2024 Chevrolet Colorado Problems & Owner Complaints

Electrical System 34 1 crash 1 fire 1 injury

“I was driving the truck and first I got a "Software Update Needed Vehicle must be parked and off" this was followed quickly be a "low tire pressure alarm" 3 times in a short distance then I got a message "Antilock brake issue do not drive over 62 MPH or vehicle may not stop" then the brakes began to randomly slam on and release and smoke began to come out of the air vents. The next alarm was "ESV Shutting down " and I lost power steering and brakes; I tried getting the vehicle off the road out of the traffic lanes and the smoke was rapidly increasing in the cab then the engine shut down and I…”
NHTSA complaint #11662746, 2025 · fire · 1 injury(ies)

“My teenage son was involved in an accident because of distraction caused by his he dashboard. Upon taking right turns with the right blinker, the LEFT blinker would subsequently illuminate for at least 4 blinks. Additionally, the CHECK ENGINE light was also illuminated. The vehicle only had less than 90miles on it. As he took a right turn at a 4 way stop, he was distracted by the left blinker and attempted to turn off the blinker manually which caused him to steer into the curb which them caused him to lose control and his a brick mailbox. $8500 worth of vehicle damage and $1500 worth of mail…”
NHTSA complaint #11616848, 2024 · crash

“The turn signal has an intermittent condition. When I put the right turn signal indicator on to signal a right turn, after the turn is completed and the turn signal stick returns to the off position my left turn signal with signal a left turn flashing approximately 2-3 times before turning off. I took it to the local Chevrolet dealer maintenance shop and they told me the replaced the turn signal stick, however a few days later the same problem occurred again. I have also learned online that other owners have had the same issue with their Colorado pickup trucks also.”
NHTSA complaint #11746174, 2026

Service Brakes 25 3 crash 3 injury

“The vehicle is registered to me; my mother was the driver at the time of the failure. At ~2,963 miles, the truck developed intermittent check engine and ABS warning lights. The dealer pulled DTC C058A (brake system control module) and P25A2. Per GM bulletin PIT6012A, the battery was replaced and a brake plunger motor sensor learn was performed. The same codes returned within weeks. The dealer then diagnosed internal failure of the brake master cylinder and reservoir, documented the vehicle as "unsafe to drive," and replaced both under warranty. The truck sat at the dealer over six weeks due to…”
NHTSA complaint #11732446, 2025 · crash · 1 injury(ies)

“The contact owns a 2024 Chevrolet Colorado. The contact stated while driving 10 MPH and approaching a stopped traffic, the contact stated that the sun temporarily blinded his vision of the roadway. The contact depressed the brake pedal, but the vehicle failed to respond and crashed into a stopped motorcycle, causing the motorcycle and the motorcyclist to fall to the ground. Additionally, the contact stated that the vehicle was designed with the Forward Collision Avoidance: Automatic Emergency Braking (AEB) system, which failed to engage as designed. The motorcycle rider was able to escape the…”
NHTSA complaint #11636046, 2025 · crash · 1 injury(ies)

“there have about 4 incidents where my vehicle has engaged the automatic emergency breaks while I’m driving, even though there are no cars around me close enough to cause that reaction. called 911 on most recent incident to get medical evaluation to check chest from seat belt sudden locking”
NHTSA complaint #11722333, 2026 · 1 injury(ies)

Forward Collision Avoidance 22 3 crash 2 injury

“The contact owns a 2024 Chevrolet Colorado. The contact stated while driving 10 MPH and approaching a stopped traffic, the contact stated that the sun temporarily blinded his vision of the roadway. The contact depressed the brake pedal, but the vehicle failed to respond and crashed into a stopped motorcycle, causing the motorcycle and the motorcyclist to fall to the ground. Additionally, the contact stated that the vehicle was designed with the Forward Collision Avoidance: Automatic Emergency Braking (AEB) system, which failed to engage as designed. The motorcycle rider was able to escape the…”
NHTSA complaint #11636046, 2025 · crash · 1 injury(ies)

“there have about 4 incidents where my vehicle has engaged the automatic emergency breaks while I’m driving, even though there are no cars around me close enough to cause that reaction. called 911 on most recent incident to get medical evaluation to check chest from seat belt sudden locking”
NHTSA complaint #11722333, 2026 · 1 injury(ies)

“While driving in heavy and slow moving traffic at approximately 15 mph, the vehicle in front stopped. The forward collision and automatic emergency braking failed to activate. These safety features are not a replacement for active driving attention, but if they properly function and activate, they could have prevented the rear end collision that occurred.”
NHTSA complaint #11650386, 2025 · crash

Engine 19

“The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 35k miles). You can check the Colorado Chevy forum, youtube, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its…”
NHTSA complaint #11737678, 2026

“Truck has 36,669 miles check engine light came on and was idling loud, after being looked at my a Chevrolet dealership came back a faulty radiator hose, and coolant was leaking. Too new of truck for this kind of problem”
NHTSA complaint #11735626, 2026

“Coolant leaking from the upper radiator inlet hose connection. The Malfunction Indicator Lamp (MIL) illuminated in the Driver Information Center (DIC).”
NHTSA complaint #11732332, 2026

Unknown Or Other 15 1 fire 1 injury

“I was driving the truck and first I got a "Software Update Needed Vehicle must be parked and off" this was followed quickly be a "low tire pressure alarm" 3 times in a short distance then I got a message "Antilock brake issue do not drive over 62 MPH or vehicle may not stop" then the brakes began to randomly slam on and release and smoke began to come out of the air vents. The next alarm was "ESV Shutting down " and I lost power steering and brakes; I tried getting the vehicle off the road out of the traffic lanes and the smoke was rapidly increasing in the cab then the engine shut down and I…”
NHTSA complaint #11662746, 2025 · fire · 1 injury(ies)

“The turn signal system intermittently malfunctions. When using the turn signal, the auto-cancel function sometimes activates the opposite signal, and at times the stalk does not stay engaged when attempting to signal. This creates a safety risk because surrounding drivers may receive the wrong turning/lane-change indication or no indication at all. The issue has occurred intermittently while driving and has been presented to Cox Chevrolet in Bradenton, Florida multiple times. Cox Chevrolet has verified turn-signal over-cancel and performed prior repairs/programming. However, the issue has not…”
NHTSA complaint #11741857, 2026

“My dog and I were headed to Home Depot on [XXX] when without any warning there was a very loud boom. My first thought was that we had been shot at. Once I gathered myself I realized the sunnroof glass had exploded. I rarely open the sunroof but do on occasion have the shade open, luckily it wasn’t open or my dog and I would have been sprayed with the glass which could have caused serious eye injury and potentially a crash. I’ve had 2 Chevy dealers tell me that is not a warranty issue that it was likely caused by a rock being thrown up. I do not believe this was the case. The closest vehicle w…”
NHTSA complaint #11741055, 2026

Power Train 13

“Vehicle intermittently lunges forward during the 2nd-to-1st downshift, even while the brakes are being applied. When this occurs, the vehicle unexpectedly accelerates or surges forward slightly, travels farther than anticipated, and feels similar to being bumped from behind. Because the condition occurs at low speeds, often in tight areas such as parking spaces, stop-and-go traffic, or before a crosswalk, it creates a risk of collision with pedestrians, vehicles, or objects. The issue has been reported to Cox Chevrolet in Bradenton, Florida multiple times, but continues to happen.”
NHTSA complaint #11741859, 2026

“Check engine light with codes p0700 and p2796 has been happening for months with multiple failed repair attempts. Vehicle was returned to me by the dealer supposedly fixed. I drove it 15 minutes to the high school for an art fair my daughter was in. They (my family) rode with me home. Check engine light was on again. On the way home, the transmission was acting strange, not shifting properly. About half way home, it got stuck in a gear at 3500 or so rpms and would not shift. I tried the manual shifter, and it didn’t work. Stuck in gear. Concern was that we were approaching a hill when…”
NHTSA complaint #11732174, 2026

“I have a 2024 Chevy Colorado Trail Boss that needs an Upper Radiator Coolant Hose. But apparently this is on nationwide backorder because although there is not a recall GM put a bulletin out they are aware of the issue that appears to be a degraded seal inside hose fitting so the whole hose needs replacing. I live in [XXX] and it is not available here and I have called OH, [XXX] , [XXX] and other state dealerships and Noone will sell that part because of the backorder. My truck has 40k miles. And every dealer I called this is a huge issue with these trucks. So it is not a wear issue when it…”
NHTSA complaint #11727584, 2026

Exterior Lighting 11

“The turn signal system intermittently malfunctions. When using the turn signal, the auto-cancel function sometimes activates the opposite signal, and at times the stalk does not stay engaged when attempting to signal. This creates a safety risk because surrounding drivers may receive the wrong turning/lane-change indication or no indication at all. The issue has occurred intermittently while driving and has been presented to Cox Chevrolet in Bradenton, Florida multiple times. Cox Chevrolet has verified turn-signal over-cancel and performed prior repairs/programming. However, the issue has not…”
NHTSA complaint #11741857, 2026

“Right turn signal auto cancel activates the left lane change signal resulting in oncoming traffic assuming a left turn to be performed but this vehicle continues straight resulting in a collision hazard. This has been happening since the purchase of the vehicle 2.5 years ago but dealer is unwilling to fix.”
NHTSA complaint #11710728, 2026

“The contact owns a 2024 Chevrolet Colorado. The contact stated that while attempting to activate the right turn signal, the left turn signal was displayed. No warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed with an overcorrection and overcancellation of the signals. The vehicle was not repaired. The manufacturer was contacted, and the failure was confirmed, but no assistance was provided. The failure mileage was approximately 8,000. The VIN was not available.”
NHTSA complaint #11728713, 2025

Steering 6

“At 20,300 miles, severe chassis and steering wheel vibration occurred during high-speed highway descents while braking. Safety risk: reduced steering control at highway speed. The vehicle was inspected by a franchised Chevrolet dealer in Lakewood, CO. The technician's written service notes document rear rotor Lateral Runout (LRO) of 0.006 inches against GM's maximum allowable specification of 0.002 inches per GM Service Bulletin 00-05-22-002 — 3x the engineering limit. The defect was confirmed in dealer documentation and is available for inspection. After I identified this discrepancy, the S…”
NHTSA complaint #11724366, 2026

“1.) While driving signalling for a right hand turn and then subsequently completing the right hand turn, the vehicle then signals left on its own accord. This is distracting for the driver and confusing to other motorists on the road. 2.) Blind spot monitoring system frequently turns on and or blinks rapidly (effects both driver and passenger side mirrors sporadically) when no other vehicles in the same vicinity. Distracting to driver who then is prompted to look around for vehicles that are not there. Quite often the trucks blind spot monitors light up when not a single other vehicle is on…”
NHTSA complaint #11637527, 2025

“The turn signals to not function correctly and give inaccurate signals to other drivers. Most (perhaps all) times, when signaling a right turn, after the right turn signal deactivates, the switch "overcorrects" and signals a left lane change (three blinks to the left). This no doubt leads to confusion to other drivers and could cause a accident. Turn signal must work flawlessly! This problem has been broadly reported on the Chevy Colorado internet forum.”
NHTSA complaint #11634189, 2025

Lane Departure 5 1 crash

“1) All the sensors on the truck relating to the auto emergency breaking, pass sensors, cruise control ETC are malfunctioning, truck was at 10,000 miles at the time and brand new. 2) This feature contributed to an accident on Jan 14 2025. I could not see because of the sun and rear ended the car in front of me. 3)The DTC report on the truck came back and stated 6 errors relating to the systems and sensors to include a data memory loss. 4)Took in for servicing at the dealership and they refused to touch the issue. GM is inspecting the truck Feb 13. 5) There were warning indicators however I thou…”
NHTSA complaint #11641065, 2025 · crash

“The components failing are the (ADAS) components. Specific concerns are with adaptive cruise control, automatic emergency braking, front facing detection camera, and blindside detection. The front facing camera will randomly deactivate prompting a message to check for obstructions as a possibly reason of failure. Upon checking, and also wiping the lense, there is not obstrution. Blindside detection operates at random and at times will stay on for a sustained period without any vehicles near or around my vehicle. This is especially bad at night because the light is extremely bright and directed…”
NHTSA complaint #11662471, 2025

“1.) While driving signalling for a right hand turn and then subsequently completing the right hand turn, the vehicle then signals left on its own accord. This is distracting for the driver and confusing to other motorists on the road. 2.) Blind spot monitoring system frequently turns on and or blinks rapidly (effects both driver and passenger side mirrors sporadically) when no other vehicles in the same vicinity. Distracting to driver who then is prompted to look around for vehicles that are not there. Quite often the trucks blind spot monitors light up when not a single other vehicle is on…”
NHTSA complaint #11637527, 2025

Structure 5

“The contact owns a 2024 Chevrolet Colorado. The contact stated that the roof of the vehicle had several dents. The contact became aware that several similar vehicles had the same dents to the roof. The contact referenced NHTSA ID Number: 11014388 (STRUCTURE) as the cause for the failure; however, the VIN was not included. The dealer was notified of the issue. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 72,000.”
NHTSA complaint #11721483, 2026

“The contact owns a 2024 Chevrolet Colorado. The contact stated that while operating the vehicle, there was a grinding sound coming from the front of the vehicle while turning in either direction. Upon inspection, the contact discovered that the front driver's side wheel well plastic cover was unsecured and had fallen and was rubbing on the front driver’s side tire while turning. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The contact stated that there was a rattling sound coming from the vehicle. Upon inspection…”
NHTSA complaint #11731573, 2025

“Bought a 2024 Chevy Colorado in Dec 2024. Going through a car wash, the air blower put dent in top of the truck. Found out there is a technical service bulletin 23-NA-209 where Chevy admits there is structural issue with bracing of the roof. The TSB also shows where five additional braces are to be added to the roof to give structural integrity. Worried about safety of truck should there be a rollover.”
NHTSA complaint #11699253, 2025

Back Over Prevention 3

“The contact owns a 2024 Chevrolet Colorado. The contact stated that the rearview camera failed to operate while shifted in reverse(R). The contact stated that the vehicle was taken to the dealer on two separate occasions; however, the failure returned after each visit. The contact stated that the dealer had acknowledged the failure; however, the contact was informed that there was no fix for the failure. The vehicle was not repaired. The manufacturer was notified of the failure but offered no additional assistance. The failure mileage was approximately 2,300”
NHTSA complaint #11696643, 2025

“The contact owns a 2024 Chevrolet Colorado. The contact stated that the 360 rearview camera would activate unintendedly while the vehicle was not in reverse(R). The contact stated that the 360 rearview camera had engaged while driving and remained engaged for an extended period of time. The contact stated that the failure had prevented him from activating the headlights as needed through the infotainment system. The vehicle was taken to the dealer, where it was diagnosed that the camera had failed, and the dealer informed the contact that the manufacturer did not have a fix for the failure.…”
NHTSA complaint #11662411, 2025

“While driving my dash and infotainment system shut off and rebooted. This left me without any vehicle information like speed nor any safety assist devices.”
NHTSA complaint #11591186, 2024

Vehicle Speed Control 3

“Vehicle intermittently lunges forward during the 2nd-to-1st downshift, even while the brakes are being applied. When this occurs, the vehicle unexpectedly accelerates or surges forward slightly, travels farther than anticipated, and feels similar to being bumped from behind. Because the condition occurs at low speeds, often in tight areas such as parking spaces, stop-and-go traffic, or before a crosswalk, it creates a risk of collision with pedestrians, vehicles, or objects. The issue has been reported to Cox Chevrolet in Bradenton, Florida multiple times, but continues to happen.”
NHTSA complaint #11741859, 2026

“2024 Chevrolet Colorado with intermittent safety defect at highway speeds. Vehicle displays P215B along with Service ESC, Service Traction Control, and Reduced Acceleration. Speedometer becomes erratic and the vehicle loses reliable speed signal at highway speed. Dealer kept vehicle for 15 days, stated repairs were made, but the same issue returned within about 2 miles of pickup on the highway. Vehicle was returned to dealer immediately. As of April 2, total days out of service will be 21. I do not believe the vehicle is safe to drive or safe to transport my family in. GM case has been opened.…”
NHTSA complaint #11727922, 2025

“Date: [XXX] | Location [XXX] Leaving Costco 1 ½ after entering entrance headed to Savannah. I was traveling at approximately 60 miles a hour with heavy traffic alongside me and a tractor trailer behind me when I felt my Truck quickly de-accelerate on its on. Then I saw the “Sudden Warning on Dashboard, “Reduced Acceleration – Drive with Care” then the 2nd Warning on Dashboard, “ Service Traction Control.” I was almost REAR ENDED by the Tractor Trailer. I was never so startled but I keep my nerve….got over to the right lane at slowed speed (It was weird. Speed slowed but felt like I was in h…”
NHTSA complaint #11585938, 2024

Fuel/Propulsion System 2

“Vehicle intermittently lunges forward during the 2nd-to-1st downshift, even while the brakes are being applied. When this occurs, the vehicle unexpectedly accelerates or surges forward slightly, travels farther than anticipated, and feels similar to being bumped from behind. Because the condition occurs at low speeds, often in tight areas such as parking spaces, stop-and-go traffic, or before a crosswalk, it creates a risk of collision with pedestrians, vehicles, or objects. The issue has been reported to Cox Chevrolet in Bradenton, Florida multiple times, but continues to happen.”
NHTSA complaint #11741859, 2026

“What component or system failed or malfunctioned, and is it available for inspection upon request? The fuel tank failed in a manner rendering the vehicle unusable as it can not be refueled. The fuel tank failed at the inlet, leaking fuel in major quantities during refueling. It is available for inspection. How was your safety or the safety of others put at risk? Major quantities of fuel leaked from the vehicle onto the roadway. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Currently the vehicle is at a dealership awaiting repair. The parts are o…”
NHTSA complaint #11674845, 2025

Visibility/Wiper 2

“Sunroof exploded while driving down the highway. Glass shattered everywhere in the interior as well all over our child car seat. Fortunately I was the only person in the truck at the time. Due to the violence of the incident I had to gain control due to the sound and flying glass. Had all windows and sunroof close with the AC on. Was going approximately 65 mph. Clear sunny day. I have more photos and video if needed. Dealer has been contacted and they will replace the sunroof under warranty.”
NHTSA complaint #11667959, 2025

“I purchased a new 2024 Chevy Colorado Z71 a few weeks ago. The windshield has some manufacturing defects. There are rings inside the glass that cause bad glare. I have tried using window cleaners but the rings are inside the layers of glass. I had the dealership inspect the issues and they confirmed there are flaws in the windshield. Dealership is trying to work with GM on the issue.”
NHTSA complaint #11613831, 2024

Air Bags 1 1 crash 1 injury

“The contact owns a 2024 Chevrolet Colorado. The contact stated that while his employee was driving at 55 MPH, the vehicle hit a deer, but the seat belt did not hold the driver in place. The contact stated that the driver's left side of her chest hit the steering wheel, she hit her head hit the windshield, and when the seatbelt retracted, the driver was pulled back to the seat with force. Additionally, the contact stated that the lap band of the seat belt tightened during the impact and bruised her lower stomach. The air bags did not deploy. The vehicle was knocked into the ditch, and then the…”
NHTSA complaint #11694465, 2025 · crash · 1 injury(ies)

Electronic Stability Control (Esc) 1

“The contact owns a 2024 Chevrolet Colorado. The contact stated that while driving at various speeds, the steering wheel was stiff and difficult to turn in either direction. In addition, the passenger’s side mirror failed to illuminate while another vehicle was passing by as intended. The messages "Reduced Acceleration", "Service Steering", and "Service Drive Train" were displayed on the instrument panel. The ESC warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed; however, the cause of the failure was not yet determined. The contact stated that while driv…”
NHTSA complaint #11679261, 2024

Fuel System 1

“The contact owns a 2024 Chevrolet Colorado. The contact stated that while his wife was driving approximately 60 MPH, the vehicle lost motive power, and failed to exceed 5-8 MPH. The traction control and the check engine warning lights were illuminated after the failure. The contact's wife was able to drive across lanes and pulled over to the right side of the roadway. The vehicle was towed to the dealer, where it was diagnosed with fuel injector failure. The dealer ordered the parts. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approxi…”
NHTSA complaint #11626124, 2024

Seat Belts 1 1 crash 1 injury

“The contact owns a 2024 Chevrolet Colorado. The contact stated that while his employee was driving at 55 MPH, the vehicle hit a deer, but the seat belt did not hold the driver in place. The contact stated that the driver's left side of her chest hit the steering wheel, she hit her head hit the windshield, and when the seatbelt retracted, the driver was pulled back to the seat with force. Additionally, the contact stated that the lap band of the seat belt tightened during the impact and bruised her lower stomach. The air bags did not deploy. The vehicle was knocked into the ditch, and then the…”
NHTSA complaint #11694465, 2025 · crash · 1 injury(ies)

Suspension 1

“At 20,300 miles, severe chassis and steering wheel vibration occurred during high-speed highway descents while braking. Safety risk: reduced steering control at highway speed. The vehicle was inspected by a franchised Chevrolet dealer in Lakewood, CO. The technician's written service notes document rear rotor Lateral Runout (LRO) of 0.006 inches against GM's maximum allowable specification of 0.002 inches per GM Service Bulletin 00-05-22-002 — 3x the engineering limit. The defect was confirmed in dealer documentation and is available for inspection. After I identified this discrepancy, the S…”
NHTSA complaint #11724366, 2026

Visibility 1

“The contact owns a 2024 Chevrolet Colorado. The contact stated that while attempting to add windshield washer fluid to the windshield washer fluid reservoir. The contact stated that the washer fluid failed to pass through the filler neck and enter the reservoir. The vehicle was taken to the dealer, who informed the contact that the failure was due to a poor design flaw and that there was no repair available currently. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 14,000.”
NHTSA complaint #11702710, 2025