2023 Hyundai Tucson Problems & Owner Complaints

Unknown Or Other 32 4 crash 1 injury

“My client lost her right eye and suffered a brain injury when an aftermarket rhinestone emblem decal from her steering wheel shot into her face during a low-impact crash with a deer. The crash left minimal damage to the front end of the vehicle, but caused the airbags to deploy, shooting the decal into my client’s head. She purchased this dangerous decoration on Amazon, and despite NHTSA notices in 2023 and 2024 telling consumers to “avoid purchasing these steering wheel decals for all vehicle makes and models” and to “remove any such decals that they have already applied to their steering wh…”
NHTSA complaint #11754571, 2025 · crash · 1 injury(ies)

“At dusk I was driving below the speed limit (40 MPH). I was at least 3 car lengths behind the vehicle in front of me when i saw the driver was braking because his brake lights came on and there was an intersection ahead with a stop light. There were at least two cars ahead of the vehicler I was behind. I braked but the car kept on going and appeared to accelerate. I was unable to stop the car with the brakes and collided with the car ahead. It was a sturdy vehicle with a strong bumper so I did not do much damage, if any, to the vehicle but my car requires 6,645.90 of repairs. No one was h…”
NHTSA complaint #11718185, 2026 · crash

“As I was parking my car in a parking spot going about 5 miles or less. My car surged forward at a very accelerated speed, and I ended up running into a brushed and a metal fence, which is what stopped me. There were no warnings that went off on my car. No emergency brakes, nothing.”
NHTSA complaint #11700859, 2025 · crash

Forward Collision Avoidance 26 6 crash

“At dusk I was driving below the speed limit (40 MPH). I was at least 3 car lengths behind the vehicle in front of me when i saw the driver was braking because his brake lights came on and there was an intersection ahead with a stop light. There were at least two cars ahead of the vehicler I was behind. I braked but the car kept on going and appeared to accelerate. I was unable to stop the car with the brakes and collided with the car ahead. It was a sturdy vehicle with a strong bumper so I did not do much damage, if any, to the vehicle but my car requires 6,645.90 of repairs. No one was h…”
NHTSA complaint #11718185, 2026 · crash

“I was backing out of my driveway, which is on a busy street. I waited for the traffic to clear. I backed out onto the main road, which I thought was completely clear, but a car came behind me and I smacked right into him. There was no beeping from my car, and the automatic braking system did not engage at all. The rear of my car, particularly the driver's side, was severely damaged. The other car's passenger front door was badly damaged. The side curtain airbag on their car deployed and their vehicle (Volvo station wagon) was not driveable. The emergency braking system frequently engages…”
NHTSA complaint #11702099, 2025 · crash

“For the second time in a year, I was pulling into a parking space and when I applied the brake, the car accelerated, seemed to be airborne and lurched forward. Though I firmly had my foot on the break, it would not stop until it hit a brick post about three feet away. This exact same scenario happened in July of last year. Then, I hit a stand of shrubs. Someone said, your foot must have slipped off the break and hit the accelerator. I said, “I don’t think so.” Yet, I took the blame for the accident, for I could not believe it was a car malfunction, nothing close to this had happened to me s…”
NHTSA complaint #11668700, 2025 · crash

Electrical System 25 1 crash 1 fire

“I purchased a new vehicle in February 2023. After a month and a half, I traveled to Washington DC on a pleasure trip. After my work/vacation trip when I am returning back to home all of the sudden, there was heavy smoke from the hood and eventually tried to turn off the engine but the car didn't respond, and when I tried to open the Hood in order to cool down the engine I see fire already in the engine. So, there was no intimation on the dashboard about the fire or not even an alert. Moreover, the engine didn't turn off even after trying to turn it off 4- 5 times. I was really worried about w…”
NHTSA complaint #11518756, 2023 · fire

“As I was parking my car in a parking spot going about 5 miles or less. My car surged forward at a very accelerated speed, and I ended up running into a brushed and a metal fence, which is what stopped me. There were no warnings that went off on my car. No emergency brakes, nothing.”
NHTSA complaint #11700859, 2025 · crash

“The vehicle developed an intermittent but potentially dangerous engine control malfunction. After the engine reached normal operating temperature, the engine speed (RPM) would repeatedly surge while the vehicle was stopped in Park and Neutral, fluctuating from approximately 1,000 RPM to over 3,000 RPM without any throttle input from the driver. The condition occurred with the air conditioning turned off and could be reproduced multiple times. At approximately the same time, the Auto Start/Stop system stopped functioning and displayed a warning indicator. A malfunction indicator lamp (check en…”
NHTSA complaint #11752416, 2026

Engine 23 1 fire

“I purchased a new vehicle in February 2023. After a month and a half, I traveled to Washington DC on a pleasure trip. After my work/vacation trip when I am returning back to home all of the sudden, there was heavy smoke from the hood and eventually tried to turn off the engine but the car didn't respond, and when I tried to open the Hood in order to cool down the engine I see fire already in the engine. So, there was no intimation on the dashboard about the fire or not even an alert. Moreover, the engine didn't turn off even after trying to turn it off 4- 5 times. I was really worried about w…”
NHTSA complaint #11518756, 2023 · fire

“The vehicle developed an intermittent but potentially dangerous engine control malfunction. After the engine reached normal operating temperature, the engine speed (RPM) would repeatedly surge while the vehicle was stopped in Park and Neutral, fluctuating from approximately 1,000 RPM to over 3,000 RPM without any throttle input from the driver. The condition occurred with the air conditioning turned off and could be reproduced multiple times. At approximately the same time, the Auto Start/Stop system stopped functioning and displayed a warning indicator. A malfunction indicator lamp (check en…”
NHTSA complaint #11752416, 2026

“I was on the highway on the way to work when my car started stalling. Every time I pressed the gas to give it some power, it would not go anyway where. after getting it towed to get looked at some of the fuel injectors failed and were misfiring. The warning message about ‘check engine’ popped up 2 minutes before it happened. this is the third time now in less than 6 months.”
NHTSA complaint #11749034, 2026

Service Brakes 18 2 crash

“For the second time in a year, I was pulling into a parking space and when I applied the brake, the car accelerated, seemed to be airborne and lurched forward. Though I firmly had my foot on the break, it would not stop until it hit a brick post about three feet away. This exact same scenario happened in July of last year. Then, I hit a stand of shrubs. Someone said, your foot must have slipped off the break and hit the accelerator. I said, “I don’t think so.” Yet, I took the blame for the accident, for I could not believe it was a car malfunction, nothing close to this had happened to me s…”
NHTSA complaint #11668700, 2025 · crash

“on 04/16/23 I got into my car and Immediately after going into drive the brakes completely failed. The car continued accelerating even after releasing the accelerator and refused to stop even while pumping the brakes. Thank god I turned into a tree and missed pedestrians. the car was totaled.”
NHTSA complaint #11517285, 2023 · crash

“While driving on a highway shortly after taking delivery of this vehicle as a Certified Pre-Owned purchase from an authorized Hyundai dealership, I experienced sudden and total brake failure. The Electronic Parking Brake (EPB) warning light illuminated and an audible warning chime sounded. The brake pedal did not respond normally. I was unable to slow the vehicle with the brakes and was forced to make an emergency maneuver to exit the highway and come to a safe stop. Upon inspecting the vehicle after stopping, I discovered that the rear left brake caliper had completely detached from its moun…”
NHTSA complaint #11745559, 2026

Vehicle Speed Control 17 5 crash 2 injury

“The contact owned a 2023 Hyundai Tucson. The contact stated that while his mother was driving at an undisclosed speed, she heard an abnormal sound emanating from an unknown location of the vehicle, after which the vehicle began to accelerate on its own. The driver attempted to stop the vehicle, but the brake pedal pulsated and failed to slow the vehicle, resulting in the driver briefly losing control of the vehicle and only coming to a complete stop after colliding with a utility pole. Both the driver and passenger side air bags deployed. No warning lights were illuminated. The vehicle was tow…”
NHTSA complaint #11598593, 2024 · crash · 2 injury(ies)

“As I was pulling into a parking space in a parking garage, the vehicle's engine revved, tires squealed and then the vehicle propelled forward on its own, without my foot being on the accelerator. The vehicle only stopped when it hit a support column and the wall of the parking structure. There was extensive damage to my vehicle and to the parking structure wall. My safety and the safety of others was put at risk due to the car accelerating on its own. The problem has not been confirmed or reproduced by the dealer, but we did take the vehicle to the dealer for inspection and they said they co…”
NHTSA complaint #11711003, 2025 · crash

“As I was parking my car in a parking spot going about 5 miles or less. My car surged forward at a very accelerated speed, and I ended up running into a brushed and a metal fence, which is what stopped me. There were no warnings that went off on my car. No emergency brakes, nothing.”
NHTSA complaint #11700859, 2025 · crash

Fuel/Propulsion System 16 1 crash

“The car suddenly and unintentionally accelerated. To avoid going through the back of my garage, I turned slightly and hit the frame of the garage. It continued to accelerate for a few seconds until I managed to stop it. I then backed up. Again, the car suddenly unintentionally accelerated. I managed to stop it. I slowly drove it into the garage. I left it in the garage until having it towed to Planet Hyundai. I did not want to drive it in case it accelerated on the drive to Planet Hyundai. I was driving about 5 mph when I hit the frame of the garage. The car continued to accelerate. Auto…”
NHTSA complaint #11583708, 2024 · crash

“I was on the highway on the way to work when my car started stalling. Every time I pressed the gas to give it some power, it would not go anyway where. after getting it towed to get looked at some of the fuel injectors failed and were misfiring. The warning message about ‘check engine’ popped up 2 minutes before it happened. this is the third time now in less than 6 months.”
NHTSA complaint #11749034, 2026

“Sitting at a red light the vehicle seemed to almost stalled then lunged forward about eight feet almost colliding with the vehicle in front of me. To my knowledge the vehicle has not been inspected by the manufacturer nor has the problem been reproduced by a dealer or independent service center. To my knowledge there were no warning lights, messages or symptoms. I am somewhat unfamiliar with this vehicle since I've only owned it for 5 days. I picked it up on 4-25-26.”
NHTSA complaint #11734716, 2026

Power Train 14 3 crash 2 injury

“The contact owned a 2023 Hyundai Tucson. The contact stated that while his mother was driving at an undisclosed speed, she heard an abnormal sound emanating from an unknown location of the vehicle, after which the vehicle began to accelerate on its own. The driver attempted to stop the vehicle, but the brake pedal pulsated and failed to slow the vehicle, resulting in the driver briefly losing control of the vehicle and only coming to a complete stop after colliding with a utility pole. Both the driver and passenger side air bags deployed. No warning lights were illuminated. The vehicle was tow…”
NHTSA complaint #11598593, 2024 · crash · 2 injury(ies)

“As I was pulling into a parking space in a parking garage, the vehicle's engine revved, tires squealed and then the vehicle propelled forward on its own, without my foot being on the accelerator. The vehicle only stopped when it hit a support column and the wall of the parking structure. There was extensive damage to my vehicle and to the parking structure wall. My safety and the safety of others was put at risk due to the car accelerating on its own. The problem has not been confirmed or reproduced by the dealer, but we did take the vehicle to the dealer for inspection and they said they co…”
NHTSA complaint #11711003, 2025 · crash

“On [XXX] around [XXX] PM two Barnes County Sheriff’s Deputies responded to a Reckless Driving Complaint. The Reckless Driving Complaint started on [XXX] and later crashed around [XXX] near [XXX]. Barnes County Sheriff Randy McClaflin said the reporting person, a [XXX] female, was also the driver of the reckless vehicle, a 2023 white Hyundai Tucson. of Fargo contacted the Barnes County Dispatch Center and reported her gas pedal was stuck and the vehicle she was driving was traveling at speeds of over 90 miles per hour. made multiple attempts to shut the vehicle off, place it in neutral/par…”
NHTSA complaint #11607070, 2024 · crash

Steering 6 1 injury

“On [XXX], while driving a 2023 Hyundai TUCSON SEL, the steering wheel suddenly and completely detached from the steering column and ended up in the driver's lap. This sudden and absolute loss of steering control is a catastrophic failure of a primary safety system that placed the driver's life and potentially the lives of others in immediate and extreme peril. It was only due to sheer luck that the vehicle was brought to a stop without an accident or injury. Following the incident, due to fear and anxiety, the driver is now in treatment and has been unable to work. The vehicle was transporte…”
NHTSA complaint #11685540, 2025 · 1 injury(ies)

“While driving on April 11, 2026 at approximately 1:30 PM on [XXX] , the vehicle experienced a loss of steering response while the roadway curved to the right. The driver turned the steering wheel normally in order to follow the curve. The steering wheel moved freely and felt normal. However, the vehicle did not respond to the steering input and instead continued traveling straight. As a result, the vehicle struck the curb on the driver’s side. The impact with the curb slightly redirected the vehicle, but steering response was not restored. The driver continued attempting to steer the vehicle,…”
NHTSA complaint #11731406, 2026

“I am writing regarding a serious vehicle safety issue involving my 2023 Hyundai Tucson Limited purchased from on [XXX] with approximately 61,000 miles. About one month after purchase, during a drive from Pennsylvania to Florida in October 2025, the vehicle experienced multiple dangerous steering and collision-assist malfunctions in clear highway conditions. The first incident occurred in Virginia while adaptive cruise control and steering assist were active at approximately 70 mph. Within seconds, the steering wheel aggressively turned left and right, causing the vehicle to tip and nearly rol…”
NHTSA complaint #11739331, 2025

Exterior Lighting 5

“The rear turn signals on the 2023 Hyundai Tucson are on the rear bumper. They are never seen by any car or truck sitting behind you or next to you in your blindspot. I believe the 2022 & the 2024 also have this issue, and there are numerous complaints about it online, especially on Reddit and auto forums. They are dangerous. Cars too close behind you or next to you in your blindspot, will never see your signal, especially the larger cars & trucks or tall autos such as buses, garbage trucks, etc. Here is one of many articles & videos about this issue: [XXX] INFORMATION REDACTED PURSUA…”
NHTSA complaint #11605308, 2024

“Indicator/turn light is very low under bumper. It is not visible to the vehicle behind and around. Other driver think that I am not turning indicator light and they are upset and honking at me. Poor design and it could cause an accident.”
NHTSA complaint #11565344, 2024

“head lights, I cannot see pedestrians walking on cross walk when driving they head lights seem kind of dim”
NHTSA complaint #11558030, 2023

Air Bags 4 3 crash 2 injury

“My client lost her right eye and suffered a brain injury when an aftermarket rhinestone emblem decal from her steering wheel shot into her face during a low-impact crash with a deer. The crash left minimal damage to the front end of the vehicle, but caused the airbags to deploy, shooting the decal into my client’s head. She purchased this dangerous decoration on Amazon, and despite NHTSA notices in 2023 and 2024 telling consumers to “avoid purchasing these steering wheel decals for all vehicle makes and models” and to “remove any such decals that they have already applied to their steering wh…”
NHTSA complaint #11754571, 2025 · crash · 1 injury(ies)

“I was driving straight when a vehicle coming from the opposite direction made a left turn without yielding, crossing into my lane. As a result, my vehicle collided with the other car at full speed. However, the airbag in my steering wheel did not deploy upon impact, as it should have. My injuries have been significantly more severe than they would have been had the airbag functioned properly. I reported this issue to the vehicle manufacturer, and they opened a case and conducted an inspection. During their inspection, they found that the airbag had since deployed. However, my vehicle was trans…”
NHTSA complaint #11643749, 2024 · crash · 1 injury(ies)

“As I was pulling into a parking space in a parking garage, the vehicle's engine revved, tires squealed and then the vehicle propelled forward on its own, without my foot being on the accelerator. The vehicle only stopped when it hit a support column and the wall of the parking structure. There was extensive damage to my vehicle and to the parking structure wall. My safety and the safety of others was put at risk due to the car accelerating on its own. The problem has not been confirmed or reproduced by the dealer, but we did take the vehicle to the dealer for inspection and they said they co…”
NHTSA complaint #11711003, 2025 · crash

Lane Departure 4 1 crash

“I was backing out of my driveway, which is on a busy street. I waited for the traffic to clear. I backed out onto the main road, which I thought was completely clear, but a car came behind me and I smacked right into him. There was no beeping from my car, and the automatic braking system did not engage at all. The rear of my car, particularly the driver's side, was severely damaged. The other car's passenger front door was badly damaged. The side curtain airbag on their car deployed and their vehicle (Volvo station wagon) was not driveable. The emergency braking system frequently engages…”
NHTSA complaint #11702099, 2025 · crash

“Major problems with this cars electrical and computer systems. Six warning lights would begin to flash in succession. Eventually car would be inoperative leaving us stranded in July 2025 in Cumberland MD then after supposed repair we were again stranded in Providence RI on Nov 20, 2025 and car has been there for repair ever since. No completion date has yet been given. I strongly believe there are major safety problems with this car.”
NHTSA complaint #11707219, 2025

“While driving 35mph on a 3-lane street in the far left lane, a driver of a Ford F-150 was in the center lane about two car lengths ahead, decided to make a right turn onto a residential street (as if he were driving a semi). As I got closer, the forward collision warning suddenly alerted and immediately initiated emergency braking system causing all 3 passengers to be thrown forward. I hit the steering wheel before seat belt caught me. I was not even within distance and he was turning in opposite direction of my lane. There also seems to be sensitivity issues with lane keeping feature as i…”
NHTSA complaint #11584233, 2024

Visibility/Wiper 4

“I was driving on the freeway no where near an overpass going about 65mph when the front panel on my panaromaic sunroof exploded and glass went everywhere. There is no signs that a rock could have possibly hit it. My safety was at risk because I could have crashed and broken glass rained down on me. There were no warning signs and the vehicle has not been inspected yet, but it will be.”
NHTSA complaint #11739695, 2026

“1. Component and Availability: The panoramic sunroof shattered spontaneously. The failed component was replaced by Myrtle Beach Hyundai, but I have documented the damage with photos, and the vehicle is available for inspection to show the remaining glass debris inside the structure and the damaged headliner. 2. Safety Risk: The sunroof shattered with a loud, gunshot-like noise while driving at 60 mph on a highway (I-95), causing extreme driver distraction and potential loss of vehicle control. Furthermore, a large amount of glass shards fell into the cabin and remains trapped inside the headl…”
NHTSA complaint #11712996, 2026

“Car is 7 months old. We had it less than 2 weeks and a rock hit the windshield and caused a crack, which we had professionally repaired the next day. 3 weeks later another small rock hits the windshield and it cracks to the point we have to have it replaced. 5 weeks later another small item hits the windshield and it cracks and we have to have it replaced again. Today, a small rock hit the windshield and caused a crack that we will be having repaired tomorrow. I have never had a car where we had to have a repair or replacement of the windshield more than once every 1-2 years and this is the 3r…”
NHTSA complaint #11529652, 2023

Structure 3

“I was driving on the freeway no where near an overpass going about 65mph when the front panel on my panaromaic sunroof exploded and glass went everywhere. There is no signs that a rock could have possibly hit it. My safety was at risk because I could have crashed and broken glass rained down on me. There were no warning signs and the vehicle has not been inspected yet, but it will be.”
NHTSA complaint #11739695, 2026

“While on the road, the sunroof just shattered completely. In this instance, nobody was hurt as the cover below the sunroof was open and that caught all the glass pieces. The car is hardly 2 year old and warranty covered the repairs. The complaint is that Hyundai never gave a clear answer as to why this happened and what can be done to prevent it. There is no consideration of the passengers getting hurt and startled by this incident. Also no consideration for the time it took for the repairs, the dealership never gave a loaner and we didn’t know we could rent it and Hyundai would reimburse. I f…”
NHTSA complaint #11667234, 2025

“The contact owns a 2023 Hyundai Tucson. The contact stated that while driving approximately 70 MPH, the vehicle experienced phantom braking without another vehicle or object being nearby. The contact deactivated the system and was able to drive the vehicle safely. The contact stated that the failure recurred several times without warning. The vehicle was taken to the dealer who determined that the bracket supporting the sensor had detached, causing the system failure. The vehicle was not repaired. The contact deactivated the Forward Collision Avoidance system. The manufacturer was made aware o…”
NHTSA complaint #11552246, 2023

Visibility 3

“The contact owns a 2023 Hyundai Tucson. The contact stated that the panoramic sunroof exploded while driving at approximately 40-50 MPH. The rear section of the sunroof glass had shattered into several pieces without impact. The contact closed the shade, and the glass fell inward. There was glass inside the shade and the roof. There were no injuries. There was an abnormally loud sound like a handgun or several balloons popping. The vehicle was previously inspected, and there were no issues found with the sunroof. The vehicle was taken to the local dealer, and the dealer stated that a rock migh…”
NHTSA complaint #11746494, 2026

“Driving down the freeway at normal speeds and my panoramic sunroof literally just exploded, raining tempered glass all over the interior of the vehicle while I was driving. No evidence that it was caused by any road debris, objects, nor falling objects from the sky. I wasn’t driving under a bridge and no cars/trucks were immediately next to me nor in front of me. Traffic was flowing at normal speed. I wasn’t injured but was certainly startled and distracted for a moment to gauge what had just happened. The dealer is looking into it. Claims it could have been caused by a rock. That s…”
NHTSA complaint #11567125, 2024

“I was driving on the highway & my sunroof exploded. Glass was shattered & rained down on me & my occupants. 1/The sun roof - I have since vacuumed the mess, but it is still not repaired. Available for inspection if needed until I get it into the shop. 2/ I was driving 65 mph when the loud noise (phone gave a warning of decibal level not safe) - broken glass & glass 'dust' blowing on us / breathed in by us. The shock of it happening when surrounded by busy traffic on a highway. 3/I have made many calls into Hyundai to get it taken care of - they are not returning my calls. 4/I initially t…”
NHTSA complaint #11509107, 2023

Back Over Prevention 2 1 crash

“I was backing out of my driveway, which is on a busy street. I waited for the traffic to clear. I backed out onto the main road, which I thought was completely clear, but a car came behind me and I smacked right into him. There was no beeping from my car, and the automatic braking system did not engage at all. The rear of my car, particularly the driver's side, was severely damaged. The other car's passenger front door was badly damaged. The side curtain airbag on their car deployed and their vehicle (Volvo station wagon) was not driveable. The emergency braking system frequently engages…”
NHTSA complaint #11702099, 2025 · crash

“The contact owns a 2023 Hyundai Tucson. The contact stated that on three occasions while the vehicle was in park(P), the vehicle failed to shift into the intended gear. The vehicle was towed to a dealer where it was diagnosed and determined that the rear-view sensor needed to be replaced. The vehicle was repaired. On another occasion, while at a car wash the rear hatch opened inadvertently. On another occasion, while driving approximately 65 MPH, the Emergency Automatic Braking Display light was illuminated, and the vehicle slowed down inadvertently. The vehicle was not repaired. The manufactu…”
NHTSA complaint #11559099, 2023

Wheels 2

“2023 Hyundai Tuscon - Very Low Milage approx 6500 Miles - while in a parking lot, The rear passenger Carrier ARM which holds the Control arm fully cracked causing the Control arm to fall off. This product failure is unprecedented as it was a total part manufacture failure. NO impact or under carriage damage was found, even upon Dealer inspection. I as the driver of the vehicle confirm that No impact, accident occurred, and luckily I was not on a highway when it occurred. This was caused ONLY as a result of Product Failure. My concern is that this may occur on the other wheel(s) as a product fa…”
NHTSA complaint #11696535, 2025

“I previously leased my vehicle from Rick Case Hyundai in April 2023, In November i started having issues with my vehicle as i moved to Colorado. My whole vehicle starts to uncontrollably shake going 25 mph and over. Since highway speed limit is 65 that is where i struggle the most with driving and that is the most endangering as well. I have to pump my breaks and hope they don't stop working. I have taken my car to get a diagnostic multiple times at different dealerships and each time i went to another dealership they advised a different problem I can send an email or mail with all attachments…”
NHTSA complaint #11667129, 2023

Fuel System 1

“The contact owns a 2023 Hyundai Tucson. The contact stated that the fuel filler door failed to open as needed. The vehicle was taken to the dealer but was not yet diagnosed or repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 76,000.”
NHTSA complaint #11752477, 2026

Parking Brake 1

“The contact owns a 2023 Hyundai Tucson. The contact stated that after placing the vehicle in park(P) and exiting the vehicle, the vehicle inadvertently rolled backwards. The contact stated that the vehicle was equipped with Automatic Emergency Braking; however, the system failed to activate, resulting in damage to the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 22,000.”
NHTSA complaint #11569138, 2024

Suspension 1

“2023 Hyundai Tuscon - Very Low Milage approx 6500 Miles - while in a parking lot, The rear passenger Carrier ARM which holds the Control arm fully cracked causing the Control arm to fall off. This product failure is unprecedented as it was a total part manufacture failure. NO impact or under carriage damage was found, even upon Dealer inspection. I as the driver of the vehicle confirm that No impact, accident occurred, and luckily I was not on a highway when it occurred. This was caused ONLY as a result of Product Failure. My concern is that this may occur on the other wheel(s) as a product fa…”
NHTSA complaint #11696535, 2025

Tires 1