The contact was able to recover control of the vehicle to remain in the intended lane. Additionally, while driving 40-45 MPH, the Lane Keep Assist veered the vehicle out of the intended lane and the vehicle side swiped the barrier wall. There were unknown warning lights illuminated. There were no reported injuries. There was no air bag deployment. The contact stated that a Police report was not filed. The vehicle…”
NHTSA complaint #11614410, 2024

Latches/Locks/Linkages 1

“The contact rented a 2024 Ford Explorer. The contact stated that while driving at approximately 15-20 MPH, the hood became ajar, raised up, and struck the windshield. The windshield shattered and sprayed shards of glass onto the occupants inside the vehicle. There were no reported injuries. The Police were called to the scene and filed a Police report. The vehicle was towed to the rental facility. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown. The VIN was not available.”
NHTSA complaint #11581954, 2024

Power Train 1

“Hello, I bought 2024 ford explore in Aug 2024 with a few hundred miles on it!! Now two months down the road with 5500miles on it, it is jerking real hard when driving or passing vehicles and slowing down!! The drive mode is in normal at all times. I took it back to where I bought it in Booneville does place and they sent me to ford place in Paris ark where they are ordering a part to see if it fix it or if I need a new transmission. Is this a lemon or what”
NHTSA complaint #11619992, 2024

Seat Belts 1 1 crash 3 injury

“During a severe, multi-lane impact crash, the second-row outer seatbelts completely failed to maintain restraint and failed to retract. Both occupants in the second-row outer seating positions (ages 5 and 7) sustained visible seatbelt friction burns on their arms from the initial impact, but immediately following the crash, both seatbelts were found completely broken, with all slack pulled completely out and zero mechanical retraction. Both children were found entirely unbuckled and unrestrained immediately following the impact. This vehicle is a Ford Explorer, and this failure matches the ex…”
NHTSA complaint #11744835, 2026 · crash · 3 injury(ies)