2023 Kia Sorento Problems & Owner Complaints

Electrical System 35 1 crash 1 fire 2 injury

“I was driving down the highway on cruise control going 67 on a 65. The car started revving up and then proceeded to go faster. I turned off the cruise control but its continued to speed up. I stomped on the brake 4 or 5 times with no effect. I rammed into the back of a bus at 110 mph.”
NHTSA complaint #11540904, 2023 · crash · 1 injury(ies)

“The vehicle was purchased new. From day one, there were issues. When it was delivered from the factory, it was discovered to be partly unpainted. This raised quality concerns. So far, the most serious has been that the motor blower failed at approximately 29,700 miles. This resulted in the vehicle filling with noxious fumes. It then had to be abandoned on the side of the highway. This led to a fire dispatch and later urgent care visits. Prior to towing, it was discovered that the AC was not working and the engine coolant reservoir was at ~ 1/4 of the minimum line. Ultimately, the vehicle was…”
NHTSA complaint #11608380, 2024 · 1 injury(ies)

“Was driving on Dallas North Toll way when my vehicle lost acceleration. Had to pull over and engine started smoking and lit a flame under the hood. Car is now at Clay Cooley Kia in Irving, TX. Car has been there for over two weeks and I still have no answers or information regarding the plan to fix it. Major dealership delay and all they keep saying is “Waiting on a Kia Engineer to come out but we don't have a date.””
NHTSA complaint #11708410, 2025 · fire

Unknown Or Other 32 2 fire 1 injury

“Automatic lift gate closed and injured child. Was placing groceries in vehicle. Closed lift gate with button on lift gate, child was next to me, but hand was behind him. Liftgate closed and would not reopen. Child was injured.”
NHTSA complaint #11695211, 2025 · 1 injury(ies)

“I am reporting a vehicle fire that occurred in June 2025 involving my Kia vehicle. On the day of the incident, I started my car and immediately noticed excessive smoke coming out of the air vents, along with a strong burning smell. I drove only a short distance and pulled into a gas station across the street to stop and check what was wrong. While stopped, my children in the back seat alerted me that there was a fire coming from the rear AC vent area. I known it was fire because I saw flames inside the AC vent located in the back seat area of the vehicle. I immediately got my children out of…”
NHTSA complaint #11709869, 2025 · fire

“Was driving on Dallas North Toll way when my vehicle lost acceleration. Had to pull over and engine started smoking and lit a flame under the hood. Car is now at Clay Cooley Kia in Irving, TX. Car has been there for over two weeks and I still have no answers or information regarding the plan to fix it. Major dealership delay and all they keep saying is “Waiting on a Kia Engineer to come out but we don't have a date.””
NHTSA complaint #11708410, 2025 · fire

Engine 28 1 fire 1 injury

“The vehicle was purchased new. From day one, there were issues. When it was delivered from the factory, it was discovered to be partly unpainted. This raised quality concerns. So far, the most serious has been that the motor blower failed at approximately 29,700 miles. This resulted in the vehicle filling with noxious fumes. It then had to be abandoned on the side of the highway. This led to a fire dispatch and later urgent care visits. Prior to towing, it was discovered that the AC was not working and the engine coolant reservoir was at ~ 1/4 of the minimum line. Ultimately, the vehicle was…”
NHTSA complaint #11608380, 2024 · 1 injury(ies)

“Was driving on Dallas North Toll way when my vehicle lost acceleration. Had to pull over and engine started smoking and lit a flame under the hood. Car is now at Clay Cooley Kia in Irving, TX. Car has been there for over two weeks and I still have no answers or information regarding the plan to fix it. Major dealership delay and all they keep saying is “Waiting on a Kia Engineer to come out but we don't have a date.””
NHTSA complaint #11708410, 2025 · fire

“I have a 2023 Kia Sorento with approx 60k, purchased new from New Pot Richey Kia. Approx 7 days ago, while driving home from dropping my son at school, my transmission system error warning came on as well as my check engine light. My RPM'S would increased without corresponding acceleration, which meant my transmission, was slipping. I was also experiencing jerking during shifting. In addition to that, my car would hesitate before moving. And I would also experience a slight vibrations at low speeds. All of this would make me feel unsafe when driving my car.”
NHTSA complaint #11751796, 2026

Power Train 19 1 crash

“The contact owns a 2023 Kia Sorento. The contact stated that while the vehicle was parked, the gear shifter was shifted into drive, the accelerator pedal was depressed; however the vehicle failed to accelerate as intended. The contact stated that the vehicle failed to move forward. No warning lights were illuminated. The contact stated that the failure had occurred more than five times within a month. The failure occurred after a previous repair was performed by the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that previously, while…”
NHTSA complaint #11699126, 2025 · crash

“The contact owns a 2023 Kia Sorento. The contact stated that while accelerating from a stop or while driving and depressing the accelerator pedal, the vehicle jerked and lost automotive power. There was no warning light illuminated. The message “Transmission Fluid Low” was displayed. The local dealer was contacted; however, the vehicle was not diagnosed. The VIN was not under recall. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 22V760000 (Power Train); as a possible cause for the failure. The manufacturer was notified of the failure. The failure mileage was 208,6…”
NHTSA complaint #11754478, 2026

“I have a 2023 Kia Sorento with approx 60k, purchased new from New Pot Richey Kia. Approx 7 days ago, while driving home from dropping my son at school, my transmission system error warning came on as well as my check engine light. My RPM'S would increased without corresponding acceleration, which meant my transmission, was slipping. I was also experiencing jerking during shifting. In addition to that, my car would hesitate before moving. And I would also experience a slight vibrations at low speeds. All of this would make me feel unsafe when driving my car.”
NHTSA complaint #11751796, 2026

Forward Collision Avoidance 12

“Vehicle exhibits repeated brake pulsation and vibration under normal braking conditions, affecting braking performance consistency. The issue began at approximately 10,000 miles and has progressively worsened. The vehicle currently has approximately 30,000 miles. The pulsation is felt through the steering wheel and brake pedal during moderate braking from highway speeds and occurs consistently across multiple driving conditions. The condition is significantly more pronounced when using the vehicle’s adaptive cruise control system. During normal operation, the adaptive cruise repeatedly applies…”
NHTSA complaint #11740604, 2026

“Upon starting the vehicle, it flashed several warning lights that were not on the day before. Including popping codes up on the infotainment system and urging me to schedule a service with KIA. Upon looking up the codes it states HVAC issue, when calling to dealership to schedule a service for it (while it is still barely under warranty) they let me know it might not be covered. That’s when I found out there is a recall only for certain VIN #’s for the exact same issue. My car won’t even drive because the electrical system is being affected. Windshield wipers going crazy, lights not working, A…”
NHTSA complaint #11708689, 2026

“Check engine light on. Rear defrost doesn't work. Auto stop/start not working. Cruise control not working. Vehicle shuts off sometimes at stand still and have to put in neutral or park and push Start button. Engine looses power while driving. Check rear cross traffic, check tire pressure monitoring system, check lane departure warning system, check speed limit system, check lane keeping assist, check forward safety system lights are cycling on the front screen and warning ️ signs pinging. Vehicle has been inspected 3 times at a local KIA DEALERSHIP. 1st in 4/2025, 2nd 6/2025 3rd time 10/2025.…”
NHTSA complaint #11702059, 2025

Service Brakes 11

“Vehicle exhibits repeated brake pulsation and vibration under normal braking conditions, affecting braking performance consistency. The issue began at approximately 10,000 miles and has progressively worsened. The vehicle currently has approximately 30,000 miles. The pulsation is felt through the steering wheel and brake pedal during moderate braking from highway speeds and occurs consistently across multiple driving conditions. The condition is significantly more pronounced when using the vehicle’s adaptive cruise control system. During normal operation, the adaptive cruise repeatedly applies…”
NHTSA complaint #11740604, 2026

“I purchased this car with approximately 22,000 miles on it. I have had to have OEM rotor resurface / replacement at the dealership approximately almost every oil change or about every 6,000 miles for about 30k miles (2 replacements, 3 resurface in an 18 month period). They sent out a Kia engineer last time it happened.”
NHTSA complaint #11730368, 2026

“UNKNOWN However multiple times the front end of the vehicle starts shaking when I try to break up especially on the highway. The dealership claimed to have repaired it once and shortly after it happened again. When I took it in they first looked and said the parts was ordered but nothing was done then came back and said oh yes it was done then refused to fix it without a charge so I had to pay to repair it since I feared that the brake would give out if I drive it. The other issue was the check engine light just popped up check engine while driving on the highway, when I take it in they…”
NHTSA complaint #11722647, 2025

Vehicle Speed Control 11 1 crash 1 injury

“I was driving down the highway on cruise control going 67 on a 65. The car started revving up and then proceeded to go faster. I turned off the cruise control but its continued to speed up. I stomped on the brake 4 or 5 times with no effect. I rammed into the back of a bus at 110 mph.”
NHTSA complaint #11540904, 2023 · crash · 1 injury(ies)

“Vehicle exhibits repeated brake pulsation and vibration under normal braking conditions, affecting braking performance consistency. The issue began at approximately 10,000 miles and has progressively worsened. The vehicle currently has approximately 30,000 miles. The pulsation is felt through the steering wheel and brake pedal during moderate braking from highway speeds and occurs consistently across multiple driving conditions. The condition is significantly more pronounced when using the vehicle’s adaptive cruise control system. During normal operation, the adaptive cruise repeatedly applies…”
NHTSA complaint #11740604, 2026

“All lights came on the dashboard including the check engine light and I could not accelerate. I had to pull over and turn car off and on to get it to accelerate. It poses a very serious threat as you can not accelerate at all and can be rearended. Kia has fixed the throttle twice and have told me 2 other times they can not replicate the issue. It clears out by the time I am able to bring it to the dealership. This issues has happened 4 times starting at 9,000 miles and most recently at 21,000 miles.”
NHTSA complaint #11738211, 2026

Lane Departure 9

“Since fall of 2025, my 2023 KIA Sorento has repeatedly been in the shop for multiple issues. Most notably, a completely wrecked steering column. This issue was fixed after being in the shop for 12 days. Then in December, I started noticing the shift would lock while in park. I would need to open the top plate and stick an item down into the shifter to emergency release in order to drive. Then all of the electrical components began to state they were no longer working. No cameras, no lane assistance, no forward collision warning, etc etc. Beyond that, all automatic locks, windows and my trunk s…”
NHTSA complaint #11750686, 2025

“6/22/24-Initial start of dashboard light "miscommunication"-Codes could not be duplicated at Evans Kia dealership 7/11/24-Miscommunication occurs again-Codes pulled for diagnostics 7/22/24-Car brought in for scheduled appointment to dealership to "fix" communication errors: I was told "There was an issue with the system not updating but I should be good to go now" 2/17/25-Communication errors reappear on dash-Car taken back to dealership; Tech line case opened; Dashboard Cluster Replaced; Car given back to customer 3/20/25-Lemon Law Case filed: Determined past mileage window-Given $3000 settle…”
NHTSA complaint #11673946, 2024

“When attempting to start the car, the engine will not start and every alert system and dashboard light turns on. The car is undriveable when it does this. It takes 5-10 minutes of turning the car on and off before it stops and is drivable again. It does not happen every time and seems to be random. This has happened 5 times. An additional 6th time this same issue happened while I was driving - all of the dashboard lights went on, and every alert / warning turned on (forward collision, lane warning, etc). The steering wheel also became stiff and extremely difficult to turn. I have been atte…”
NHTSA complaint #11611286, 2024

Visibility/Wiper 7

“The panoramic sunroof on my 2023 Kia Sorento intermittently fails to close. When commanded to close, the glass travels most of the way, then stops or reverses before reaching the fully closed position. It frequently takes many repeated attempts. In some cases the panel will not seat at all until the vehicle is driven over rough pavement, and the resulting vibration allows it to complete closure. The malfunction is accompanied by a loud grinding or scraping noise from the roof assembly during travel. This condition has been present since I purchased the vehicle new. The sunroof has seen very l…”
NHTSA complaint #11751824, 2026

“While traveling on a freeway, the front sliding portion of our sunroof exploded outward and upward. Sunroof was closed at the time with no impact present to cause the event. A very expensive repair for something that is clearly a defect of some sort. KIA was contacted and not willing to warranty or help cover.”
NHTSA complaint #11750795, 2026

“I am submitting a vehicle safety and certification concern regarding a 2023 Kia Sorento Hybrid that was marketed and offered for sale as a Kia Certified Pre-Owned (CPO) vehicle by Shawnee Mission Kia, 7951 Shawnee Mission Pkwy, Mission, KS 66202. On [XXX], during an in-person inspection of the vehicle prior to purchase, I observed conditions inconsistent with expected Certified Pre-Owned inspection and preparation standards, including inverter coolant below the minimum level, engine oil materially above the normal operating range, and deteriorated windshield wiper condition. A third-party wit…”
NHTSA complaint #11739280, 2026

Fuel/Propulsion System 6 1 crash 1 injury

“I was driving down the highway on cruise control going 67 on a 65. The car started revving up and then proceeded to go faster. I turned off the cruise control but its continued to speed up. I stomped on the brake 4 or 5 times with no effect. I rammed into the back of a bus at 110 mph.”
NHTSA complaint #11540904, 2023 · crash · 1 injury(ies)

“VEHICLE: 2023 Kia Sorento, VIN [XXX] , currently 48,000 miles. Vehicle has never been in a collision. DEFECT: FUEL FILLER DOOR ACTUATOR WITH NO EMERGENCY RELEASE — STRANDING HAZARD The fuel filler door actuator fails to release on demand intermittently. When the actuator fails, the door must be pried open with tools or force, which is inconsistent and not always possible. The dealership service advisor has stated that this model is not equipped with any emergency release mechanism for the fuel filler door. With no emergency release, the actuator is the only mechanism by which the fuel door can…”
NHTSA complaint #11740591, 2026

“Faulty fuel injectors are causing consistent engine misfires and occasionally causing the check engine light to illuminate and for the vehicle to reduce power greatly. This poses a great safety risk to both myself and other drivers on the road because in the event of a large misfire, my vehicle suddenly slows and I have to navigate to the shoulder of the road. A Kia dealership has confirmed that the cause of these misfires is due to a faulty fuel injector that begins to work inconsistently above 3000 RPM. This issue began shortly after the vehicle was purchased in 2023, but due to the dealersh…”
NHTSA complaint #11740305, 2026

Steering 6

“Since fall of 2025, my 2023 KIA Sorento has repeatedly been in the shop for multiple issues. Most notably, a completely wrecked steering column. This issue was fixed after being in the shop for 12 days. Then in December, I started noticing the shift would lock while in park. I would need to open the top plate and stick an item down into the shifter to emergency release in order to drive. Then all of the electrical components began to state they were no longer working. No cameras, no lane assistance, no forward collision warning, etc etc. Beyond that, all automatic locks, windows and my trunk s…”
NHTSA complaint #11750686, 2025

“When attempting to start the car, the engine will not start and every alert system and dashboard light turns on. The car is undriveable when it does this. It takes 5-10 minutes of turning the car on and off before it stops and is drivable again. It does not happen every time and seems to be random. This has happened 5 times. An additional 6th time this same issue happened while I was driving - all of the dashboard lights went on, and every alert / warning turned on (forward collision, lane warning, etc). The steering wheel also became stiff and extremely difficult to turn. I have been atte…”
NHTSA complaint #11611286, 2024

“The contact owns a 2023 Kia Sorento. The contact stated while driving 45 MPH, there was an abnormal squealing sound coming from the steering wheel and the steering wheel was difficult to turn. There was no warning light illuminated. The vehicle was taken to the dealer to be diagnosed. The contact stated that the vehicle received an unstated repair; however, the failure persisted. The manufacturer was made aware of the failure. The approximate failure mileage was 1,328.”
NHTSA complaint #11562990, 2023

Visibility 4

“The contact owns a 2023 Kia Sorento. The contact stated that while his wife was driving 10 MPH, after making a left turn, the sunroof shattered with the sunroof cover closed. The vehicle was steered to the side of the road and inspected, but the contact was unaware that the sunroof had exploded. The vehicle was taken to the residence, where the contact’s husband became aware that the sunroof had shattered. The contact had not sustained any injuries. The vehicle was then taken to a dealer, where it was diagnosed that the sunroof had exploded and needed to be replaced. The vehicle was not repair…”
NHTSA complaint #11721357, 2026

“The contact owns a 2023 Kia Sorento. The contact stated that while attempting to activate the HVAC system, there was an abnormal burning plastic odor inside the vehicle. There was no warning light illuminated. The vehicle was to an independent mechanic who diagnosed the vehicle and determined that the blower motor relay had short circuited and needed to be replaced. The vehicle was not repaired; however, the contact performed a repair based on guidance from the mechanic. The contact stated that the vehicle was repaired, but the failure with the blower motor relay reoccurred. The contact recent…”
NHTSA complaint #11702926, 2025

“Front panel of panoramic sunroof shattered while driving on Interstate 90 at approx 65mpg. Sunroof was fully closed. Exploded on its own with no outside influence. Conditions were clear and dry. Sounded like a gun shot and glass was flying everywhere. Fortunately shade was closed with no glass entering passenger compartment. Could have resulted in injuries or accident if glass entered the driving inside area.”
NHTSA complaint #11675809, 2025

Exterior Lighting 2

“Vehicles instrument cluster goes black at times ( speedometer, tach and all exterior lights and turn signals are inoperative during this time) I took it to the dealership and they said they couldn’t duplicate the problem”
NHTSA complaint #11652948, 2025

“My passenger interior dash and glove box trim are melted. I’ve had it checked out by Kia, however they do not see where an origin could have come from. The day i noticed it, my vehicle had been hit on the front right passenger fender. The melting looked to be electrical or caused by a combustion of sort but we also believe it could have been caused by reflection off of the interior of my vehicle to that spot. I live in Michigan, the temperature was above 80*.”
NHTSA complaint #11526836, 2023

Seats 2

“THIS IS THE SECOND REPORT I AM MAKING. As in my last report this involves the driver’s seat and changing profiles on the infotainment system. - The driver’s seat/profile will keep my settings for a few weeks or months and then it randomly forgets and resets to the factory settings. - On June 18, 2024 the infotainment profile was set for my husband. I switched to my profile and was backing out of my garage and the seat switched to factory settings while the car was actively in reverse. I am short and could not reach the break or gas pedal! - The dealer has not had any other complaints like thi…”
NHTSA complaint #11597689, 2024

“There are two user profiles on the main infotainment system for this vehicle and there are two seat position memory buttons on the door. I am the main driver of the vehicle and have input my seat position into seat memory button #1 on my door making sure my profile on the infotainment is up and the position is confirmed. The system will randomly delete my position and the seat will move to what appears to be the factory setting. I am 5’ 2” so the seat moves lower and so far back I cannot reach the gas nor break pedals. As this has happened what seems like at least 100 times, I mention the pro…”
NHTSA complaint #11544710, 2023

Structure 2

“Front panel of panoramic sunroof shattered while driving on Interstate 90 at approx 65mpg. Sunroof was fully closed. Exploded on its own with no outside influence. Conditions were clear and dry. Sounded like a gun shot and glass was flying everywhere. Fortunately shade was closed with no glass entering passenger compartment. Could have resulted in injuries or accident if glass entered the driving inside area.”
NHTSA complaint #11675809, 2025

“Issue occurred and came to like during the past winter snow storm. The hood of the SUV does not allow and blocks the wiper blade arm from being lifted in order to clean ice off the wiper blade nor can the wiper arm be lifted to clear ice and snow under the wiper arm to allow proper operation. This design flaw does not allow safe and clear sight function of the windshield wipers.”
NHTSA complaint #11567472, 2024

Back Over Prevention 1

“Even though the dealership reports that safety recall 23V610 / SC280 for the mounting clip replacement was completed on 2/16/24, my rearview camera has just fell out of its housing, hanging by its wires, with the mounting clips laying broken in my driveway. My rearview camera is currently unusable; its taped up so that it is not just swinging by the wires. When I contacted my dealership, they are pretty sure they can get this work covered under the warranty, but they are not sure. And my VIN# is currently not pulling up any "Active Recalls". Either the clips they used to replace the previous…”
NHTSA complaint #11665716, 2025

Engine And Engine Cooling 1

“The contact owns a 2023 Kia Sorento. The contact stated that while driving at 40 MPH, the "Low Oil" message was displayed on the instrument panel. The contact immediately pulled over and called for assistance. A service technician arrived at the scene and added engine oil, and the vehicle was driven to an independent mechanic to be inspected. The vehicle was inspected, and the contact was informed that the bolts on the oil pan were loose, causing oil to leak from the engine. The bolts were tightened. The mechanic then informed the contact that certain Kia vehicles were under investigation for…”
NHTSA complaint #11717191, 2026

Equipment 1

“[XXX] was shopping for new vehicle and compared advertised window sticker safety rating to NHTSA rating. The rating on the window sticker was incorrect (stated 5 stars when NHTSA confirms 4 stars). Concerned that this is false advertising and misleading for consumers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)”
NHTSA complaint #11566141, 2024

Traction Control System 1

“was driving down road that was dry with sunshinning. Vehicle Traction control then came on breaks went to the floor and steering wheel started to jerk while the car was still going 55 MPH”
NHTSA complaint #11495427, 2022