2024 Ford Bronco Sport Problems & Owner Complaints

Electrical System 25 1 crash 3 fire

“The contact owned a 2024 Ford Bronco Sport. The contact stated that while driving into the driveway and coming to a complete stop, the contact became aware of steam coming from underneath the hood and believed that the engine was overheating. No warning light was illuminated on the instrument panel prior to the vehicle catching on fire. The contact and his wife were inside the vehicle were in the vehicle during the failure. The driver and the passenger exited the vehicle safely. There was grey and white odorless smoke coming from the vehicle. The contact stated that the fire originated in the…”
NHTSA complaint #11753141, 2026 · fire

“Driving on [XXX] . I smelled gasoline. My entire car smelled of it. Next I got a notification to service my vehicle soon. I immediately pulled over and called two Ford dealerships. Downers Grove and Naperville. Neither helped. I located I was close to a dealership. I went there. This is where I learned that underneath my car, wires had caught fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)”
NHTSA complaint #11733616, 2026 · fire

“On [XXX], my 2024 Ford Bronco Sport spontaneously burst into flames while driven by my [XXX] son. Per a local bystander, there was smoke and fire observed around the undercarriage as he drove down the road. Multiple vehicles began honking while stopped at a red light. A driver alerted my son of the fire. He was able to evacuate along with his [XXX] sister. As they were fleeing to the median of an active highway, the vehicle burst into flames. After several explosions the vehicle continued to burn and melt until the fire dept extinguished the flames. Prior to spontaneous combustion, ther…”
NHTSA complaint #11593802, 2024 · fire

Engine 20 1 fire

“On [XXX], my 2024 Ford Bronco Sport spontaneously burst into flames while driven by my [XXX] son. Per a local bystander, there was smoke and fire observed around the undercarriage as he drove down the road. Multiple vehicles began honking while stopped at a red light. A driver alerted my son of the fire. He was able to evacuate along with his [XXX] sister. As they were fleeing to the median of an active highway, the vehicle burst into flames. After several explosions the vehicle continued to burn and melt until the fire dept extinguished the flames. Prior to spontaneous combustion, ther…”
NHTSA complaint #11593802, 2024 · fire

“This is not a complaint against the dealership, but against the individual that was in charge of compliance. I am an attorney in Maine and it started with the fact that under main law, a dealer has to give two keys and if they don’t have it for free calibrated, and I got one key in the master key was not given, and there was issues with that and the compliance guy and finance a warranty guy whose name I forget, but they know who he is cause I’ve talked to them. He told me he had never heard of it and I showed him the statute and I just didn’t argue but then February 7 six days after the recall…”
NHTSA complaint #11749844, 2026

“How long does Ford have to fix a recall for fuel injection that could cause a fire? I was notified 11 months ago and there still is no word of a correction to the issue”
NHTSA complaint #11745103, 2026

Fuel/Propulsion System 19 3 fire

“Driving on [XXX] . I smelled gasoline. My entire car smelled of it. Next I got a notification to service my vehicle soon. I immediately pulled over and called two Ford dealerships. Downers Grove and Naperville. Neither helped. I located I was close to a dealership. I went there. This is where I learned that underneath my car, wires had caught fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)”
NHTSA complaint #11733616, 2026 · fire

“Our 2024 Bronco Sport Outer Banks, 1.5 liter engine, purchased new from a Ford dealer 11/2024, serviced at the dealership and driven less than 14k miles, was destroyed by a spontaneous fire 3/22/2026. After driving 12 miles, we parked in a parking lot. Upon exiting the car we noticed a burning smell and saw small plumes of steam or smoke coming from under the car hood. Within a minute a red/orange disc of heated metal became visible on the hood surface as flames came from under the hood. Seven minutes later the fire department arrived extinguishing the fire. The car was destroyed. There wer…”
NHTSA complaint #11727373, 2026 · fire

“On [XXX], my 2024 Ford Bronco Sport spontaneously burst into flames while driven by my [XXX] son. Per a local bystander, there was smoke and fire observed around the undercarriage as he drove down the road. Multiple vehicles began honking while stopped at a red light. A driver alerted my son of the fire. He was able to evacuate along with his [XXX] sister. As they were fleeing to the median of an active highway, the vehicle burst into flames. After several explosions the vehicle continued to burn and melt until the fire dept extinguished the flames. Prior to spontaneous combustion, ther…”
NHTSA complaint #11593802, 2024 · fire

Unknown Or Other 18

“This is not a complaint against the dealership, but against the individual that was in charge of compliance. I am an attorney in Maine and it started with the fact that under main law, a dealer has to give two keys and if they don’t have it for free calibrated, and I got one key in the master key was not given, and there was issues with that and the compliance guy and finance a warranty guy whose name I forget, but they know who he is cause I’ve talked to them. He told me he had never heard of it and I showed him the statute and I just didn’t argue but then February 7 six days after the recall…”
NHTSA complaint #11749844, 2026

“Vehicle's "infotainment center" is totally dead. No backup camera & I am disabled, have great difficulty turning around to see when I back up (I've had a cervicle spinal fusion which limits my field of vision). Dealer states no other complaints & Ford cannot provide a fix for even just the backup camera problem until Oct.”
NHTSA complaint #11742886, 2026

“Sometimes the Ford Bronco will hesitate to move from a stop position especially when the auto start and stop has been engaged during periods of driving. Also the vehicle hesitated when trying to change lanes. I had to push gas peddle all the way down in order to get into another lane. Several times the light is green for me to go and there is several seconds of hesitation and then the vehicle would go. The severity of these issues occurred in the months of April and May 2026, but I have taken vehicle into 2 different dealerships and they can't seem to locate problem”
NHTSA complaint #11740072, 2026

Power Train 17 3 crash 2 fire 1 injury

“I believe the transmission has an issue. The car was started and it quickly went into reverse and sped up trapping my wife between the door and a tree as she was exiting the vehicle to swap seats for me to drive. No known warnings were issued by the vehicle prior to the incident on 6/7/2025. The previous recall for the BCM & PCM was completed on 2/27/2025 by our local Ford dealer”
NHTSA complaint #11665543, 2025 · crash · 1 injury(ies)

“Driving on [XXX] . I smelled gasoline. My entire car smelled of it. Next I got a notification to service my vehicle soon. I immediately pulled over and called two Ford dealerships. Downers Grove and Naperville. Neither helped. I located I was close to a dealership. I went there. This is where I learned that underneath my car, wires had caught fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)”
NHTSA complaint #11733616, 2026 · fire

“The contact owns a 2024 Ford Bronco. The contact stated while driving at an undisclosed speed, the contact noticed a burning odor in the interior of the vehicle. The contact stated an error message indicated service 4WD was displayed. In addition, the contact stated that when the vehicle was parked in the garage, the contact noticed a burning odor on the exterior of the vehicle. The vehicle was taken to the dealer, however the failure was not duplicated. The dealer performed an oil change. The contact stated that seven days later, the failure occurred. The contact stated while driving at an u…”
NHTSA complaint #11665096, 2025 · fire

Fuel System 11

“The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and referred the contact to the dealer for assistance. The contact had not experienced a failure.”
NHTSA complaint #11753552, 2026

“The contact owns a 2024 Ford Bronco Sport The contact received notification of NHTSA Campaign Number: 25V467 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available.  The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.”
NHTSA complaint #11741597, 2026

“The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). However, the parts required to complete the recall repair are not yet available. The contact has not contacted a dealer. The vehicle has not been diagnosed or repaired. The manufacturer was made aware of this issue and informed the contact that a remedy is not currently available. The manufacturer further stated that a second notification letter will be issued once the remedy becomes available. The contact stated that the manufacturer has exceeded a reasonab…”
NHTSA complaint #11735825, 2026

Service Brakes 5 1 crash

“• What component or system failed or malfunctioned, and is it available for inspection? The brake system on my 2024 Ford Bronco Sport failed to respond for approximately 2–3 seconds after I pressed the brake pedal. This occurred immediately after freeing my foot from underneath the gas pedal while cruise control was active. The vehicle is available for inspection. • How was your safety or the safety of others put at risk? The vehicle did not slow down when the brake pedal was fully pressed, causing me to enter an intersection while other vehicles were turning. I had to swerve to avoid a colli…”
NHTSA complaint #11701629, 2025 · crash

“On March 17, 2026, during an oil change service at Mullinax Ford of Kissimmee, located at 1810 E Irlo Bronson Memorial Hwy, Kissimmee, FL, I reported several concerns, including a clicking noise, a rough braking noise, and a whiplash-like sensation when engaging Drive. I was also advised that I was nearing the time for a brake fluid flush because the vehicle was around 24,000 miles. On April 15, 2026, I returned to Mullinax Ford for the brake fluid flush. The same concerns were again noted, but I was told the vehicle checked out and that there were no issues with the brakes. I picked up the ve…”
NHTSA complaint #11734721, 2026

“I purchased my vehicle 6 months ago. I had no prior issues outside of a rough drive or a very slight burning smell from time to time. 12/2025 I found out through my auto insurance that my vehicle had a active safety recall (25S76) so I scheduled with my local Ford to get the temp software PCM update done until the remedy becomes available. Immediately after the software update I started getting a lot of system error codes; keys not detected, airbag fault, Tailgate open (when it wasnt), auto hold system fault, auto start/stop system fault, etc.. During this time I had issues with my break syste…”
NHTSA complaint #11711867, 2026

Structure 4

“On XXX, driving at a relatively low rate of speed coming off the on-ramp from [XXX] onto [XXX], the hood of our Thrifty rental vehicle, a 2024 Ford Bronco, suddenly and without warning, flew up and completely obstructed the windshield. As we had just entered the highway we were quite fortunate to have been in the right hand lane and able to safely pull into the breakdown lane. And even more fortunate that there were not cars immediately ahead or behind us that we could have hit. And third, very fortunate that the force of the hood did not shatter the windshield. The hood flew up with such forc…”
NHTSA complaint #11743267, 2026

“The rear quarter panel glass on the vehicle's passenger side cracked. This is consistent with Recall Reference Number: 24S10 in which the adhesion of the glass is known to fail.”
NHTSA complaint #11674608, 2025

“Moof roof popped up from the center ripping at all edges, causing loud boom sound. Glass shattered. No drastic change in temperature. No impact of object. Newly purchased. Dropped off at dealership to investigate.”
NHTSA complaint #11631579, 2024

Tires 4

“225/65 R 17 A small sliver of wood Punctured the sidewall which is unbelievable that a tire would be that weak from what appears to be a blunt puncture on a Ford Bronco Sport made for all kinds of off and on road driving conditions and something as small as a flattened tooth pick would be sufficient as a safe tire. Looking at continental tires track record with sidewall rubber structural issues I suspect this is another defect and should be investigated and recalled before causing property damage ,serious injury or death due to sidewall issues .”
NHTSA complaint #11731308, 2026

“The contact owns a 2024 Ford Bronco Sport equipped with Continental Tires, Tire Line: Cross Contact, Tire Size: 225/65R/17, and DOT Number: [XXX] . The contact stated that while driving at approximately 70 MPH, the contact heard an abnormally loud sound coming from the rear end of the vehicle, and the contact noticed that the rear passenger's side tire had sustained a blowout. Upon inspection, it was discovered that the tread of the tire had separated. The dealer was contacted. The vehicle was not diagnosed or repaired. The tire was original equipment. The tire was not replaced. The manufactur…”
NHTSA complaint #11677823, 2025

“All 4 Continental PRO CONTACT TX tires on 1 week old brand new purchased Ford Bronco Sport VIN [XXX] from Ford Dealer Swelling on Sidewalls in various points. After researching amongst other Bronco Sport Forums issue appears to be common failure on New Bronco Sports equipped with Continental PRO CONTACT TX tires. Requested tires to be changed at Dealer, they found 1 Bronco Sport with Balled up Sidewall issues and wanted to replace "like for like" admitting they have a some sort of FACTORY defect but would not exchange tires for ones with "OUT" Factory Defect. I believe there is Faulty Constru…”
NHTSA complaint #11610618, 2024

Back Over Prevention 3 1 crash

“My backup camera one two separate occasions has not operated properly. First time it never showed a vehicle had come up behind me. Didn’t go off with any notice. I backed into a car. Second time a man with a cart walk behind as I was backing out no notice. There is a recall on review camera but not on my vin.”
NHTSA complaint #11663968, 2025 · crash

“My car was parked in my driveway and I parked it up by the driveway door when I came out the next day my car was at the end of the driveway nobody broke in it it was still locked but that was strange then it seemed like every time I'm driving this car it doesn't want to give me power to drive the car I just took it out of town and red lights start popping on inside the dashboard stating something about transmission fluid cooling something I have been to the dealership quite a few times in reference to the car not getting enough power They keep saying nothing wrong with this car but it's someth…”
NHTSA complaint #11738678, 2026

“The entire Advanced Drive Assistants Systems only works when it feels like it. Thankfully I haven't had any accidents yet..., but I have come very close to it three times. Especially when the lane system went down, it almost sent me into the car next to me.”
NHTSA complaint #11660856, 2025

Steering 3

“Clonninger Auto Body Shop 511 Jake Alexander Blvd S Salisbury NC 28147 The 2024 Bronco Sport owned by Megan Michaels was presented to our service department with a customer concern of a rattling noise coming from the rear of the vehicle, along with abnormal tire wear on the rear tires. Our Master Technician performed a road test and verified a clunking/rattling noise originating from the left rear of the vehicle. The vehicle was then lifted, and a comprehensive inspection of the rear suspension system was completed. During inspection, it was determined that the left rear lower control arm mo…”
NHTSA complaint #11733219, 2026

“Chattering/screeching from right side of the car. Near tires. Took it in and showed example to technician and he heard it. Comes when turning right or backing up right slowly. They discovered it was the rear differential unit and it will be in the shop for 1-2 weeks.”
NHTSA complaint #11676989, 2025

“The steering is temporarily disabled when the vehicle is in the auto off/fuel saver mode. I had an approaching EMS vehicle that I was almost struck by because my vehicle was off due to that feature. The steering wheel was not responsive.”
NHTSA complaint #11652400, 2025

Vehicle Speed Control 3

“I don’t know the exact name of the system that failed but my Bronco would not accelerate after making complete stops. When I would press on the gas pedals to move from a stopped position the Bronco would move very very slowly which in turn almost caused me to have over 3 car accidents as when I would press the gas to move from a stopping position it would move forward very slowly no matter who much pressure I would put on the gas pedal which in turn the oncoming cars almost hit me. I took the Bronco to the dealership and they said they had to reprogram the acceleration but that it could take u…”
NHTSA complaint #11691255, 2025

“The Powertrain of this Ford Bronco Sport (2024) with only 12,000 miles on it malfunctioned while the driver was on a major highway. No control over gears, engine power, etc. Had to pull over in heavy traffic. Fortunately there was a shoulder, or this would have been a major safety risk for the driver and other vehicles and would likely have resulted in an accident. Apparently, this malfunction is related to battery issues as well and can affect the emergency caution flashers. The vehicle was inspected by Ford after being towed to a local dealership and was told that this was part of a reca…”
NHTSA complaint #11672731, 2025

“THIS CAR HAS LESS THAN 2,500 MILES ON IT, AND IT FAILED TO GO INTO GEAR WHEN PULLING OUT ON A MAJOR HIGHWAY. WHEN IT DID SLIP INTO GEAR, IT WOULD ONLY GO 10 MPH THE WHOLE WAY HOME. MULTIPLE ALERTS WERE SENT TO MY PHONE; SEE BELOW FOR SPECIFIC ALERT INFO. THE DEALERSHIP SAID IT WAS A LOOSE WIRE AFTER TELLING ME THEY WOULD REPLACE THE CAR, AND OVER 60 SENSORS WENT OFF. ALERTS: SERVICE ENGINE WARNING POWERTRAIN MALFUNCTION REDUCED POWER PRE-COLLISION ASSISTANCE NOT AVAILABLE”
NHTSA complaint #11636521, 2025

Visibility/Wiper 3

“The wiper will be on and if I turn it on high it will just be low or medium”
NHTSA complaint #11752776, 2026

“The vehicle was bought brand new in February of this year, 2025. Was bought and has been driven by my daughter who turned [XXX] this year. She went to camp and the vehicle sat behind the house till she got back. the vehicle and front windshield face west and is exposed to the summer sun from 11:30 till 8pm. When she got back and went to drive the car on [XXX], there was a large stress crack in the middle of the windshield. (will attach pictures if possible with this online form). I had my neighbor check his security camera to see if anyone had vandalized the vehicle or if there had been any l…”
NHTSA complaint #11672335, 2025

“The windshield on this vehicle is faulty. On online forms, others have commented on the same thing I am experiencing: the integrity of this windshield is so weak that within a couple months (sometimes just a few days) of having the vehicle, you can get multiple chips or cracks. On my last chip, I was driving on a Michigan highway at least 30 yards from other vehicles when something chipped my windshield. I've had the windshield chip while going 65mph on the high way, and also while my vehicle was at a standstill at a red light and the car in front of me pulled away quickly, kicking up debris…”
NHTSA complaint #11655123, 2025

Forward Collision Avoidance 2

“Front seats Cause back and hip pain and fatigue on trips over 30 mins- head rest don’t adjust to help compensate putting in awkward positioning. The automatic braking or whatever signifies your close to objects in the front has randomly breaked hard with nothing near me almost resulting in being rear rear ended.”
NHTSA complaint #11748577, 2026

“Passenger seatbelt doesn’t loosen up driven normal. Adaptive cruise control doesn’t work, never has. I didn’t know about it until Monday I am taking it to a ford dealership today at Ken Garff Ford. .”
NHTSA complaint #11745204, 2026

Lane Departure 2 1 crash

“My backup camera one two separate occasions has not operated properly. First time it never showed a vehicle had come up behind me. Didn’t go off with any notice. I backed into a car. Second time a man with a cart walk behind as I was backing out no notice. There is a recall on review camera but not on my vin.”
NHTSA complaint #11663968, 2025 · crash

“The entire Advanced Drive Assistants Systems only works when it feels like it. Thankfully I haven't had any accidents yet..., but I have come very close to it three times. Especially when the lane system went down, it almost sent me into the car next to me.”
NHTSA complaint #11660856, 2025

Latches/Locks/Linkages 2

“The contact rented a 2024 Ford Bronco Sport. The contact stated that while driving approximately 30-35 MPH, the hood flew open, struck and cracked the windshield, completely obstructing the driver's visibility. The contact pulled over to the curb and then into a parking lot. The contact stated that he was disabled, and that the failure was significantly frightening. The contact was shaking for 30 minutes after the failure. The contact stated that the vehicle was a replacement rental vehicle that the car rental company had provided after the initial rental vehicle shuddered and stalled while dr…”
NHTSA complaint #11731655, 2026

“The contact owns a 2024 Ford Bronco Sport. The contact stated that the driver's side front door locked without unintendedly. There were no warning lights illuminated. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 300.”
NHTSA complaint #11575742, 2024

Suspension 2

“Clonninger Auto Body Shop 511 Jake Alexander Blvd S Salisbury NC 28147 The 2024 Bronco Sport owned by Megan Michaels was presented to our service department with a customer concern of a rattling noise coming from the rear of the vehicle, along with abnormal tire wear on the rear tires. Our Master Technician performed a road test and verified a clunking/rattling noise originating from the left rear of the vehicle. The vehicle was then lifted, and a comprehensive inspection of the rear suspension system was completed. During inspection, it was determined that the left rear lower control arm mo…”
NHTSA complaint #11733219, 2026

“Chattering/screeching from right side of the car. Near tires. Took it in and showed example to technician and he heard it. Comes when turning right or backing up right slowly. They discovered it was the rear differential unit and it will be in the shop for 1-2 weeks.”
NHTSA complaint #11676989, 2025

Visibility 2

“The contact owns a 2024 Ford Bronco Sport. The contact stated that while the vehicle was parked outside, the front windshield cracked. The front windshield had a long horizontal crack. There was no warning light illuminated. Upon inspection, the crack had started from the inside of the windshield. The vehicle was taken to the dealer where it was inspected. The contact was informed that the windshield had cracked due to stress from sun exposure. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 3,500.”
NHTSA complaint #11673709, 2025

“I was driving down the highway, and my moonroof exploded. I thought something had exploded or someone had shot at me. No other cars were around me that could have caused something to pop up and hit the roof. I did take it to the dealership service where photos were taken and submitted for a possible claim on the warranty. I only have about 2000 miles on the vehicle. My first payment isn't even due yet. Ford warranty declined the claim. It looked like it exploded upwards leading me to think this was an installation or material issue. Glass that exploded out flew off the roof of the vehicle scra…”
NHTSA complaint #11660926, 2025

Engine And Engine Cooling 1

“The contact owns a 2024 Ford Bronco Sport. The contact stated that while starting the vehicle, there was a ticking sound coming from the engine compartment. There was no warning light illuminated. Additionally, while driving at an undisclosed speed, the contact smelled a fuel odor. The Mobile App indicated that the VIN was associated with NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, parts were not yet available for the recall repair. The vehicle was taken to a dealer, and a software update was performed related to the recall, but the dealer confirmed that parts were still…”
NHTSA complaint #11709937, 2026

Seat Belts 1

“Passenger seatbelt doesn’t loosen up driven normal. Adaptive cruise control doesn’t work, never has. I didn’t know about it until Monday I am taking it to a ford dealership today at Ken Garff Ford. .”
NHTSA complaint #11745204, 2026

Seats 1

“Front seats Cause back and hip pain and fatigue on trips over 30 mins- head rest don’t adjust to help compensate putting in awkward positioning. The automatic braking or whatever signifies your close to objects in the front has randomly breaked hard with nothing near me almost resulting in being rear rear ended.”
NHTSA complaint #11748577, 2026