2023 Chevrolet Blazer Problems & Owner Complaints

Engine 12 1 crash

“The driver-side half-shaft disengaged from the transmission. This caused a roll away of the vehicle when it is thought to be securely in "park" gear cuasing a frontal colisión.”
NHTSA complaint #11605819, 2024 · crash

“The vehicle’s radiator developed a coolant leak that was discovered and confirmed by the dealership during a routine oil change, tire rotation and state inspection. There were no warning lights, warning messages prior to the dealership discovering the leak. The radiator required replacement. The dealership also told me that they had the replacement radiator on hand because this type of radiator failure had been occurring fairly often with this type of vehicle. The radiator failure presented a potential safety concern because a coolant leak can worsen without warning and result in a sudden loss…”
NHTSA complaint #11754268, 2026

“The contact owns a 2023 Chevrolet Blazer. The contact stated that while driving 10 MPH and pulling into a parking lot, the sun gear and the drive shaft fractured. The vehicle became inoperable. The vehicle was pushed to a safe place. The check engine warning light illuminated after the failure. The contact associated the failure with NHTSA Campaign Number: 23V172000 (Power Train). The vehicle was towed on a flatbed to the local dealer. The vehicle was not diagnosed or repaired. The dealer provided an estimate for the transmission replacement. The manufacturer was contacted and confirmed that t…”
NHTSA complaint #11745894, 2026

Power Train 10

“The contact owns a 2023 Chevrolet Blazer. The contact stated that while driving 10 MPH and pulling into a parking lot, the sun gear and the drive shaft fractured. The vehicle became inoperable. The vehicle was pushed to a safe place. The check engine warning light illuminated after the failure. The contact associated the failure with NHTSA Campaign Number: 23V172000 (Power Train). The vehicle was towed on a flatbed to the local dealer. The vehicle was not diagnosed or repaired. The dealer provided an estimate for the transmission replacement. The manufacturer was contacted and confirmed that t…”
NHTSA complaint #11745894, 2026

“ON SEPTEMBER 10, 2025 THE TRANSMISSION FAILED FOR THE 3RD TIME WITHOUT WARNING. THIS TRANSMISSION ONLY LASTED ABOUT 5,500 MILES. WHEN IT FAILS, IT SIMPLY DOES SO WITHOUT WARNING. WHILE DRIVING IT WLL START SHUDDERING AND WHEN YOU STOP IT JUST WONT GO AFTER THAT. gm KNOWS THERE IS AN ISSUE WITH THESE 9 SPEED TRANSMISSIONS BECAUSE THEY ARE ON BACKORDER AND MY VEHICLE HAS BEEN IN THE SHOP FOR OVER TWO MONTHS WAITING ON PARTS. SINCE THIS IS THE 3RD FAILED TRANSMISSION UNDER WARRANTY, I CREATED A COMPLAINTWITH GM AND REQUESTED A BUY BACK BUT THEY REFUSED.”
NHTSA complaint #11699735, 2025

“On July 31st 2025 my vehicle would not sift out of first gear. I had vehicle towed to Kelly Chevrolet in [XXX] . After a failed repair attempt on August 18 2025 have been waiting on back ordered valve body part number 24045659. No eta on this part even though a transmission replacement would resolve but dealer refuses to replace. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)”
NHTSA complaint #11689364, 2025

Service Brakes 8 3 crash 1 injury

“The contact's father owns a 2013 Chevrolet Blazer. The contact stated that while his father was driving at approximately 40 MPH straight forward, the brake pedal was depressed, and it traveled to the floorboard. Then, the brake pedal was lifted, and the brake pedal traveled a second time to the floorboard. The vehicle did not slow down as intended, and the vehicle crashed into the rear of another vehicle. The air bag did not deploy, and no warning lights illuminated. The contact's father sustained a facial bruise. Medical attention was not needed. A police report was filed. The vehicle was tow…”
NHTSA complaint #11678513, 2025 · crash · 1 injury(ies)

“While my wife was pulling into park the car and pressing the brake, the car all of a sudden accelerated into the building. Pressing the brake failed to stop the car. No person was in the way of the car so no one other than my wife was at risk of injury. The problem has not been reproduced since the car was totaled. The car was inspected by the insurance for loss but that was it. Police and manufacturer have not inspected the car. No warnings were presented prior to the accident.”
NHTSA complaint #11622967, 2024 · crash

“The driver-side half-shaft disengaged from the transmission. This caused a roll away of the vehicle when it is thought to be securely in "park" gear cuasing a frontal colisión.”
NHTSA complaint #11605819, 2024 · crash

Electrical System 6

“"I am the owner of a 2023 Chevrolet Blazer RS. The digital odometer and speedometer screen intermittently crashes and goes completely black for 15 to 20 seconds while the vehicle is in motion on public roads. This creates an immediate safety hazard as I am left with zero knowledge of my current speed. General Motors has acknowledged this specific software stability bug under Technical Service Bulletin 22-NA-023 but refuses to fix the issue due to the vehicle being 9 days past its 3-year calendar warranty, despite having only 32,400 miles." I contacted your GM agent @ 800-222-1020 and was told…”
NHTSA complaint #11750847, 2026

“The vehicle has turned off twice while driving. Endangering the safety of everyone in the vehicle”
NHTSA complaint #11723647, 2026

“My bright lights do not go off when oncoming vehicles or vehicles in front of me are close and when they do dim they go on and off. People flash their brights at me causing me not to be able to sleep and this happens even when they turned off of auto. Another item of concern is that the car would lock and unlock and the interior lights would go on and off. This was fixed but it was a line under the front that was not soldered together at the manufacturer is what the Chevy dealership stated.”
NHTSA complaint #11715738, 2025

Steering 6

“The contact owns a 2023 Chevrolet Blazer. The contact stated that while driving, a code appeared on the dashboard P0128. When the vehicle's engine was switched off, the engine cooling fan continued to run. Warning light stating the steering would be disable.; however power steering was not lost. The vehicle was taken to a dealer where it was diagnosed with a thermostat failure. The manufacturer was notified of the failure. The approximate failure mileage was 48,000”
NHTSA complaint #11740828, 2026

“Re: Vehicle Safety Defect Complaint – 2023 Chevrolet Blazer To Whom It May Concern, I am submitting a formal safety defect complaint regarding my 2023 Chevrolet Blazer. This vehicle has exhibited multiple system failures that present a serious risk to driver safety and public roadway safety. The vehicle was purchased new on July 20, 2023. Beginning on April 21, 2025, at approximately 27,610 miles, the vehicle developed a progressive defect initially presenting as oil-related issues. Despite multiple repair attempts, the condition worsened and required a full engine replacement in January 2026.…”
NHTSA complaint #11734585, 2026

“My vehicle makes a clunk noise when the vehicle is in motion and i press on the accelerator it also makes a little jerk. This mainly happens @ low speeds and on a incline hill. There some type of oil or grease stains where the cv axle goes into transmission. ive felt my vehicle with less power and pulls to the left. Took the vehicle to chevrolet and they said they couldnt duplicate the issue or the oil leak.”
NHTSA complaint #11731998, 2026

Forward Collision Avoidance 5 1 crash

“The driver-side half-shaft disengaged from the transmission. This caused a roll away of the vehicle when it is thought to be securely in "park" gear cuasing a frontal colisión.”
NHTSA complaint #11605819, 2024 · crash

“The contact owns a 2023 Chevrolet Blazer. The contact stated that while driving at an undisclosed speed with no vehicles or objects nearby, the Forward Collision Avoidance system activated, and the Automatic Emergency Braking System engaged and brought the vehicle to a complete stop. Upon driving off, the vehicle then jerked and jolted. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who informed the contact that the vehicle functioned as intended during the time in the Service C…”
NHTSA complaint #11700596, 2025

“On February 14, 2025, at approximately 0700 hours, I was traveling southbound on XXX, approaching a left turn (eastbound) onto XXX. I was the first vehicle in the turn lane with no other vehicles or pedestrians in front of me. The road conditions were clear, dry, and cold. Upon receiving a green light to proceed with my left turn, I began to accelerate without issue. However, approximately halfway through the turn, my vehicle's pedestrian collision avoidance system was unexpectedly triggered. The red windshield alert light began flashing, accompanied by an audible warning, followed by hard br…”
NHTSA complaint #11645502, 2025

Exterior Lighting 4 1 injury

“The contact owns a 2023 Chevrolet Blazer. The contact stated that the power lift tailgate was lifted when the vehicle was parked, however after placing items into the rear of the vehicle, the tailgate mistakenly closed, hitting the contact in the eye. The contact sustained a left eye injury. Medical treatment was not needed. The was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 6,000.”
NHTSA complaint #11519821, 2023 · 1 injury(ies)

“My bright lights do not go off when oncoming vehicles or vehicles in front of me are close and when they do dim they go on and off. People flash their brights at me causing me not to be able to sleep and this happens even when they turned off of auto. Another item of concern is that the car would lock and unlock and the interior lights would go on and off. This was fixed but it was a line under the front that was not soldered together at the manufacturer is what the Chevy dealership stated.”
NHTSA complaint #11715738, 2025

“The contact owns a 2023 Chevrolet Blazer. The contact stated that there was a dark shadow and circle on the headlight while driving at various speeds. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 14,000.”
NHTSA complaint #11598335, 2024

Fuel/Propulsion System 3

“Re: Vehicle Safety Defect Complaint – 2023 Chevrolet Blazer To Whom It May Concern, I am submitting a formal safety defect complaint regarding my 2023 Chevrolet Blazer. This vehicle has exhibited multiple system failures that present a serious risk to driver safety and public roadway safety. The vehicle was purchased new on July 20, 2023. Beginning on April 21, 2025, at approximately 27,610 miles, the vehicle developed a progressive defect initially presenting as oil-related issues. Despite multiple repair attempts, the condition worsened and required a full engine replacement in January 2026.…”
NHTSA complaint #11734585, 2026

“Engine light on caused by emission system failure. Sensor unable to be changed until recall. Remote start unavailable while engine light is on. Had issue. Looked at four times at dealership. No correction taken.”
NHTSA complaint #11639810, 2025

“I purchased this car in May 2023.Since day 1 one the car stalls after filling and out of nowhere. Can be sitting still or going down the highway and highway sped. I took it on snd they could not find anything. Was told to keep track of when it happens. After almost being rear ended several tons and being put in extreme safety I called them and took it back in . They have now had since 9/21/2023 saying they’re some kid of valve problem in the gas tank. So I am paying for a brand new car that is unsafe to drive and is at the dealer for who knows how long .”
NHTSA complaint #11547691, 2023

Unknown Or Other 2 1 crash

“While my wife was pulling into park the car and pressing the brake, the car all of a sudden accelerated into the building. Pressing the brake failed to stop the car. No person was in the way of the car so no one other than my wife was at risk of injury. The problem has not been reproduced since the car was totaled. The car was inspected by the insurance for loss but that was it. Police and manufacturer have not inspected the car. No warnings were presented prior to the accident.”
NHTSA complaint #11622967, 2024 · crash

“My vehicle makes a clunk noise when the vehicle is in motion and i press on the accelerator it also makes a little jerk. This mainly happens @ low speeds and on a incline hill. There some type of oil or grease stains where the cv axle goes into transmission. ive felt my vehicle with less power and pulls to the left. Took the vehicle to chevrolet and they said they couldnt duplicate the issue or the oil leak.”
NHTSA complaint #11731998, 2026

Air Bags 1 1 crash 1 injury

“The contact's father owns a 2013 Chevrolet Blazer. The contact stated that while his father was driving at approximately 40 MPH straight forward, the brake pedal was depressed, and it traveled to the floorboard. Then, the brake pedal was lifted, and the brake pedal traveled a second time to the floorboard. The vehicle did not slow down as intended, and the vehicle crashed into the rear of another vehicle. The air bag did not deploy, and no warning lights illuminated. The contact's father sustained a facial bruise. Medical attention was not needed. A police report was filed. The vehicle was tow…”
NHTSA complaint #11678513, 2025 · crash · 1 injury(ies)

Engine And Engine Cooling 1

“The contact owns a 2023 Chevrolet Blazer. The contact stated that while driving, a code appeared on the dashboard P0128. When the vehicle's engine was switched off, the engine cooling fan continued to run. Warning light stating the steering would be disable.; however power steering was not lost. The vehicle was taken to a dealer where it was diagnosed with a thermostat failure. The manufacturer was notified of the failure. The approximate failure mileage was 48,000”
NHTSA complaint #11740828, 2026

Lane Departure 1

“The contact owns a 2023 Chevrolet Blazer. The contact stated while driving at an undisclosed speed, the Lane Keep Assist feature steered the vehicle to the left while the vehicle was driving inside the lane. The Lane Keep Assist warning light was illuminated. Additionally, the vehicle also experienced a loss of power steering assist. The contact stated that the failure occurred after the vehicle drove over a pothole. The contact also stated that the dealer had previously replaced the front-end bracket after another vehicle struck the front end while the vehicle was parked and unoccupied in a p…”
NHTSA complaint #11668579, 2025

Tires 1

“The contact owns a 2023 Chevrolet Blazer. The contact stated while driving at an undisclosed speed, the Lane Keep Assist feature steered the vehicle to the left while the vehicle was driving inside the lane. The Lane Keep Assist warning light was illuminated. Additionally, the vehicle also experienced a loss of power steering assist. The contact stated that the failure occurred after the vehicle drove over a pothole. The contact also stated that the dealer had previously replaced the front-end bracket after another vehicle struck the front end while the vehicle was parked and unoccupied in a p…”
NHTSA complaint #11668579, 2025

Vehicle Speed Control 1

“The contact owns a 2023 Chevrolet Blazer. The contact stated that while driving approximately 50 MPH, the vehicle experienced unintended acceleration and the speed increased to over 70 MPH. The contact indicated that while depressing the brake pedal the vehicle failed to slow as needed and the parking brake was activated to eventually stop the vehicle. The vehicle was later towed to the local dealer who was unable to determine or confirm the unintended acceleration failure. The contact was informed that the brake rotors and brake pads needed to be replaced due to excessive wear. The contact st…”
NHTSA complaint #11515521, 2023