2023 Ford Expedition Problems & Owner Complaints

Electrical System 16 1 crash 1 fire

“Hurricane Helene inundated our parking lot on September 27 with approximately 3-4 feet of storm surge. Many vehicles (20-25) were trapped and flooded. This vehicle caught fire and was totally consumed over the course of a 5-6 hour burn. Although all vehicles in our lot were flooded, this was the only vehicle to catch fire. By reports of eyewitnesses, the fire started underwater at the front of the vehicle and proceeded to consume it entirely. It did not blow up. Also reported is that the flashers and alarm/horn were active when the fire started (same was true for most other vehicles in the…”
NHTSA complaint #11621500, 2024 · fire

“I crunk my 2023 Ford Expedition up yesterday so the AC would run and it wouldn’t be so hot. I pressed the break, and the start button and simply crunk it up, I then got the keys out of the vehicle so I could unlock my house. When I walked back outside My truck had rolled backwards and hit my house. The vehicle was in park. Now I have to fix my house and my truck and all of this is something that should have never happened and is extremely scary and dangerous. Thankfully I got into my house before it hit it because I may not have been so lucky considering my vehicle was to my back and coul…”
NHTSA complaint #11542513, 2023 · crash

“The contact owns a 2023 Ford Expedition. The contact stated that while parked and turned off, the vehicle suddenly started independently. The contact turned off the vehicle manually. The contact stated that the failure occurred twice. The dealer was contacted, and an appointment was scheduled; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 22,080.”
NHTSA complaint #11749505, 2026

Unknown Or Other 12 1 fire 5 injury

“On June 10, 2026, I attempted to enter my vehicle through the driver's door. The power running board was set to the "Automatic" position but failed to deploy when the driver's door was opened. I stepped toward the vehicle expecting the running board to be extended, as it normally would be, but it was not. As a result, I lost my footing and fell. The fall caused a nondisplaced fracture of my left ring finger, which required evaluation at an urgent care facility, X-rays, treatment by a hand specialist, and immobilization in a custom splint. Surgery was considered due to concern for possible rot…”
NHTSA complaint #11746778, 2026 · 1 injury(ies)

“The chrome in the middle console of my vehicle was peeling and cut my finger”
NHTSA complaint #11744138, 2026 · 1 injury(ies)

“The Panoramic Sunroof spontaneous combusted traveling 75 mph on the interstate. No debris, other vehicles, or overpasses in sight. The explosion and raining glass poses a safety concern. The vehicle is currently in the shop being inspected by the manufacturer, repair shop, insurance adjusters trying to decide who is going to cover the random exploding panoramic sunroof. If government environmental can require auto start stops be put on all consumer vehicles, it seems that the regulatory safety could do something about the overhead exploding glass that is both dangerous and costly.”
NHTSA complaint #11725469, 2026 · 1 injury(ies)

Power Train 11 1 crash

“I crunk my 2023 Ford Expedition up yesterday so the AC would run and it wouldn’t be so hot. I pressed the break, and the start button and simply crunk it up, I then got the keys out of the vehicle so I could unlock my house. When I walked back outside My truck had rolled backwards and hit my house. The vehicle was in park. Now I have to fix my house and my truck and all of this is something that should have never happened and is extremely scary and dangerous. Thankfully I got into my house before it hit it because I may not have been so lucky considering my vehicle was to my back and coul…”
NHTSA complaint #11542513, 2023 · crash

“Driving on highway, tried to accelerate, the car was acting like it was in neutral and would not accelerate. Checked to ensure I was not. the car began decelerating and I started to pull over. As I entered the brake down lane - the car automatically switched to park jarring the car to a stop. The dashboard provided the following fault "shift system fault service required" Tried shifting to drive, neutral, reverse and each time it would shift back to park and give me the warning. Had to have the car towed. The dealership is very vague on the root cause of the issue saying i need a ne…”
NHTSA complaint #11751175, 2026

“Service engine light illuminated indicating different occurrences. The vehicle was taken to a Ford dealership for repair since it's under factory warranty. The service representative, after taking control of the vehicle, he wrote the following in the repair work order: "When Brandon went to park the vehicle, vehicle did not want to go, barely pressed the throttle pedal and it took off like it was floored, foot was off the pedal and it was accelerating in the lot, put vehicle in neutral and applied brakes - see line 2" Line two (2) in the work order states the following: "Customer states…”
NHTSA complaint #11628143, 2024

Engine 6 2 fire

“On May 16, 2026, my 2023 Ford Expedition with 6,197 miles caught fire while I was driving home from work. I smelled smoke inside the cabin, and within moments smoke began coming through the air vents. I pulled over and exited the vehicle. When I got out, I saw the engine compartment was on fire and heavy smoke was coming from under the hood. As I moved away from the vehicle, there were multiple loud pops and bangs coming from the engine area. Police and fire crews responded and extinguished the fire, but the vehicle is a total loss. This was a nearly new vehicle with very low mileage. I beli…”
NHTSA complaint #11740156, 2026 · fire

“It made a loud boom I stopped thought it was a tire when I got out of the car flames started to come out of the driver side wheel well”
NHTSA complaint #11682727, 2025 · fire

“There is a shudder and whining noise with confused shifting gears behavior.”
NHTSA complaint #11640678, 2024

Vehicle Speed Control 6 3 crash 1 injury

“The contact owns a 2023 Ford Expedition. The contact stated that while the accelerator pedal was depressed, the vehicle inadvertently accelerated. As a result, the vehicle proceeded over the side curves then stalled. All the air bags deployed. No warning lights was illuminated. The contact sustained injury to his left arm that required medical attention. A police report was filed. The vehicle was not repaired. The vehicle was towed to a tow lot and deemed a total loss by the insurance company. The manufacturer was notified of the failure and the contact was provided a case number and advised t…”
NHTSA complaint #11552691, 2023 · crash · 1 injury(ies)

“The contact owned a 2023 Ford Expedition. The contact stated that while his wife was occupying the vehicle at the residence and attempting to park in the drive postion, the vehicle independently accelerated and crashed into the garage wall, causing damage to the garage wall, refrigerator, and storage cabinet. The brake pedal was depressed, but the vehicle was in full throttle and failed to stop. No warning light was illuminated. During the failure, the contact's wife was the only occupant inside the vehicle. In addition, the display screen went blank. The contact's wife had not sustained an in…”
NHTSA complaint #11705302, 2025 · crash

“At approximately 13:12 CST on [XXX], I exited the car wash at a gas station in Rochester, MN. I drove around to the front of the gas station to park so I could go inside to replenish the car wash card. At approximately 13:13 CST, as I was turning right, pulling into the parking space near the entrance, the truck accelerated unexpectedly and collided with a cement parking pilon (sp?). I am unsure how this occurred. I believe the vehicle may have accelerated on its own. Holding my foot hard on the brake, I shifted into reverse, then backed the truck up about 2 feet from the pilon, turned off…”
NHTSA complaint #11571218, 2024 · crash

Visibility 6

“The contact owns a 2023 Ford Expedition. The contact stated that while operating the vehicle, the front driver’s and passenger’s side electric mirrors could not be adjusted from the front driver’s door main switch. Additionally, the windows failed to roll up and to roll down while using the front driver’s door main switch. The contact stated that while in a parking garage, the front driver’s side window failed to roll down, and the driver was unable to immediately insert the parking garage ticket to exit the garage. The contact stated that the failure was intermittent. The vehicle was taken to…”
NHTSA complaint #11706720, 2025

“The contact owns a 2023 Ford Expedition. The contact stated while driving 75 MPH and taking an exit, the panoramic sunroof exploded without impact. The sunroof exploded from the inside going outward. The contact stated that the first panoramic slide had exploded, and the second sunroof was still intact. There was glass on the interior of the vehicle. There were no warning lights illuminated. There were no reported injuries. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 55,384.”
NHTSA complaint #11634270, 2025

“I was driving down the road. There were no other vehicles around me. I then heard, what sounded like someone shooting a gun from the middle row up through the sunroof. It was the most insanely loud noise, i had ever heard coming from a vehicle. I pulled over and realized that the sunroof had exploded. The glass was shattered and was protruding up. The glass then shattered, sending shards of glass to the interior of the vehicle over my son, elderly mother and myself. We were all so frightened.”
NHTSA complaint #11604555, 2024

Service Brakes 5

“While driving the ABS system failure warning along with 2 other system warnings come on and brakes fall to the floor. My Ford expedition is experiencing the same catastrophic electronic brake booster failure as recall 25S77. The dealer updated the software and the problem continued. Its back at the dealership after happening an additional 4 time and I'm being told it $2500 to replace the electronic brake booster. My VIN is not on the recall but in experiencing the exact life-threatening system failure.”
NHTSA complaint #11748150, 2026

“Vehicle: 2023 Ford Expedition XLT Max Component: Service Brakes / Hydraulic / Brake Pedal Description of the Problem: The vehicle experiences intermittent brake slippage that occurs randomly approximately 2–3 times per month. The issue happens while decelerating between 10–20 mph. When applying the brakes to slow down, the brake pedal suddenly travels further downward, as if the brakes slip or momentarily lose pressure. This significantly reduces braking confidence and control. The condition occurs without warning and is not driver-induced. When it happens, it feels as though the brakes may…”
NHTSA complaint #11711084, 2026

“While pulling out of a parking lot onto a 4 lane undivided city street, the vehicle flashed a warning light on the dash saying “Trailer Brakes Engaged” and the vehicle came to an abrupt stop in the lanes of active traffic narrowly avoiding a collision. As if the parking brake had set uncommanded. The vehicle was not and has never pulled a trailer since we’ve owned it the last 9 months. The engine was stalled but accessory was still on. After an off/on cycle the vehicle started and went into gear functioning normally. Immediately taken to a ford/Lincoln dealer. They inspected and told us they f…”
NHTSA complaint #11704788, 2025

Forward Collision Avoidance 4

“While pulling out of a parking lot onto a 4 lane undivided city street, the vehicle flashed a warning light on the dash saying “Trailer Brakes Engaged” and the vehicle came to an abrupt stop in the lanes of active traffic narrowly avoiding a collision. As if the parking brake had set uncommanded. The vehicle was not and has never pulled a trailer since we’ve owned it the last 9 months. The engine was stalled but accessory was still on. After an off/on cycle the vehicle started and went into gear functioning normally. Immediately taken to a ford/Lincoln dealer. They inspected and told us they f…”
NHTSA complaint #11704788, 2025

“The vehicle experienced a failure of multiple driver assistance and safety systems, with warning messages displayed in the instrument panel cluster. The affected systems include Adaptive Cruise Control, Automatic Emergency Braking, Blind Spot Warning, Forward Collision Warning, Lane Departure Warning, Lane Keeping Assistance, Parking Collision Warning, and Rear Cross Traffic Warning. All of these features are currently inoperative. During normal vehicle operation, messages indicated that driver assistance features were unavailable or malfunctioning. Diagnostic trouble codes related to invalid…”
NHTSA complaint #11707318, 2024

“The contact owns a 2023 Ford Expedition. The contact stated that while driving at various speeds with the Adaptative Cruise Control activated, the vehicle failed to decelerate automatically upon approaching another vehicle, requiring the contact to depress the brake pedal. The Pre-collision warning light was illuminated, and the vehicle made an abnormal beeping sound. The vehicle was taken to the dealer, and the contact was informed that the vehicle was operating as designed; however, the failure persisted. The vehicle was taken back to the dealer, where the contact was informed that a softwa…”
NHTSA complaint #11680963, 2024

Structure 4 1 injury

“The contact owns a 2023 Ford Expedition. The contact received notification of NTHSA Campaign Number 26V368000 (Structure); however, the part needed for the recall repair was not yet available. The contact stated that while reaching to pick up a debit card, the center console cup holder chrome plating, which had peeled off and stood upright, sliced the contact's pinky finger on her right hand. The deep gash required medical attention. No further information was available. The contact associated the injury with the recall. The local dealer was contacted. The contact stated that the manufacture…”
NHTSA complaint #11748729, 2026 · 1 injury(ies)

“I was driving on the freeway at a high rate of speed (65-70mph) and a piece of my roof rack broke off my car and flew off into the road. This could have hit a car behind us or harmed a person inside the car. Nothing hit my car to cause it to come off. I showed it to the dealer and they claimed that pieces of cars don't just fall off for no reason. They said they would file a claim for it to be covered under warranty. There was no warning prior to this happening.”
NHTSA complaint #11743299, 2026

“The contact owns a 2023 Ford Expedition. The contact stated that upon opening the front driver's side door, the contact became aware that the door hinges were fractured. The failure also occurred on the lower part of the front passenger's side door. The dealer was contacted, and the contact sent a picture of the failure to the dealer. The vehicle was not yet diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 62,305.”
NHTSA complaint #11718731, 2026

Fuel/Propulsion System 3 2 fire

“It made a loud boom I stopped thought it was a tire when I got out of the car flames started to come out of the driver side wheel well”
NHTSA complaint #11682727, 2025 · fire

“Hurricane Helene inundated our parking lot on September 27 with approximately 3-4 feet of storm surge. Many vehicles (20-25) were trapped and flooded. This vehicle caught fire and was totally consumed over the course of a 5-6 hour burn. Although all vehicles in our lot were flooded, this was the only vehicle to catch fire. By reports of eyewitnesses, the fire started underwater at the front of the vehicle and proceeded to consume it entirely. It did not blow up. Also reported is that the flashers and alarm/horn were active when the fire started (same was true for most other vehicles in the…”
NHTSA complaint #11621500, 2024 · fire

“There is a shudder and whining noise with confused shifting gears behavior.”
NHTSA complaint #11640678, 2024

Suspension 3 2 crash

“The contact owns a 2023 Ford Expedition. The contact stated while driving at 15 MPH, the contact heard a loud popping sound and the vehicle was pulled to the right. The front passenger’s side wheel assembly and wheel were detached. The contact stated that due to the failure, the contact's vehicle damaged two vehicles that were parked on the street. The Toyota Sienna was scratched and damaged on the driver’s side of the rim and the driver's side door and rearview mirror. In addition, the Kia Sportage was scratched and damaged to the driver’s side of the bumper and the driver’s side of the…”
NHTSA complaint #11622676, 2024 · crash

“I crunk my 2023 Ford Expedition up yesterday so the AC would run and it wouldn’t be so hot. I pressed the break, and the start button and simply crunk it up, I then got the keys out of the vehicle so I could unlock my house. When I walked back outside My truck had rolled backwards and hit my house. The vehicle was in park. Now I have to fix my house and my truck and all of this is something that should have never happened and is extremely scary and dangerous. Thankfully I got into my house before it hit it because I may not have been so lucky considering my vehicle was to my back and coul…”
NHTSA complaint #11542513, 2023 · crash

“UNKNOWN. Lots of vibration issues through the body and steering wheel shimmy. Whole cabin harmonic vibrations put new tires on and road force balanced. Still having issues. truck veers left and right without input when going over bumps. Steering wheel shimmy’s left and right when going over bumps. Transmission seems to lock up and release while going over bumps while stopping.”
NHTSA complaint #11548035, 2023

Lane Departure 2

“The vehicle experienced a failure of multiple driver assistance and safety systems, with warning messages displayed in the instrument panel cluster. The affected systems include Adaptive Cruise Control, Automatic Emergency Braking, Blind Spot Warning, Forward Collision Warning, Lane Departure Warning, Lane Keeping Assistance, Parking Collision Warning, and Rear Cross Traffic Warning. All of these features are currently inoperative. During normal vehicle operation, messages indicated that driver assistance features were unavailable or malfunctioning. Diagnostic trouble codes related to invalid…”
NHTSA complaint #11707318, 2024

“The contact owns a 2023 Ford Expedition. The contact stated that while driving at an undisclosed speed, the dashboard was reflecting the sun onto the windshield. The contact was unable to drive and utilize the flat panel display. The large flat panel display angle was in an awkward position to use. The screen contrast and readability were poor. The contact was concerned about the random software updates. Additionally, the touch screen display was difficult to maneuver due to the lack of buttons or knobs. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The ma…”
NHTSA complaint #11585239, 2023

Seat Belts 2

“The seatbelt strap malfunctioned ( locked) and and I was unable to loosen the straps .. resulting in having to cut the strap to get my child out”
NHTSA complaint #11699949, 2025

“Third row seat belt buckle warped and damaged. My child’s car seat was installed for normal cleaning and upon inspection was obviously warped compromising the safety of a small child. No warning lights on the dash indicated a seatbelt failure.”
NHTSA complaint #11604160, 2024

Steering 2

“While leasing this vehicle from Hertz via Priceline out of Seattle the vehicle was always was extremely difficult to keep in is own lane. Didn't matter if you were doing 20 mph or 60 mph. This was brought to Hertz via Priceline and they have not answered back to what the issues were other than saying no one else complained about it an apparently are investigating the problem. This vehicle was picked up on April 29,2026 from SeaTac and returned on May 4,2026. Neither Priceline did nothing but gave a $25 credit and Hertz will not answer any attempts to contact them.”
NHTSA complaint #11752250, 2026

“UNKNOWN. Lots of vibration issues through the body and steering wheel shimmy. Whole cabin harmonic vibrations put new tires on and road force balanced. Still having issues. truck veers left and right without input when going over bumps. Steering wheel shimmy’s left and right when going over bumps. Transmission seems to lock up and release while going over bumps while stopping.”
NHTSA complaint #11548035, 2023

Air Bags 1

“My "restraints indicator lamp warning" is going off occasionally. Ford just contacted me to tell me that my airbag will not deploy if needed.”
NHTSA complaint #11672675, 2025

Engine And Engine Cooling 1 1 fire

Firerelated 1 1 fire

Fuel System 1

“The contact owns a 2023 Ford Expedition. The contact stated while refueling the vehicle, the contact removed the pump nozzle from the filler neck and gasoline squirted out of the fuel filler neck. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 1,578. The VIN was not available.”
NHTSA complaint #11519065, 2023

Latches/Locks/Linkages 1

“The contact owns a 2023 Ford Expedition. The contact stated that the liftgate failed to open with the key fob remote or manually. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the sensor was inoperable. The vehicle was repaired, but the failure persisted. The vehicle was taken back to the dealer, who was unable to duplicate the failure. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.”
NHTSA complaint #11540243, 2023

Seats 1

“The contact owns a 2023 Ford Expedition. The contact stated that on every occasion while driving, she observed a loud rattling noise emanating from the second-row seats. Additionally, the contact stated that she observed the second-row headrests and the seat shaking while looking in the rear-view mirror. The vehicle was taken to a dealer where the vehicle was unable to be diagnosed. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately approximately 500.”
NHTSA complaint #11578962, 2023

Tires 1

“285/45/22 None of the tires will balance leading to terrible vibrations at highway speeds. Dealer tried several times to balance and also road force balance them. Vibrations can be dangerous at highway speeds.”
NHTSA complaint #11623733, 2024

Wheels 1

“The contact owns a 2023 Ford Expedition. The contact stated that there was an abnormal metal-to-metal sound coming from the front end of the vehicle while driving at slow speeds and downshifting. The contact stated there was something loose in the driver's side front wheel. There were no warning lights illuminated. The vehicle was taken to the local dealer four times, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The vehicle was taken to another local dealer, Gorno Ford Quick Lane (21111 Allen Rd., Woodhaven, MI 48183); on two occasions howeve…”
NHTSA complaint #11625431, 2023