2023 Jeep Gladiator Problems & Owner Complaints

Electrical System 14 1 fire

“The contact owns a 2023 Jeep Gladiator. The contact stated that after parking the vehicle and turning the engine off, approximately two hours later the contact discovered smoke and flames coming from the engine compartment of the vehicle. The fire department was called to the scene and extinguished the flames. During the fire, the garage was destroyed and the exterior of the home was partially damaged. A fire report was taken at the scene and the vehicle was later towed away. The fire department and insurance investigator concluded that the fire had originated in the engine compartment of the…”
NHTSA complaint #11613951, 2024 · fire

“The vehicle suffered a catastrophic, systemic high-speed CAN C data bus loop collapse (Diagnostic Trouble Code U0002-00 "Bus Off"), resulting in an immediate, total loss of communication across almost all primary factory control modules—including the Body Control Module (BCM), Powertrain Control Module (PCM), Transmission Control Module (TCM), and ABS gateway. The vehicle is completely immobilized. This specific network data loop shares an exact architectural footprint and physical circuit link with the high-current electrical defects targeted under active, open Federal Safety Recall Campaign…”
NHTSA complaint #11744215, 2026

“The battery keeps draining. It’s done it twice in 1 year, 2 different batteries”
NHTSA complaint #11718041, 2026

Suspension 12

“Jeep Death Wobble. Going 60, hit a bump and then the entire front end of Jeep started jumping back and forth so badly, I thought the Jeep was coming completely apart and I was going to crash. Applying the brakes didn't help, the steering seemed out of control, I was terrified and felt like I was going to lose going to lose control of the vehicle or crash into an oncoming vehicle! Thank God I didn't! I just had to wait till the vehicle slowed down and it eventually it stopped. This is now the 3rd time it happened in the passed week.”
NHTSA complaint #11735257, 2026

“My 2023 Gladiator currently has 36,000 miles and is experiencing severe front-end vibration commonly referred to as “death wobble.” The issue occurs at approximately 60 mph when hitting a bump on the highway, causing the steering wheel and front end to shake violently. I have scheduled an appointment with an authorized Jeep dealer for inspection. This condition has nearly caused an accident, as I was traveling on a busy highway and had to slow down abruptly and pull over to regain control. There are no warning lights, messages, or other noticeable symptoms.”
NHTSA complaint #11718954, 2026

“Vehicle has been in the shop at 17,000 miles and had a complete transfer case, front and rear output shafts and rear Danna 44 (Max Tow) replaced in November of 2025. In June of 2025 vehicle has been in another shop for the same issues that occurred before these driveline repairs for three weeks now. Shop can not diagnose issues after three weeks. A star report has been made and Jeep is sending a technician to diagnose.”
NHTSA complaint #11742964, 2025

Steering 10

“The contact owns a 2023 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 26V363000 (Steering); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.”
NHTSA complaint #11746139, 2026

“The vehicle suffered a catastrophic, systemic high-speed CAN C data bus loop collapse (Diagnostic Trouble Code U0002-00 "Bus Off"), resulting in an immediate, total loss of communication across almost all primary factory control modules—including the Body Control Module (BCM), Powertrain Control Module (PCM), Transmission Control Module (TCM), and ABS gateway. The vehicle is completely immobilized. This specific network data loop shares an exact architectural footprint and physical circuit link with the high-current electrical defects targeted under active, open Federal Safety Recall Campaign…”
NHTSA complaint #11744215, 2026

“Jeep Death Wobble. Going 60, hit a bump and then the entire front end of Jeep started jumping back and forth so badly, I thought the Jeep was coming completely apart and I was going to crash. Applying the brakes didn't help, the steering seemed out of control, I was terrified and felt like I was going to lose going to lose control of the vehicle or crash into an oncoming vehicle! Thank God I didn't! I just had to wait till the vehicle slowed down and it eventually it stopped. This is now the 3rd time it happened in the passed week.”
NHTSA complaint #11735257, 2026

Fuel/Propulsion System 8

“while completly filling the vehicle with gasoline, fuel sprays out of teh filler neck onto the vehicle and ground. This has happened many times, at reputible gas stations (Costco, Sams, walmart, Loaf and Jug). Dealership replaced original filler tube. But problem still exists. Shared video with dealership and they indicated they had no problems Castle Rock Jeep, Castle rock, COlorado”
NHTSA complaint #11746287, 2026

“Cut off on me while driving. Loss power in middle of street almost cause me to hit another vehicle. Took it to repair under warranty they took almost 2 months to repair. Did some research and apparently this is a common issue on these trucks ans it is still not a recall about it. Dealership replaced same fuel injection pump it had. So basically it will happen again sometime soon. My vehicle only has 17k miles.”
NHTSA complaint #11710724, 2025

“Gas overflows when filling at gas station It has happened over 5 times. Nozzle is on the lowest setting Have been to the dealership twice to have it inspected I have video of it happening twice. The tank is usually 1/4 tank when filling. Safety hazard.”
NHTSA complaint #11693420, 2025

Power Train 8

“The vehicle does not have linerar acceperation. At times from a start, cold or warn engine, the vehicle will abruptly accelerate harder than the gas pedal was pressed. at light throttle, the vehicle will surge, shutter or chug. Erattic acceperation. after the engine replacement for a connecting rod bearing failure, the engine was running rough, poor mileage and stalled on a wet and cold morning (32degrees, raining). The stall happened on the deaccel lane of the interstate 25 (65 mph). THe dealership replaced one injector and said the problem was fixed. But it is not. Vehicle has n…”
NHTSA complaint #11746289, 2026

“Vehicle has been in the shop at 17,000 miles and had a complete transfer case, front and rear output shafts and rear Danna 44 (Max Tow) replaced in November of 2025. In June of 2025 vehicle has been in another shop for the same issues that occurred before these driveline repairs for three weeks now. Shop can not diagnose issues after three weeks. A star report has been made and Jeep is sending a technician to diagnose.”
NHTSA complaint #11742964, 2025

“I used the 4 wheel drive and received message that clutch was hot, then received message to service transmission. Vehicle went into limp mode. Drove at speeds of 35 to 40 miles an hour. 50 miles an hour down hill. Had to drive access roads because [XXX] traffic is 75 miles per hour. Several times speed was even slower. Took it to brown dodge in Devine. The reset system and said I could not use 4x4. Referenced star code s2521000001. I took vehicle in 7/13/25. I wonder if they even previously preformed recall 19a clutch on This manual transmission. Purchased Mojave Jan/2023,…”
NHTSA complaint #11674645, 2025

Engine 7 1 fire

“The contact owns a 2023 Jeep Gladiator. The contact stated that after parking the vehicle and turning the engine off, approximately two hours later the contact discovered smoke and flames coming from the engine compartment of the vehicle. The fire department was called to the scene and extinguished the flames. During the fire, the garage was destroyed and the exterior of the home was partially damaged. A fire report was taken at the scene and the vehicle was later towed away. The fire department and insurance investigator concluded that the fire had originated in the engine compartment of the…”
NHTSA complaint #11613951, 2024 · fire

“5800 miles, the engine failed due to a connecting rod failure. Chrysler replaced the engine at no cost. Oil changes were done at the year mark as the mileage limit was not reached. Dealership indicates they replace several 3.6 engines a month for warranty failures Castle Rock Jeep, Castle rock Colorado.”
NHTSA complaint #11746281, 2026

“The contact owns a 2023 Jeep Gladiator. The contact stated that there were several electrical issues while driving the vehicle at various speeds; there were surges in the RPM accompanied by the vehicle wobbling abnormally. The contact stated that the instrument panel was completely blank. There were no warning lights illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was advised that the PCA harness was faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The approxim…”
NHTSA complaint #11687986, 2025

Unknown Or Other 5 1 fire

“My vehicle was off and parked in my driveway, my dogs were alerting to something outside and I looked out to see the front end of my vehicle in flames, by the time the fire department got here, there was nothing left but a shell.”
NHTSA complaint #11688040, 2025 · fire

“Back glass shattered spontaneously. It is on Jeep website that it is know to be a manufacturer of defect. Dodge/Jeep will not repair or offer any assistance. It's a 2023 Jeep gladiator milage is under 30,000 miles. It garage kept and only driven 1 day a week and sometimes not even that.”
NHTSA complaint #11725875, 2026

“On [XXX], I purchased a 2023 Jeep Gladiator from Lakeland Chrysler, Dodge, Jeep Ram in Lakeland, Florida. At the time of purchase. I purchased a 36K/3 Year Bumper to Bumper warranty on the vehicle. After purchasing the vehicle, I noticed that several lights would come on in the vehicle. So I took the vehicle to the shop. The vehicle was taken to Posner Park Chrysler, Dodge, Jeep , RAM. A diagnostic test was completed, and they informed me that the airbags were inoperable, and the harnesses were sliced. The front door lock was also not working as well as other items. There was no way for me t…”
NHTSA complaint #11670503, 2025

Service Brakes 4

“Parking brake would not hold vehicle on hill. When the handle was released, a metalic clinking noise was heard. Castle rock jeep dealership said all was fine. Upon my inspection, I found the parking brake cable connection under teh center console was no longer connected. The cable was reconnected, and the cable was tightened to specifications indicated my Jeep. THe vehicle had 6200 miles on it. p.s. THis was after the warranty replacement of the engine. THe dealership indicated they tested several other jeeps and they all acted as mine. No concern for safety.”
NHTSA complaint #11746285, 2026

“Parking/emergency brake has become unattached and no longer functions. It is a manual transmission and the parking brake is required to keep the vehicle from possibly rolling once parked.”
NHTSA complaint #11584730, 2024

“Purchased new in 2023....vehicle soon started making a "hissing" sound from steering area normally upon first morning startup. The vehicle would then go forward or in reverse when I attempted to come out of "park" but had not released brake yet. brought to dealer for repair 2/26/24 at 6162 miles. dealer replaced vacuum pump as cause of concern. the issue seemed resolved for maybe less than two weeks. same issue returned. The safety concern is that the vehicle should not move with the brake pedal pressed and this issue is allowing the vehicle to move. the brakes have to be pumped several times…”
NHTSA complaint #11580496, 2023

Air Bags 2

“I purchased this vehicle April 2025 from Hollywood Motors LLC in Columbus OH. I noticed recently the vehicle had some frame damage after getting alignment, Also the airbag warning lights were coming on. Took the vehicle to a very reputable frame shop and they thoroughly investigated and found there that the drivers side frame rail i pushed back significantly. Also recently noticed the steering wheel adjustment is does not work. I purchased AS IS but I got confirmation in writing from dealer that he guarantees there is no frame damage and the vehicle is safe. This is false information and…”
NHTSA complaint #11694719, 2025

“On [XXX], I purchased a 2023 Jeep Gladiator from Lakeland Chrysler, Dodge, Jeep Ram in Lakeland, Florida. At the time of purchase. I purchased a 36K/3 Year Bumper to Bumper warranty on the vehicle. After purchasing the vehicle, I noticed that several lights would come on in the vehicle. So I took the vehicle to the shop. The vehicle was taken to Posner Park Chrysler, Dodge, Jeep , RAM. A diagnostic test was completed, and they informed me that the airbags were inoperable, and the harnesses were sliced. The front door lock was also not working as well as other items. There was no way for me t…”
NHTSA complaint #11670503, 2025

Vehicle Speed Control 2

“media screen goes black wile driving and cluster has red lines comes on and off”
NHTSA complaint #11703157, 2025

“2023 Jeep Gladiator with 8000 miles shut off while driving down the highway at approximately 40 Mph. Service Electronic Throttle Control light illuminated. Coasted to a stop and put the vehicle in park. Vehicle wouldn’t restart. Vehicle is currently at the dealership awaiting service.”
NHTSA complaint #11592749, 2024

Wheels 2

“Jeep Death Wobble. Going 60, hit a bump and then the entire front end of Jeep started jumping back and forth so badly, I thought the Jeep was coming completely apart and I was going to crash. Applying the brakes didn't help, the steering seemed out of control, I was terrified and felt like I was going to lose going to lose control of the vehicle or crash into an oncoming vehicle! Thank God I didn't! I just had to wait till the vehicle slowed down and it eventually it stopped. This is now the 3rd time it happened in the passed week.”
NHTSA complaint #11735257, 2026

“At 4k miles hit small bump, jeep vibrated violently this has happened on multiple occasions at highway speeds & was very dangerous. Dealer has vehicle in shop for over 24 hours blame’s tire alignment, they had just rotated tires.”
NHTSA complaint #11552898, 2023

Exterior Lighting 1

“Headlights on new Jeep vehicles are terribly bright and poorly aimed so that they blind all oncoming traffic. There are many other newer vehicles with similar problems, but Jeeps seems to be the worst, along with Dodge Ram pickups. Please do something about getting laws passed to require proper aiming of headlights. The new HID and LED lights are obnoxious enough when they are aimed properly and there is a tiny change in elevation of the road. But if you drive down a flat country highway, you can easily see 1 out of 10 cars coming at you with much brighter lights than all the others. This shou…”
NHTSA complaint #11558492, 2023

Firerelated 1 1 fire

“The contact owned a 2023 Jeep Gladiator. The contact stated that while the vehicle was parked on a private road, but turned on, a fuel odor was detected inside the cabin. No warning light was illuminated. A few minutes later, the engine compartment on the passenger side caught fire. The contact's husband and their pets were able to safely exit the vehicle without injury. The vehicle burned to the ground. The fire department arrived and extinguished the fire. A fire department report was filed. The insurance company was notified of the failure, but had not yet declared the vehicle totaled. The…”
NHTSA complaint #11709930, 2026 · fire

Visibility/Wiper 1

“Brand new Jeep gladiator. 458 miles on it and the windshield glass cracked. No rock or external object hit it, simply faulty glass. I went to an online forum and found that windshields cracking on jeep’s is extremely common and Jeep refuses to warranty or do anything about it.”
NHTSA complaint #11568699, 2024