2022 Ford Maverick Problems & Owner Complaints

Electrical System 41 1 crash

“When the battery voltage suddenly drops the vehicle loses its power steering making slow speed turns extremely difficult. This poses a serious risk of the inability to control the direction of the vehicle and this makes a crash extremely probable.”
NHTSA complaint #11732082, 2026 · crash

“Due to go to dealership to inspect steering wheel”
NHTSA complaint #11745687, 2026

“I was trying to turn and the wheel kept kicking back the other direction. About a week prior to this as I was driving down the road all of a sudden the wheel threw me across a median and into incoming traffic almost causing multiple accidents. I have a video of it but it won’t allow me to upload it. [XXX] However this link should play it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)”
NHTSA complaint #11737585, 2026

Power Train 38

“I had stopped at an intersection and when I applied the gas, the truck stuttered a bit before going. It ran okay for less than a mile. I stopped at the next intersection and when I applied the gas, the truck shuttered, started to go then just stopped. It stayed running but didn't want to go. I was able to get it through the intersection but that was it. The message i am getting is powertrain malfunction/reduced power. When we put our diagnosis tool on it, we get code P0757.”
NHTSA complaint #11752946, 2026

“I am filing a formal safety defect complaint regarding a severe catastrophic transmission failure on my 2022 Ford Maverick ( 2.0L EcoBoost 8f35 8 speed transmission ) that poses an immediate safety hazard to occupants and sharing traffic. Upon inspection a heavy volume of metal shavings flakes were discovered also the code PO73D unable to engage in neutral came up. The safety risk of this specific failure is extreme because the vehicle is physically unable to respond to a neutral command the driver cannot clear or cut engine power to the drive wheels during an emergency mechanical malfunction…”
NHTSA complaint #11746600, 2026

“Transmission started slipping. Not wanting to pull in drive or reverse”
NHTSA complaint #11741076, 2026

Unknown Or Other 22 1 crash 1 injury

“EL DIA 21 DE MARZO DEL 2022 LLEGANDO A MI CASA Y PARA SER BIEN ESPECIFICA FRENTE A MI CASA ME ESTABA ACOMODANDO PARA COLOCAR EN RIVERSA MI GUAGUA Y LA MISMA SE ACELERO SOLA Y LOS FRENOS NO LE FUNCIONARON, CAUSANDO QUE ME FUERA POR UN RISCO. LOS AIR BAGS NUNCA LE ABRIERON.”
NHTSA complaint #11464070, 2022 · crash · 1 injury(ies)

“The chrome tips on the window switch fell off and jammed itself in the switch, in the on position for the passenger window. These exact parts are already on recall for different Ford models but it is the same part number being used.”
NHTSA complaint #11739007, 2026

“This is a complaint of Sheridan Ford in Wilmington DE specifically refusing to complete the recall without my paying out of pocket. Manufacturer Recall Number24S59 NHTSA Recall Number24V684 was left incomplete because they demanded I pay for a "diagnostic" fee on a known safety issue - this dealership is taking advantage of a saftey recall that is required to force customers to pay”
NHTSA complaint #11714442, 2026

Structure 15 1 crash 1 injury

“I was involved in an accident. During the accident none of the airbags deployed. The impact was so hard that it lifted the truck up off the ground and spinned us around 90 degrees. This resulted in the individuals seated on the passenger side of the truck to be thrown into the door fairly hard, with one passenger hitting her head on the window even with the seatbelt on. The point of impact was the drivers side back tire and bumper area.”
NHTSA complaint #11619483, 2024 · crash · 1 injury(ies)

“The driver's side (left front) door failed at the check-arm attachment point inside the door assembly: the spot welds securing the check-arm reinforcement bracket to the inner door structure cracked and separated. The vehicle is a commercial fleet 2022 Ford Maverick XL SuperCrew with approx. 82,000 miles. The vehicle and failed component are available for inspection upon request. First symptoms were difficulty opening and closing the door with popping/cracking noises. No warning lamps or messages occurred; the failure is concealed inside the door. This is a safety risk because the check arm a…”
NHTSA complaint #11751291, 2026

“Driver side door limiter welds broke loose. Ford said they had to replace the entire door and it was not covered by warranty. The dealer said that this happened to a bunch of Ford Escapes, but they did not have a recall for the Maverick yet.”
NHTSA complaint #11723780, 2026

Engine 14 1 fire

“Truck smelled funny, pulled over to check it out. Got out truck and noticed it was on fire from engine.”
NHTSA complaint #11682511, 2025 · fire

“When driving at normal speed, my truck completely shut down with no warning. The instrument panel went dark and the engine shut off. I do not believe I was able to steer, though I think the brakes allowed me to slow the vehicle to a stop. I was near an intersection, so I was lucky to not have been hit from the rear or run in to traffic in front of me. The vehicle was unresponsive and would not turn back on. I was stuck blocking 1 lane of traffic for an hour because the vehicle could not be steered or taken out of gear to push it to the side of the road. I inspected the battery connection and n…”
NHTSA complaint #11720345, 2026

“My car shuts off Battery drains, burning smell Rear camera gives out Clicking noises”
NHTSA complaint #11693262, 2025

Service Brakes 11 1 crash 1 injury

“EL DIA 21 DE MARZO DEL 2022 LLEGANDO A MI CASA Y PARA SER BIEN ESPECIFICA FRENTE A MI CASA ME ESTABA ACOMODANDO PARA COLOCAR EN RIVERSA MI GUAGUA Y LA MISMA SE ACELERO SOLA Y LOS FRENOS NO LE FUNCIONARON, CAUSANDO QUE ME FUERA POR UN RISCO. LOS AIR BAGS NUNCA LE ABRIERON.”
NHTSA complaint #11464070, 2022 · crash · 1 injury(ies)

“NHTSA #26V104: I purchased this vehicle to rent it out on Turo (a vehicle sharing platform). It was de-listed from Turo on March 18 due to NHTSA #26V104 recall being unresolved. I have been unable to rent my vehicle since then and Ford has not provided a remedy to this recall. I would like to log a complaint that this software fix remedy has taken too long.”
NHTSA complaint #11740980, 2026

“I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative whi…”
NHTSA complaint #11718278, 2026

Air Bags 9 3 crash 1 injury

“I was involved in an accident. During the accident none of the airbags deployed. The impact was so hard that it lifted the truck up off the ground and spinned us around 90 degrees. This resulted in the individuals seated on the passenger side of the truck to be thrown into the door fairly hard, with one passenger hitting her head on the window even with the seatbelt on. The point of impact was the drivers side back tire and bumper area.”
NHTSA complaint #11619483, 2024 · crash · 1 injury(ies)

“I was hit by another car in between the passenger side front door and the passenger side back door. I was hit with enough force to push me off the road. There was no side airbag deployment.”
NHTSA complaint #11507163, 2023 · crash

“The contact owns a 2022 Ford Maverick. The contact stated that while driving at 75 MPH, another vehicle side-swiped the contact's vehicle on the passenger's front side; however, the side curtain air bag failed to deploy. There were no injuries. A police report was filed. The vehicle was towed to an auto repair center. The contact related the failure to NHTSA Campaign Number - 22V594000 (Air Bags). The dealer was made aware of the failure; however, the parts to repair the recall are not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 8,…”
NHTSA complaint #11511612, 2022 · crash

Back Over Prevention 9

“The contact owns a 2022 Ford Maverick. The contact stated that while attempting to park the vehicle, the rearview camera became inoperable. The contact stated that the image displayed on the screen was frozen. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were unavailable. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reason…”
NHTSA complaint #11641645, 2025

“The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available for NHTSA Campaign Number: 25V019000 (Electrical System); and Parts distribution disconnect for NHT…”
NHTSA complaint #11651287, 2024

“The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (BACK OVER PREVENTION) and 25V019000 (ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.”
NHTSA complaint #11644164, 2024

Exterior Lighting 8

“I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative whi…”
NHTSA complaint #11718278, 2026

“The rear brake lights intermittently do not work, but at the same time the middle third light brake light works fine. also the turn signals work fine. People will rear end me if they don’t see my brake lights. I am a retired, master mechanic, and my son is also a mechanic. We have both looked into this problem and it possibly could be either a module or the turn signal switch. I had no warning of this problem coming on other than someone telling me my rear brake lights stopped working when they were following me. This is a very dangerous situation.”
NHTSA complaint #11716908, 2026

“My car shuts off Battery drains, burning smell Rear camera gives out Clicking noises”
NHTSA complaint #11693262, 2025

Steering 6 2 crash 1 injury

“The contact owned a 2022 Ford Maverick. The contact stated that while her grandson was driving at various speeds, the steering wheel locked and the vehicle lost power steering and functionality. The vehicle flipped over several times. An unknown warning light illuminated. It was unknown if the air bags were deployed. A police report was filed. The contact’s grandson was taken to the hospital via ambulance due to sustaining injuries to the back and neck. The vehicle was towed to a local towing yard. The insurance company was contacted and deemed the vehicle a total loss. The insurance company t…”
NHTSA complaint #11644855, 2025 · crash · 1 injury(ies)

“When the battery voltage suddenly drops the vehicle loses its power steering making slow speed turns extremely difficult. This poses a serious risk of the inability to control the direction of the vehicle and this makes a crash extremely probable.”
NHTSA complaint #11732082, 2026 · crash

“Due to go to dealership to inspect steering wheel”
NHTSA complaint #11745687, 2026

Seat Belts 5 1 injury

“The contact owns a 2022 Ford Maverick. The contact stated that after she parked the vehicle, her daughter unlatched the rear passenger's seat belt; however, the shoulder strap that she had placed behind her was twisted and inadvertently retracted. The seat belt then seized while tightly wrapped around the contact's daughter's waist, causing her breathing difficulty. The contact had to cut the rear passenger's seat belt with a scissor to release her daughter. The contact's daughter sustained bruising on her stomach and waist; however, medical attention was not received. The vehicle was not diag…”
NHTSA complaint #11533304, 2023 · 1 injury(ies)

“I am getting a “rear seat belt monitor fault” warning on my dash accompanied by an air bag warning light. It is also not allowing the auto start stop function to work as the vehicle states it cannot verify the driver seat belt is fastened. I have read in online forums that this is not an isolated issue.”
NHTSA complaint #11685134, 2025

“The component that failed on this vehicle was the restraint control module (RCM). It was replaced by the dealer and is not available for inspection. The safety of the driver I believe was at risk due to the vehicle occupant sensor not showing an occupant and only showing a question mark on the dash display. This was also causing an airbag and seat belt indicator light. The problem has been reproduced by a dealer. The problem first showed a rear seat occupant issue and then started showing for the left front seat. Showing an air bag and seat belt indicator.”
NHTSA complaint #11625447, 2024

Suspension 5

“When we brought it in for first oil change at the dealership ; when we got it back it had a broken axle which they tried to say we just needed new tires , after contacting service manager and he and I go for a ride in it they kept it for several weeks and put over 300 miles on it and got ford engineering involved to determine the cause was broken axle. It has been replaced again since then supposedly by a recall but it feels like it is broken again ! Ford took some shortcuts and used inferior parts, infrastructure etc , we had tremendous problems with the battery to which they said their shou…”
NHTSA complaint #11736807, 2026

“Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operate…”
NHTSA complaint #11712273, 2026

“CV joints failing. 61k miles and getting a shaking front end wheel driving. A failure could cause an accident or other safety odor for the drivers and others. I’ve seen many reports of the same failures but no recalls yet. Ford should take care of this issue.”
NHTSA complaint #11666653, 2025

Vehicle Speed Control 4 1 crash 1 injury

“EL DIA 21 DE MARZO DEL 2022 LLEGANDO A MI CASA Y PARA SER BIEN ESPECIFICA FRENTE A MI CASA ME ESTABA ACOMODANDO PARA COLOCAR EN RIVERSA MI GUAGUA Y LA MISMA SE ACELERO SOLA Y LOS FRENOS NO LE FUNCIONARON, CAUSANDO QUE ME FUERA POR UN RISCO. LOS AIR BAGS NUNCA LE ABRIERON.”
NHTSA complaint #11464070, 2022 · crash · 1 injury(ies)

“This car shifts to drive to neutral without any intervention on the freeway.”
NHTSA complaint #11635239, 2025

“The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The vehicle failed to accelerate as designed. The powertrain message was displayed. Additionally, the WRENCH symbol was displayed. The vehicle was taken to the local dealer, but the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The Ford Pass App alerted the contact of the failure. The vehicle was taken to another local dealer, Loudon Motors Ford LLC (3476 Union Ave SE, Minerva, OH 44657); where it was diagnosed that the throttle a…”
NHTSA complaint #11641628, 2024

Forward Collision Avoidance 3 1 crash

“When in adaptive cruise control the vehicle must of not seen the lines properly and started to steer towards the ditch. Then when trying to steer back onto the road the truck keep trying to steer into the ditch. The truck was fighting the drivers input even though the truck should deactivate the adaptive cruise control when manually taking over. The truck end up in the ditch and ran over a mailbox. The truck was inspected by Ford but they claimed nothing is wrong with it. It says in the manual that adaptive cruise control sometimes doesn't detect lines properly but when taking control the vehi…”
NHTSA complaint #11671260, 2025 · crash

“Due to go to dealership to inspect steering wheel”
NHTSA complaint #11745687, 2026

“I was at a stoplight, when the light turned green I went to press the gas and the whole car lost power and died. The car stalled and would not turn over again. The vehicle had power but would not start the engine. All the alerts were flashing on the dash and the car would not go into neutral, so I was stuck in the middle of the roadway. I followed the procedures to activate the manual override and place the car into neutral and the vehicle would still not move. The electrical brake would not allow the vehicle to move. We tried repeatedly to put the car into neutral to move out of an active roa…”
NHTSA complaint #11683189, 2025

Fuel/Propulsion System 3 1 fire

“The main fuel line feeding the fuel pump ruptured without warning, causing gas to spray across the engine compartment. The hot engine caused the gas to start cooking off, resulting in a fire in the engine compartment. The fuel line rupture has been confirmed by my Ford dealership.”
NHTSA complaint #11497241, 2022 · fire

“I bought a 2022 Maverick on 12 JAN 2022. The car broke down on the highway six months after (23 JUL 2022). Ford service department claimed it was a fuel injector issue and by replacing the part, the truck should be as good as new. Fast forward to Sat 30 DEC 2023 and the truck breaks down on the highway again with the engine light flashing. Ford service department informed me that the engine has to be replaced because several parts are broken/shattered and they do not know how. I am inclined to believe that the issue was never fixed to begin with and Ford put my safety and the lives of the peop…”
NHTSA complaint #11563638, 2023

“The 2022 Ford Maverick has a design flaw the harms the environment and places driver and passengers at risk. Specifically the vehicle does not have a metal skid plate which places the Evap System at risk for damage. If the system is damaged the vehicle is still driveable, but doing so allows gas vapors into the environment and worse, possibly into the passenger compartment. Looking under the vehicle, one finds some sort of fabric or mesh material which is definately not robust enough to protect the evap system components from damage. Driving on paved roads....no problem. Using this vehicle…”
NHTSA complaint #11489982, 2022

Lane Departure 2

“Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operate…”
NHTSA complaint #11712273, 2026

“Since the date of purchase (10/29/21) I am unable to change/set FM stations. Apps (ie: iHeart, Spotify) and voice command work intermittently. Apps will not work unless phone is plugged in. 911 assist will not work if not paired and connected to a Bluetooth enabled and compatible cell phone (see pg. 59 2022 Maverick owner’s manual). Unsure if lane keeping assistance is working properly. Vehicle was brought to Sam Galloway Ford on 10/30/21. Per Sam Galloway Ford: “Ford is aware of these problems. It is a ‘hardware’ issue.””
NHTSA complaint #11448618, 2022

Visibility/Wiper 2

“Never in all my years of driving have I or anyone i know experienced a vehicle with such a sensitive windshield that cracks with even minimal impact. I've owned this Ford maverick for under 3 years with 3 chip repairs and 2 replacements. This is unfair to consumers as often we are not aware of this issue until it is too late to change undo the purchases on these vehicles and have to drive faulty vehicles. It's surprising that there's no recall already assessed for something that causes customers to have higher insurance premiums, constant damage that affects visibility and causes some to dri…”
NHTSA complaint #11684877, 2025

“My license plate light has stopped working. It was replaced and still isn’t working. This reduces visibility and increases risk of a crash. This is in addition to the legal requirement to have an operating license plate light.”
NHTSA complaint #11619481, 2024

Firerelated 1

Fuel System 1

“The contact owns a 2022 Ford Maverick. The contact stated that the vehicle would not properly accelerate from a stationary position and the check engine warning light remained illuminated. The vehicle was taken to the local dealer who diagnosed that the EVP Emissions Control System and the purge valve were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.”
NHTSA complaint #11567187, 2024

Latches/Locks/Linkages 1

“I was working on my vehicle, when I close the hood. Upon closing, I heard something, I go to open, and the hood latch is stuck closed, not sure if that's a safety concern, but it was for me, as I could not access any important components of my vehicle, took it to the dealer, but still something of concern on a new vehicle.”
NHTSA complaint #11503901, 2023

Seats 1

“What component or system failed or malfunctioned? It’s not exactly failed or malfunctioned as much as it is just a flawed design. However, the problem is that the drivers seatbelt keeps getting wrapped up in the lever to recline the seat. This results in the handle getting pulled off of the seat constantly, the seat unexpectedly reclining when the driver pulls on the seatbelt too hard, or the seatbelt simply getting bunched up in the handle causing it to just become stuck and non functional. Is it available for inspection upon request? It is available for inspection anytime. How was your saf…”
NHTSA complaint #11571348, 2024

Tires 1

“I ordered my truck with all terain tires, they installed Falken wildpeak A/T AT3W 235 65R 17 tires.When me vehicle sits for a while (especially when its cold out) .I get a vibration for the first few miles down the road then it goes away. I have taken it to the dealer they are blameing the issue on the Falken tires,they said these tires develop a flat spot after sitting for a while. So they didnt think it was going to hurt my vehicle so they where not going to replace them.Seeing how I paid extra for all terrain tires and they installed these tires I don't think that was the correct action on…”
NHTSA complaint #11606275, 2024

Wheels 1

“The contact owns a 2022 Ford Maverick. The contact stated that while her son was driving approximately 60-65 MPH on the Interstate, the passenger’s side front wheel detached. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.”
NHTSA complaint #11702445, 2025