2022 Toyota RAV4 Problems & Owner Complaints

Electrical System 34 1 crash 2 injury 2 death

“The contact is an attorney concerned about a crash involving a 2022 Toyota Rav4. The attorney stated that the vehicle had a comma.ai device installed on the vehicle. The attorney stated that while 2 couples were occupying the vehicle and driving at night on an expressway, there was a police vehicle on the side of the road responding to a separate vehicle crash. The driver of the vehicle may have been asleep, along with the front passenger, while relying on the comma.ai device to operate the vehicle. The vehicle failed to engage the brakes in order to avoid crashing into the police vehicle, and…”
NHTSA complaint #11728650, 2026 · crash · 2 death(s)

“COMPONENT: ELECTRICAL SYSTEM / TELEMATICS (DCM)The vehicle suffers from a documented manufacturing defect involving the Data Communication Module (DCM/Telematics system, Calibration N01D14B4644). The module enters an infinite transmission loop when the vehicle is turned off, causing a severe parasitic battery drain that repeatedly drops the 12V auxiliary battery below operational voltage.This creates a severe safety hazard, causing total electrical failure and leaving the driver unexpectedly stranded without warning, presenting an immediate safety risk in extreme weather or unsafe locations.An…”
NHTSA complaint #11749469, 2026

“Our 3 yrs old + Toyota RAV4 Hybrid SUV with barely over 30,000 miles on it had 2 safety issues within 2 months of each other! First was the driver's side mirror- it was rattling, feeling like it might fall off! Seems common issue, perhaps due to cheap plastic parts inside. We had it fixed- Toyota Brand Engagement Center gave a 'Goodwill' gesture to cover us replacing it at Dealership, though it should never have happened on such a newer vehicle in the first place! Then not even 2 months later, a Warning flashed- "Pre Collision System Malfunction!" Also "Headlights" with same warning- "SEE DEAL…”
NHTSA complaint #11746585, 2026

Unknown Or Other 34 1 crash

“On 11-9 the vehicle had an unintended acceleration that resulted in a collision. The vehicle was brand new. On 11-8 the vehicle had another unintended acceleration with a different driver where no collision was involved. Toyota is ignoring the problem.”
NHTSA complaint #11495306, 2022 · crash

“The sunroof shattered while I was driving. There were no other vehicles around me or on the street. I heard a loud bang and glass rained down on me. The glass is pitched upward like it exploded from the inside. There is no other damage to my car. I had no warning other than the loud bang. When I am not out, my car is in a garage it never sits outside.”
NHTSA complaint #11729230, 2026

“When I put my car on park. The driver side (left door) lock actuator makes a long click noise. Also when I press on unlock it makes that sound as well”
NHTSA complaint #11729109, 2026

Engine 26 1 crash

“We were traveling across country from Michigan to Arizona. We were 50 miles outside Tucson, AZ on [XXX]. Traveling 80 mph in a 75 mph zone, in passing lane and felt like car exploded and all airbags deployed and we came to a quick stop. No major injuries to either of us. One vehicle incident, did not collide with anything or hit any debris. It was a clear day, road conditions good, no noises, lights etc. My husband was able to keep from rolling and we came to a stop with many semi's etc flying by, very scary. When we were able to safely get out and call 911, there was significant drivers side…”
NHTSA complaint #11722251, 2026 · crash

“The contact owns a 2022 Toyota Rav4. The contact stated that the economy feature disengaged while driving. While the lane assist was activated, the vehicle drifted over into another lane. The engine was revving and backfired. The vehicle lost motive power while driving at undisclosed speeds. The driver's side windshield had a glaze or wax on the outside. While idling, the vehicle surged forward. The driver hovered a foot over the brake pedal. The vehicle was taken to the local dealer but was not diagnosed or repaired. The vehicle was taken to several dealers, AutoNation Toyota Winter Park Serv…”
NHTSA complaint #11751482, 2026

“TSB T-SB-0010-24 P0303 code 163,000 miles Toyota denied goodwill assistance Cost: $2,549.65 Check engine light came on with vehicle hesitation on acceleration almost caused to stall with reduced power while driving , the dealership diagnosed the issue as TSB T-SB-0010-24 with cylinder #3 misfire requiring exhaust valve lash adjuster to be replaced. Contacted Toyota corporate to request help with goodwill or discount , was denied , was told they couldn't help no reason given .This issue is a well know Toyota RAV4 defect and even though they claim it only happens when is cold this happened to m…”
NHTSA complaint #11740904, 2026

Steering 18 1 crash 2 injury

“The contact owned a 2022 Toyota RAV4. The contact stated that while driving at approximately 20 MPH, the steering wheel independently veered in the right direction. As a result, the vehicle crashed into an unoccupied parked vehicle. The contact's vehicle flipped twice and the driver's side of the vehicle was severely damaged. The air bags deployed. The contact and the back seat passenger received medical treatment. The contact sustained a lower back injury and heart issues, and the passenger sustained a bump on the head. A police report was filed. The vehicle was towed to the contact's residen…”
NHTSA complaint #11583407, 2023 · crash · 2 injury(ies)

“After driving for approximately 30-minutes in a heavy rain i pulled over and the automatic engine shutoff feature activated while i was waiting to go inside for an appointment. When attempting to restart the car, the engine would start but then shut off showing a "low power steering" warning message on my dash. The problem persisted for approximately 15-20 minutes. Eventually after about 10 attempts to restart the engine, the car started back up and drove fine the rest of the day. I have heard of this happening to many other rav4s on the Autosafety.org website and it causes me concern, especi…”
NHTSA complaint #11746188, 2026

“The steering will drift or pull to the side while driving down the road.”
NHTSA complaint #11733111, 2026

Structure 18 1 crash 2 injury

“My wife and I were traveling down SR74 mp 12 and rear ended a cow at 68 miles per hour. The airbags did not deploy from impact and yet the car is totaled the hood started through the safety glass of the windshield.”
NHTSA complaint #11577399, 2024 · crash · 2 injury(ies)

“The contact owns a 2022 Toyota RAV4. The contact stated that while driving at various speeds during rainy weather conditions, water would leak inside the front driver-side door and puddle. The vehicle was taken to a local dealer, where it was diagnosed with a deteriorated sealant. The vehicle was repaired. In addition, the contact stated that while driving at various speeds during rainy weather conditions, water would intrude into the rear driver-side door and would accumulate inside. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to costs. The manufactu…”
NHTSA complaint #11740660, 2026

“When I put my car on park. The driver side (left door) lock actuator makes a long click noise. Also when I press on unlock it makes that sound as well”
NHTSA complaint #11729109, 2026

Air Bags 10 8 crash 7 injury

“My wife and I were traveling down SR74 mp 12 and rear ended a cow at 68 miles per hour. The airbags did not deploy from impact and yet the car is totaled the hood started through the safety glass of the windshield.”
NHTSA complaint #11577399, 2024 · crash · 2 injury(ies)

“1.Airbag did not deploy but it did pop up from steringwheel and there is powder present. 2. Service at the dealership told me based on description that it is airbag failure and that there is no recalls for such on my car. 3.The vehicle is seating at the wrecker yard. UNKNOWN what if any inspections have been done. 4.No warning lights prior”
NHTSA complaint #11688800, 2025 · crash · 1 injury(ies)

“The contact owns a 2022 Toyota RAV4. The contact stated that a sudden complete stop on a major roadway was necessary due to a turtle crossing, and the vehicle in front was at a complete stop and exited the vehicle in their attempt to remove the turtle from the road. A third vehicle coming from the rear failed to slow down and was driving at 55 MPH, crashed into the rear of the contact. As a result, the contact rear-ended the vehicle in front, which was unoccupied due to the attempt of a turtle removal from the roadway. The contact mentioned that the seat belt did not retract during the impact.…”
NHTSA complaint #11654978, 2025 · crash · 1 injury(ies)

Forward Collision Avoidance 10 3 crash 2 injury

“My wife and I were traveling down SR74 mp 12 and rear ended a cow at 68 miles per hour. The airbags did not deploy from impact and yet the car is totaled the hood started through the safety glass of the windshield.”
NHTSA complaint #11577399, 2024 · crash · 2 injury(ies)

“Truck hits a car that car lose control and drive in front of my wife wile driving she crash and the only messege apear on dash panel was air bag system malfunction my car is a Rav4 2022, before the crash lights like tps control come on and off”
NHTSA complaint #11692322, 2025 · crash

“Problemas con el sistema de precolosion falla del sensor el carro es inseguro e tenido 2 incidentes donde el sistema no responde ni se activa antes del impacto problemas con el motor, estabilidad del carro, conteo de velocidad, frenos, llantas, cruze de carriles, puntos ciegos”
NHTSA complaint #11561028, 2022 · crash

Power Train 10 1 crash 1 injury

“I was at stop position. i pressed the hold button and then took my foot off the break. when traffic started moving i pressed the hold button again with my foot still on floor the car started jumping and pressing the the two other car on my front. the two other cars got totaled.”
NHTSA complaint #11527993, 2023 · crash · 1 injury(ies)

“Driving up a slope of about 20-30 degrees gradient of a straight lane going into a private parking lot. Braked and decided to make a 3-point turn to get back out. There was no traffic in the lane. Put gear on reverse while on the slope with the vehicle pointing in the up direction of the slope. Vehicle suddenly surge backwards, accelerating. Vehicle sped down the slope and crossed a street. Could not stop. Vehicle was stopped only after placing gear into park from reverse, and after jumping curb across the street. Fortunately, there were no cross traffic in either direction on the street, othe…”
NHTSA complaint #11714277, 2026

“It’s been raining for about 4-5 hours by now, I drove to church (1 hour drive) left my car outside in the parking lot in the rain while I was there. Then drove home (another 1 hour) and when I came home just now I sat in my car parked with the engine on for about 5 minutes when suddenly the car started shaking and then it turned off with a message “Engine Stopped - Power Steering Low, ignition on” on my 2022 Toyota RAV4 XLE. I think this issue needs to be investigated ASAP as it is a big safety concern, what if it happened when I was driving on the highway in the rain, at night? My Google and…”
NHTSA complaint #11639786, 2025

Fuel/Propulsion System 9

“I was driving home in the rain for about 75 minutes and when I arrived in my driveway I saw steam coming from the front grille area. It wasn't due to a high engine coolant temperature so I decided to carefully open the hood and check for the source. I saw water inside the bottom of the engine bay behind the radiator steaming from the heat of the engine. A few seconds later, the engine stalled and the following message appeared: "Engine Stopped, Steering Power Low" which came on with a check engine light, red battery light, and steering light. I used my scan tool and obtained the code: P0171, S…”
NHTSA complaint #11719600, 2026

“Fuel Injector failed, causing the engine to run extremely rich, misfire, and cause severe drivability issues. Issue occurred just outside vehicle base warranty. Problem was verified and confirmed by vehicle dealership. MIL was illuminated when drivability issue and malfunction started.”
NHTSA complaint #11603374, 2024

“On 11/15/23 I went to Byers Toyota Dealership and asked them to check my car due to the gas smell inside of the car when driven and outside of my car when parked for a longer period of time. The smell is coming from the rear. The car also has a very strong gas smell when the tank is open to pump gas. I did not notice any leaks. On the visit on 11/1523, they fixed the leaking evaporator according to your bulletin from May 2023 to alleviate the burning oil smell coming from my car’s HVAC heater.  They also checked the fuel pump and told me that I have the correct one and it should function as de…”
NHTSA complaint #11567672, 2023

Service Brakes 7 1 crash 1 injury

“I was at stop position. i pressed the hold button and then took my foot off the break. when traffic started moving i pressed the hold button again with my foot still on floor the car started jumping and pressing the the two other car on my front. the two other cars got totaled.”
NHTSA complaint #11527993, 2023 · crash · 1 injury(ies)

“I have taken vehicle to Toyota service center numerous times and showed them what the vehicle is doing and they are telling me it’s normal. Its not normal when every bump, manhole, railroad tracks you hit in the road with your foot on the brake when your trying to slow down when the abs or traction control is activated and the car skids forward and comes close to causing a crash. When that is activated sounds like a electric grinding noise is activated. I only have videos no pictures”
NHTSA complaint #11635315, 2025

“While driving in stop-and-go traffic on a major highway, the auto braking system engaged and the brake would not release. The car came to an abrupt halt and the brake would not release, the gas pedal would not depress. I had to turn the car off, place the car in park and restart the car, the car then continued driving. There was a message on the dash about EPB.”
NHTSA complaint #11619738, 2024

Vehicle Speed Control 6 2 crash 1 injury

“I was at stop position. i pressed the hold button and then took my foot off the break. when traffic started moving i pressed the hold button again with my foot still on floor the car started jumping and pressing the the two other car on my front. the two other cars got totaled.”
NHTSA complaint #11527993, 2023 · crash · 1 injury(ies)

“Problemas con el sistema de precolosion falla del sensor el carro es inseguro e tenido 2 incidentes donde el sistema no responde ni se activa antes del impacto problemas con el motor, estabilidad del carro, conteo de velocidad, frenos, llantas, cruze de carriles, puntos ciegos”
NHTSA complaint #11561028, 2022 · crash

“Driving up a slope of about 20-30 degrees gradient of a straight lane going into a private parking lot. Braked and decided to make a 3-point turn to get back out. There was no traffic in the lane. Put gear on reverse while on the slope with the vehicle pointing in the up direction of the slope. Vehicle suddenly surge backwards, accelerating. Vehicle sped down the slope and crossed a street. Could not stop. Vehicle was stopped only after placing gear into park from reverse, and after jumping curb across the street. Fortunately, there were no cross traffic in either direction on the street, othe…”
NHTSA complaint #11714277, 2026

Lane Departure 5

“The contact owns a 2022 Toyota Rav4. The contact stated that the economy feature disengaged while driving. While the lane assist was activated, the vehicle drifted over into another lane. The engine was revving and backfired. The vehicle lost motive power while driving at undisclosed speeds. The driver's side windshield had a glaze or wax on the outside. While idling, the vehicle surged forward. The driver hovered a foot over the brake pedal. The vehicle was taken to the local dealer but was not diagnosed or repaired. The vehicle was taken to several dealers, AutoNation Toyota Winter Park Serv…”
NHTSA complaint #11751482, 2026

“Our 3 yrs old + Toyota RAV4 Hybrid SUV with barely over 30,000 miles on it had 2 safety issues within 2 months of each other! First was the driver's side mirror- it was rattling, feeling like it might fall off! Seems common issue, perhaps due to cheap plastic parts inside. We had it fixed- Toyota Brand Engagement Center gave a 'Goodwill' gesture to cover us replacing it at Dealership, though it should never have happened on such a newer vehicle in the first place! Then not even 2 months later, a Warning flashed- "Pre Collision System Malfunction!" Also "Headlights" with same warning- "SEE DEAL…”
NHTSA complaint #11746585, 2026

“The Blind Spot Warning system fails to alert the driver when a vehicle in the adjacent lane is partially behind the current vehicle. It only activates when the nearby vehicle is completely behind the current vehicle. Due to this limitation, the system does not provide adequate warnings for nearby vehicles, which has nearly caused several accidents when the driver attempted to change lanes.”
NHTSA complaint #11589842, 2023

Seat Belts 5 2 crash 1 injury

“The contact owns a 2022 Toyota RAV4. The contact stated that a sudden complete stop on a major roadway was necessary due to a turtle crossing, and the vehicle in front was at a complete stop and exited the vehicle in their attempt to remove the turtle from the road. A third vehicle coming from the rear failed to slow down and was driving at 55 MPH, crashed into the rear of the contact. As a result, the contact rear-ended the vehicle in front, which was unoccupied due to the attempt of a turtle removal from the roadway. The contact mentioned that the seat belt did not retract during the impact.…”
NHTSA complaint #11654978, 2025 · crash · 1 injury(ies)

“Truck hits a car that car lose control and drive in front of my wife wile driving she crash and the only messege apear on dash panel was air bag system malfunction my car is a Rav4 2022, before the crash lights like tps control come on and off”
NHTSA complaint #11692322, 2025 · crash

“The drivers side front seat belt buckle will not latch. There is no dirt or other debris in the latch to stop it from functioning.”
NHTSA complaint #11739557, 2026

Visibility/Wiper 5

“The panoramic moonroof on my 2022 Toyota RAV4 spontaneously shattered and exploded outward at approximately 2:09 PM on June 21, 2026 while my wife was driving and exiting the freeway. There was a loud bang, followed by glass shards ejecting primarily outward onto the roof with a pattern showing the glass failed/bent from the inside out. The outer glass panel broke into multiple large sections with a clean perimeter failure and no visible external impact point or road debris damage. This created an immediate safety hazard: loud distraction while driving at highway speeds, flying glass, and sudd…”
NHTSA complaint #11745498, 2026

“APPEARS TO BE A MANUFACTURING DEFECT. SIDE DOORS BACK AND FRONT FILL WITH WATER. WINDOWS ROLLED UP AND DOWN HAVE STREAKS OF WATER(WET ALL THE TIME). WATER POURS OUT OF DOOR FRAMES. SLOSHING OF WATER IN DOORS. CAR HAS NO MORE THAN 15,000 MILES ON IT. ALWAYS KEEP COVERED IN GARAGE. CAR DOES NOT ACCUMULATE DEBRIS OR LEAVES. HAVE TAKEN INTO TOYOTA PALO ALTO TWICE NOW. NO REAL HELP. CANNOT SEE WELL FROM WINDOWS - SAFETY ISSUE AS SIDE WINDOWS STAY STREAKED OBSCURING VIEW AND MOLD CONCERNS WITH WET INTERIOR DOORS.”
NHTSA complaint #11643227, 2025

“I just want it in writing that my windshield just randomly cracked. It was parked and nothing hit it and it just cracked.”
NHTSA complaint #11499826, 2022

Latches/Locks/Linkages 2

“The automatic locking system stopped working for 2 of my doors. Front passenger and back driver sides no longer lock or unlock. This poses a serious risk considering I live near the ghetto and my car has already been broken into.”
NHTSA complaint #11746924, 2026

“I am submitting this complaint to report a known and widespread safety defect involving the door lock actuators on my Toyota RAV4. My vehicle’s door actuators have failed at approximately 39,000 miles, just outside the 3‑year/36,000‑mile warranty. This failure prevents the doors from locking and unlocking properly, which poses a significant safety hazard while driving, especially in emergency situations. When I brought the issue to Beechmont Toyota, the dealership refused to repair the defect under goodwill or warranty consideration. I spoke with Stacy Meyer, Assistant Service Manager [XXX]…”
NHTSA complaint #11737471, 2026

Suspension 2

“Loud clunk over bumps, suspension sounds loose and dangerous. Vehicle was purchased new and has 24,443 miles, this sound is NOT normal for a new vehicle.”
NHTSA complaint #11582476, 2024

“6/15/23 @ 18,357 miles the car was given a four wheel alignment at the owners request. Due to loud tire noise and visible cupping on the right rear inside edge, it was clear the car's wheel alignment was wrong. The dealer's before and after alignment is attached. When presented the before and after, I noted RR Camber was.-2.3 vs. a range of -1.8 to -0.3 degrees. The reading was unchanged from initial. They advised me the camber cannot be adjusted and is "fixed" from the Factory. The form also read "One of more value are not within specification. Tire wear, handling and safety problems…”
NHTSA complaint #11571098, 2023

Tires 2

“Tire split on the inside of the tire wall about 1 inch up. Less than 20,000 miles on them. I do not believe this is normal. 225/60 R18. Car was serviced by Toyota on March 21st.”
NHTSA complaint #11583412, 2024

“Tire size:225 65/17 While driving the side of a brand new tire blew out. We had three passengers in the vehicle that could have been in danger if we were going at a greater speed. We took the new tire in and was told by the auto shop that it could not be repaired. We had to purchase a new one and I have the invoice. I try to resolve this with Firestone but according to them, the tire was not under warranty. The new tire only had 5000 miles and it is a tread of at least 60,000 miles.”
NHTSA complaint #11514777, 2023

Wheels 2 1 crash

“We were traveling across country from Michigan to Arizona. We were 50 miles outside Tucson, AZ on [XXX]. Traveling 80 mph in a 75 mph zone, in passing lane and felt like car exploded and all airbags deployed and we came to a quick stop. No major injuries to either of us. One vehicle incident, did not collide with anything or hit any debris. It was a clear day, road conditions good, no noises, lights etc. My husband was able to keep from rolling and we came to a stop with many semi's etc flying by, very scary. When we were able to safely get out and call 911, there was significant drivers side…”
NHTSA complaint #11722251, 2026 · crash

“My steering wheel has been peeling/flaking off and it’s only 3 years old and my USB plug in inconsistent and turns off or doesn’t work will cords.”
NHTSA complaint #11710176, 2025

Back Over Prevention 1 1 crash

“Problemas con el sistema de precolosion falla del sensor el carro es inseguro e tenido 2 incidentes donde el sistema no responde ni se activa antes del impacto problemas con el motor, estabilidad del carro, conteo de velocidad, frenos, llantas, cruze de carriles, puntos ciegos”
NHTSA complaint #11561028, 2022 · crash

Equipment 1

“The contact owns a 2022 Toyota RAV4. The contact stated that the infotainment system was not functioning as designed. The system continued to reboot and flash, the screen went blank, and it failed to stay connected. There were no warning lights illuminated. The contact was concerned about breaking the law by using her phone while driving. The vehicle was taken to a local dealer, where it was diagnosed that the infotainment system needed to be replaced; however, the vehicle was not repaired.The vehicle was then taken to another local dealer, Rohrich Toyota Parts & Toyota Service (2020 W Liberty…”
NHTSA complaint #11748707, 2023

Visibility 1

“The contact owns a 2022 Toyota Rav4. The contact stated that while driving at an undisclosed speed, she noticed that the front windshield started to form a crack from the front passenger’s side over to the driver’s side of the windshield. The contact stated that the crack had formed without an impact to the windshield. The vehicle was not diagnosed nor repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was 2,963. The VIN was unavailable.”
NHTSA complaint #11492960, 2022