2023 Toyota 4Runner Problems & Owner Complaints

Unknown Or Other 12 1 crash

“The car just accelerated while during into parking lot. I used brake but did work and hit on to the pole. It accelerated pretty fast. The parking lot store has a video of me coming in slow and the the car accelerated.”
NHTSA complaint #11663054, 2025 · crash

“Windshield cracked approximately 2” from the bottom all the way across while using the defroster to clear ice from it. I was still parked at the time. I am unsure how long it will stay water tight or become worse. One concern is the crash avoidance and the automatic high beam sensor are both attached to the windshield and don’t want them to fail. I also don’t want the entire piece of glass to shatter and land in my lap while driving. The dealer refused honoring the repair under warranty. They only use one particular repair shop (which I suspect they own) and even quoted me a price for replacin…”
NHTSA complaint #11716332, 2026

“the rear manual tailgate has opened 3 times while the vehicle was at highway speeds and the doors would be locked. the latest incident happened on 1-30-26, at highway speed (70mph) the tailgate opened completely without warning. the indicator on the dash did light up and an alarm did sound. I had been on the road approximately 10 miles without incident before that. this was the third time this happened, although the first two the door did not completely open, only became unlatched but stayed shut. all three times were mornings that were extremely cold. (below -1 F) each time i made sur…”
NHTSA complaint #11714444, 2026

Exterior Lighting 3

“My brand new 2023 Toyota 4Runner has terrible head lights. I see I am not the first person to post this very same complaint either. These headlights NEED to be recalled and replaced by Toyota. I will do my best to describe this, but when driving in the dark there is large shadow cast on the left side of the throw of the lights. It is far in front of the car, just before the light tapers off into darkness. But it's not just that the headlights are uneven, I have light that surrounds the dark spot. So it's like I'm constantly chasing an animal. The 4Runner has a soft suspension, so every small b…”
NHTSA complaint #11553600, 2023

“The headlight pattern of the low beam lights has a large dark area at the 10 to 11 O'clock position that appears in the oncoming traffic lane when driving at night. This dark area is very distracting while driving at night. The area is approximately 1 to 2 meters in diameter when seen on the driving surface. It appears the headlights to not meet the photometric requirements for headlights. This pattern was first noticed when the vehicle was delivered by the dealer. I have contacted multiple dealers with no remedy. The dealer states that "pattern is by design."”
NHTSA complaint #11546888, 2023

“When using the low beams, there is a distinctive shadow or blotch that is evident on the driver's side only in the 2023 4 Runner Limited. I understand from others that it is due to the LED anti glare technology mandated to be used by the government. This shadow or blotch is NOT visible when using the high beams. When using the low beams the shadow is ALWAYS in the periphery or in front of the driver....but it is there at ALL times. As a driver, my eyes are drawn to it, taking my eyes off of the traffic or road ahead. On several occasions I have thought that it was an animal or something.…”
NHTSA complaint #11541730, 2023

Tires 3

“Component: Tire – Dunlop Grandtrek AT20 P265/70R17 Vehicle: 2023 Toyota 4Runner (approx. 25,000 miles) After a standard tire rotation, I began experiencing severe steering wheel vibration (flutter) at highway speeds (55–65+ mph) and during braking. The issue started immediately after rotation and has not gone away, even after returning the tires to their original positions. The dealer replaced rotors and pads, but the vibration remained. There are no warning lights, and no visible tire damage. This condition has been reproduced by the dealer. Upon researching, I found that Toyota issued Tec…”
NHTSA complaint #11668391, 2025

“The contact owns a 2023 Toyota 4Runner equipped with Falken Tires, Tire Line: WildPeak, Tire Size: 275/70/R17, DOT: (N/A). The contact stated that while driving at an undisclosed speed, the steering wheel and driver's seat began to vibrate violently, prompting the contact to dramatically reduce the speed of the vehicle, but the failure persisted. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the four tires. The independent mechanic foun…”
NHTSA complaint #11608776, 2024

“The contact owns a 2023 Toyota 4Runner equipped with Nitto Tires, Tire Line: Ridge Grappler, Tire Size: 265/70/R17, DOT Number: 737079K4222. The contact stated while driving 58 MPH, the steering wheel was vibrating. The vehicle was taken to the dealer, where it was determined that the tires had caused the steering wheel to vibrate. The dealer referred the contact to the tire manufacturer. The vehicle was not repaired. The tire manufacturer was made aware of the failure and a case was opened. The vehicle manufacturer was also made aware of the failure and advised the contact to take the vehicle…”
NHTSA complaint #11555592, 2023

Air Bags 2 2 crash

“We had made collision accident with a brand new 4runner as it appears in the uploaded pictures, the airbags didn’t deploy and never show any notification on the dashboard that there is a problem in the airbag system,after the accident a notification came to the screen that the airbag system malfunctioned and i have to visit dealer And now the insurance company wants to fix that car and give it bag to me however i don’t feel safe anymore to drive that car again.”
NHTSA complaint #11626731, 2024 · crash

“November 2023, my 13 year old daughter and I were involved in a car accident. A vehicle made a left hand turn in front of us and we collided (t-boned) the passenger side of the other vehicle. There were no warning lights, notifications of car crossing in in front of us, the assisted brake system did not activate, the air bags did not deploy, the on car assistance showed no accident reported. Other than the seat belts in the vehicle, no other safety features engaged. We have not been able to locate anyone who can confirm why no of the safety features did not work. Why did none of the safet…”
NHTSA complaint #11565631, 2023 · crash

Back Over Prevention 2

“Poor image quality of backup camera. Very grainy and sometimes dark image makes it difficult to see what’s behind you when backing up. A small child or pet could easily be missed when backing up due to this poor image quality. This is an accident waiting to happen. Prior model years and noticeably better image quality”
NHTSA complaint #11518799, 2023

“The contact owns a 2023 Toyota 4Runner. The contact stated that while the vehicle was shifted into reverse, the back-up camera displayed a distorted screen. No warning light was illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 700.”
NHTSA complaint #11506099, 2022

Engine 2 1 crash

“My vehicle is rear-ended by a large earth mover branded as a Kenworth. My vehicle was then pushed into another. After the initial impact, my engine went racing above 5,000 RPM. It was disengaged from the transmission. I switched my car into neutral, shut my car off and the engine was no longer racing when I restarted the car. Because of an engine racing, I am concerned about the potential that somebody's transmission would be engaged and it could cause serious further injury.”
NHTSA complaint #11648905, 2025 · crash

“We purchased our vehicle new September 2023 from a Toyota dealership. Engine oil dipstick Toyota part 15301-50140 was installed in vehicle and was verified by 50140 stamped on dipstick. I wanted an extra oil dipstick so ordered a replacement through Toyota. The original dipstick part 15301-50140 is no longer available and has been superseded by Toyota part 15301-0P060. I ordered the new dipstick part number and received it from Toyota. It is verified by 0P060 stamped on the dipstick. The safety concern is the two dipsticks are not the same length and each one requires a different quant…”
NHTSA complaint #11603553, 2024

Forward Collision Avoidance 2 2 crash

“The car just accelerated while during into parking lot. I used brake but did work and hit on to the pole. It accelerated pretty fast. The parking lot store has a video of me coming in slow and the the car accelerated.”
NHTSA complaint #11663054, 2025 · crash

“November 2023, my 13 year old daughter and I were involved in a car accident. A vehicle made a left hand turn in front of us and we collided (t-boned) the passenger side of the other vehicle. There were no warning lights, notifications of car crossing in in front of us, the assisted brake system did not activate, the air bags did not deploy, the on car assistance showed no accident reported. Other than the seat belts in the vehicle, no other safety features engaged. We have not been able to locate anyone who can confirm why no of the safety features did not work. Why did none of the safet…”
NHTSA complaint #11565631, 2023 · crash

Power Train 2

“The Front differential need to be replaced. The dealership where we purchased the vehicle replaced the differential. When we got the vehicle back we still had the same problem. The car was making a groaning sound while turning to the right above 35 mph. And the whole car would shake and my wife said it felt like the car was going to fall apart. The vehicle also needed new sway bar bushings my guess is that is because the shaking caused by the bad differential. A car shaking that bad and the axle loose inside the differential seems like a huge safety issue. Also I found a tsb online for this ex…”
NHTSA complaint #11630469, 2024

“Vehicle begins to shake when speed reaches 60 to 70 MPH (issue has been happening since the vehicle left the lot). Shaking can be felt in the steering wheel, gas/brake pedals and front seats. Vehicle has been taken to a Toyota dealership three different times and after three realignments and tire rebalancing, the issue still persists. Several 4Runner owner forums are experiencing the same issue in this make, model and year; and suspect the issue might be stemming from a malfunctioning or broken needle bearing.”
NHTSA complaint #11666953, 2023

Seat Belts 2 1 crash 1 fire 4 injury

“The contact owned a 2023 Toyota 4Runner. The contact stated that while her father was driving under 30 MPH on a side road, the driver swerved to miss a deer. The vehicle drove off a hill, rolled over and landed on its top, and all the seat belts simultaneously unbuckled, causing all the passengers to hit their heads against the roof simultaneously. Additionally, the contact noticed an abnormal fuel odor. The contact stated that she was unable to exit the vehicle. The contact's brother assisted the contact in exiting the vehicle, and all passengers were able to exit the vehicle. The vehicle the…”
NHTSA complaint #11715551, 2023 · crash · fire · 4 injury(ies)

“On 2/21/2023, my parents jumped into the backseat of my parked car and began putting on their seatbelts. They were met with resistance and were unable to retract their seatbelts. This was very arcane because I seldom have any backseat passengers and I don't load any heavy cargo into my car. Moreover, I went into my backseat and retracted the rear seatbelts, except for the middle backseat, slowly enough to expose the part of the belt webbing that was torn. On both sides of my rear seatbelts, the webbing of the belts is torn. This is perplexing because I never utilize my rear seatbelts, I don't…”
NHTSA complaint #11514122, 2023

Service Brakes 2 1 crash 1 injury

“The contact owned a 2023 Toyota 4Runner. The contact stated that while the husband was driving approximately 35 MPH, the brake pedal was depressed but the pedal became stiff and did not slow down as intended. As a result, the contact collided with two vehicles. The air bags deployed. The driver sustained shoulder, back, and forearm injuries. Medical attention was needed. The contact stated that the two other vehicles involved needed medical attention. A police report was filed. The vehicle was taken to a wrecking lot. The manufacturer was not notified of the failure. The failure mileage was ap…”
NHTSA complaint #11551453, 2023 · crash · 1 injury(ies)

“New, strange noise started in Dec'25 (41K miles; 2yrs 9 months). No warning lights. Diagnosed as failed brake accumulator (first at an independent shop, later at the dealer). Apparently the accumulator is part of the full master cylinder assembly which must be replaced. Toyota has quoted $3,200 to complete this repair and is telling me it must be out of pocket.”
NHTSA complaint #11739260, 2025

Steering 2

“I was driving the vehicle and suddenly the steering wheel started to getting hard to turn it and the dash board doesn’t show any failure I went right away to dealership close by they inspected the vehicle they states there is a power steering failure but the car never showed any failure on dashboard or safety system”
NHTSA complaint #11721837, 2026

“On [XXX] while driving approximately 60 mph on a straight smooth highway only about 4 miles from my home my 4 Runner started violently shaking. The whole vehicle was shaking like the wheels were going to fall off. The steering wheel was shaking and I was shaking due to the amount of vibration. I did not depress the brakes for fear it would flip and crash. I let off the accelerator to slow down carefully and find a spot to pull off the highway. As I got slower I checked the onboard tire pressure which indicated all tires were holding correct amounts of air. About 3/4 to a mile from the time the…”
NHTSA complaint #11574613, 2024

Suspension 2

“On [XXX] while driving approximately 60 mph on a straight smooth highway only about 4 miles from my home my 4 Runner started violently shaking. The whole vehicle was shaking like the wheels were going to fall off. The steering wheel was shaking and I was shaking due to the amount of vibration. I did not depress the brakes for fear it would flip and crash. I let off the accelerator to slow down carefully and find a spot to pull off the highway. As I got slower I checked the onboard tire pressure which indicated all tires were holding correct amounts of air. About 3/4 to a mile from the time the…”
NHTSA complaint #11574613, 2024

“Vehicle begins to shake when speed reaches 60 to 70 MPH (issue has been happening since the vehicle left the lot). Shaking can be felt in the steering wheel, gas/brake pedals and front seats. Vehicle has been taken to a Toyota dealership three different times and after three realignments and tire rebalancing, the issue still persists. Several 4Runner owner forums are experiencing the same issue in this make, model and year; and suspect the issue might be stemming from a malfunctioning or broken needle bearing.”
NHTSA complaint #11666953, 2023

Lane Departure 1

“I was driving down the highway when suddenly I heard a loud noise that resembled a gunshot, and shattered glass started flying all around the front of my vehicle. It turned out my sunroof had unexpectedly exploded. It was like the car was under pressure and it was relieved through the sunroof. I had my air conditioner on and my windows up. My sunroof cover was open and broke glass managed to be scattered everywhere. This resulted in glass fragments coming into contact with my face and arms, leading to a painful burning feeling on my skin. Luckily, a Toyota dealership was 2 miles away. I imme…”
NHTSA complaint #11589400, 2024

Latches/Locks/Linkages 1

“After adjusting the vehicle lock sound level in the settings, it completely disabled my key fobs and the panic function on the key fob. Had to take to dealer to fix. Dealer had never seen the issue before. Been reported online many many times. Dealers and Toyota refuse to acknowledge a known issue.”
NHTSA complaint #11680482, 2025

Vehicle Speed Control 1 1 crash

“The car just accelerated while during into parking lot. I used brake but did work and hit on to the pole. It accelerated pretty fast. The parking lot store has a video of me coming in slow and the the car accelerated.”
NHTSA complaint #11663054, 2025 · crash

Visibility/Wiper 1

“Windshield cracked approximately 2” from the bottom all the way across while using the defroster to clear ice from it. I was still parked at the time. I am unsure how long it will stay water tight or become worse. One concern is the crash avoidance and the automatic high beam sensor are both attached to the windshield and don’t want them to fail. I also don’t want the entire piece of glass to shatter and land in my lap while driving. The dealer refused honoring the repair under warranty. They only use one particular repair shop (which I suspect they own) and even quoted me a price for replacin…”
NHTSA complaint #11716332, 2026