2022 Ford Expedition Problems & Owner Complaints

Electrical System 19 3 injury

“While driving the vehicle, the stereo system suddenly without warning started an unbearable loud and deafening noise. I was driving on a busy highway and was able to the the next exit. I had 2 other occupants in the vehicle. We had to exit the vehicle because the noise level from the speaker was painful and caused disorientation. I turned the vehicle off but the noise continued for at least 10 minutes then stopped. Myself and the 2 other occupants still have ear pain 24 hours later.”
NHTSA complaint #11605923, 2024 · 3 injury(ies)

“ABS break lights and Service Advanced Trac lights flashing and beeping. Eventually Break fluid low lights came on and car would not break when driving . Leaked break fluid on driveway. Car was unable to be driven, no breaks .all happened very quickly and without any reason .i had it towed to a break mechanic and he said it was the ABS modular break line that was broken and there was no more break fluid and it had leaked out . He suggested I send it to the dealership. It sounds like the exact same issue as the recall # 25S47 on campaign 25V314 but my vin number does not fall under they but show…”
NHTSA complaint #11750075, 2026

“The contact owns a 2022 Ford Expedition. The contact stated that while the vehicle was parked, it failed to start with several unknown warning lights illuminated. The vehicle was jump-started. The dealer was contacted, but the vehicle was not repaired. The manufacturer was notified of the failure. Additionally, the contact stated that the air bag warning light continuously remained illuminated. The failure was associated with NHTSA Campaign Number: 23V847000 (Steering, Air Bags); however, the VIN was not associated with the recall. The vehicle was not diagnosed or repaired. The manufacturer w…”
NHTSA complaint #11734069, 2026

Unknown Or Other 19

“Moonroof rubber sealant allowing water in”
NHTSA complaint #11718858, 2026

“B&O radio amplifier exploded causing a sharp ear piercing static sound. This caused severe driver distraction and potential fire risk.”
NHTSA complaint #11711418, 2026

“My employee was walking to his Ford 2022 Expedition, he had started it remotely, went to open the back of the vehicle, and the glass exploded. We have a video of it happening from a ring camera system.”
NHTSA complaint #11702722, 2025

Forward Collision Avoidance 15 1 crash

“DOCUMENTATION OF UNWARRANTED / UNCONTROLLED VEHICLE ACCELERATION: DRIVER STATED THAT WHILE VEHICLE WAS STOPPED IN TRAFFIC, VEHICLE ACCELERATED WITHOUT USE OF ACCELERATOR PEDAL. VEHICLE LURCHED FORWARD INTO VEHICLE AHEAD, AND INTO 2ND VEHICLE AHEAD IN TRAFFIC. ENGINE CONTINUED TO RACE AT HIGH SPEED WITH TRANSMISSION IN DRIVE, SPINNING REAR TIRES UNCONTROLLED WITH BOTH FEET DEPRESSING BRAKE PEDAL. VEHICLE HAD TO BE PUT IN NEUTRAL TO SHUT OFF ENGINE. APPROXIMATELY 15 - 20 MINUTES PRIOR TO INCIDENT, VEHICLES CRUISE CONTROL DISENGAGED WITHOUT REASON WHILE DRIVING @ 60 MPH ON PARKWAY. SYSTEM RE E…”
NHTSA complaint #11560912, 2023 · crash

“ABS break lights and Service Advanced Trac lights flashing and beeping. Eventually Break fluid low lights came on and car would not break when driving . Leaked break fluid on driveway. Car was unable to be driven, no breaks .all happened very quickly and without any reason .i had it towed to a break mechanic and he said it was the ABS modular break line that was broken and there was no more break fluid and it had leaked out . He suggested I send it to the dealership. It sounds like the exact same issue as the recall # 25S47 on campaign 25V314 but my vin number does not fall under they but show…”
NHTSA complaint #11750075, 2026

“Receiving Front Camera Malfunction Service required warning. Also receiving pre-collision assist, adaptive cruise control and automatic emergency break system warnings. Other systems likely disabled. Found that there was a TSB issued for the same year but on the F-150. DTC's C1001:31, U3000:89, U3000:49. This issue is likely caused by faulty cable connections where condensation has caused corrosion making the system inoperable thus creating a major safety issue for owners. I took the Expedition to SawGrass Ford in Sunrise FL and they confirmed that the issue was due to the electronics/cables.…”
NHTSA complaint #11725446, 2026

Power Train 14

“While driving on the highway, my 2022 Ford Expedition suddenly lost acceleration. The gas pedal stopped responding completely and the vehicle gradually lost power until it shut off. It had to be towed and the battery was fully drained afterward. It was later diagnosed as a fuel pump failure. This was a sudden loss of propulsion in traffic and created a serious safety concern. Police pulled over and were able to get me towed to the nearest safe stop as my car stopped on a bridge with no shoulder.”
NHTSA complaint #11743375, 2026

“Transmission randomly hard down shifts erratically. It feels like i lose control of the vehicle. Shifting is so violent, it's like I were driving over a man hole with a missing cover. These are under normal operating conditions. Not towing, not hard braking. Not extreme cold or hot climate. There are no warning laps on the dash board. This issue has been reviewed at 2 different FORD dealer / repair shops. The first location changed the transmission fluid. The second one changed the transmission torque converter. Documentation can be provided. There is no computer data that ind…”
NHTSA complaint #11734256, 2026

“Harsh shifting in relation to TBS 23-2250 causing the vehicle response to be unpredictably unsafe merging or suddenly stopping or accelerating.”
NHTSA complaint #11729302, 2026

Structure 12

“The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 26V204000 (Visibility), and 26V368000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.”
NHTSA complaint #11749999, 2026

“Moonroof rubber sealant allowing water in”
NHTSA complaint #11718858, 2026

“The contact owns a 2022 Ford Expedition. The contact stated that while driving approximately 75 MPH, the sunroof windscreen flew off and landed on the highway. The vehicle was taken to a dealer, where it was determined that the sunroof windscreen needed to be replaced. The vehicle was repaired; however, the failure reoccurred approximately five months later. The contact stated that while driving approximately 75 MPH, the sunroof windscreen flew off onto the highway again. The vehicle was taken to the same dealer, where it was determined that the sunroof windscreen needed to be replaced. The ve…”
NHTSA complaint #11733250, 2025

Engine 10 1 crash 4 injury

“The contact owns a 2022 Ford Expedition Max. The contact stated that while stopped with the brake pedal depressed in a parking lot, the vehicle accelerated inadvertently without warning. The vehicle crashed into the driver's side center of another vehicle totaling it. The approximate four occupants of the vehicle crashed into sustained unknown injuries and were transported to the hospital. A police report was filed. The contact did not sustain any injuries. The vehicle was towed to a collision center where it was repaired. The vehicle was not diagnosed or repaired. The manufacturer was not not…”
NHTSA complaint #11611844, 2024 · crash · 4 injury(ies)

“While driving on the highway, my 2022 Ford Expedition suddenly lost acceleration. The gas pedal stopped responding completely and the vehicle gradually lost power until it shut off. It had to be towed and the battery was fully drained afterward. It was later diagnosed as a fuel pump failure. This was a sudden loss of propulsion in traffic and created a serious safety concern. Police pulled over and were able to get me towed to the nearest safe stop as my car stopped on a bridge with no shoulder.”
NHTSA complaint #11743375, 2026

“The vehicle stalls, when stopped in traffic. In order to restart the vehicle, the transmission must be placed in the “park” position. This happens intermittently after the vehicle has been driven for a longer distance. I have read that this is related to the fuel injection system getting overheated which causes the fuel supply to drop and basically starves the system of the necessary fuel for combustion. Ford does not have a solution for this, however, the problem continues and creates a safety hazard especially during the darker hours.”
NHTSA complaint #11708859, 2025

Service Brakes 9 1 crash

“On Nov 22 I pulled over to the shoulder of a highway in the midst of a snowstorm to make a phone call. When I went to get back onto the highway, my vehicle lost all brakes...the brake pedal hit the floor...and I had a low-speed impact with a berm rising up to a driveway that intersected the shoulder. The vehicle had to be towed to a nearby dealer. The only mechanism to stop it on/off the tow truck was slamming transmission into park. Due to the storm, I had to spend the night in the vehicle in the freezing cold at the tow destination. The cause of the brake failure was determined to be…”
NHTSA complaint #11667839, 2024 · crash

“ABS break lights and Service Advanced Trac lights flashing and beeping. Eventually Break fluid low lights came on and car would not break when driving . Leaked break fluid on driveway. Car was unable to be driven, no breaks .all happened very quickly and without any reason .i had it towed to a break mechanic and he said it was the ABS modular break line that was broken and there was no more break fluid and it had leaked out . He suggested I send it to the dealership. It sounds like the exact same issue as the recall # 25S47 on campaign 25V314 but my vin number does not fall under they but show…”
NHTSA complaint #11750075, 2026

“I am submitting a formal consumer complaint regarding a persistent brake issue—specifically a loud squeal when coming to a stop in a 2022 Ford Expedition Max Limited purchased as a Certified Pre-Owned vehicle through Ford’s Blue Advantage Program. At the time of sale, I was assured the vehicle met certification standards, had no unresolved safety concerns, and that any recalls had been addressed. However, I later learned that Safety Recall 25S47 (NHTSA Campaign 25V-314) had been issued in May 2025—one month prior to purchase—for a front brake line defect that may cause brake fluid leaks, redu…”
NHTSA complaint #11733754, 2025

Vehicle Speed Control 8 1 crash

“DOCUMENTATION OF UNWARRANTED / UNCONTROLLED VEHICLE ACCELERATION: DRIVER STATED THAT WHILE VEHICLE WAS STOPPED IN TRAFFIC, VEHICLE ACCELERATED WITHOUT USE OF ACCELERATOR PEDAL. VEHICLE LURCHED FORWARD INTO VEHICLE AHEAD, AND INTO 2ND VEHICLE AHEAD IN TRAFFIC. ENGINE CONTINUED TO RACE AT HIGH SPEED WITH TRANSMISSION IN DRIVE, SPINNING REAR TIRES UNCONTROLLED WITH BOTH FEET DEPRESSING BRAKE PEDAL. VEHICLE HAD TO BE PUT IN NEUTRAL TO SHUT OFF ENGINE. APPROXIMATELY 15 - 20 MINUTES PRIOR TO INCIDENT, VEHICLES CRUISE CONTROL DISENGAGED WITHOUT REASON WHILE DRIVING @ 60 MPH ON PARKWAY. SYSTEM RE E…”
NHTSA complaint #11560912, 2023 · crash

“When the vehicle starts, two error messages appear. The first one is "Pre-Collission Assist not available" and the second one is "Front camera fault - Service required". Due to these errors, I have no collission assist and cruise control does not work and cannot be enabled. I have taken it to the dealer 3 times (Since the summer) to be repaired and they have reloaded the software each time. This has not fixed the problem and they refuse to replace any hardware. They have stated that it is a software issue and that a fix will be forthcoming but they have no fix or timeframe as to when it w…”
NHTSA complaint #11697375, 2025

“Several incidents in which adaptive cruise control resets itself to 90mph when moving into a higher speed limit area- for example, cruising along at 70mph, pass a speed limit sign allowing 75mph, and suddenly the cruise control resets at 90mph. If you are not very consciously thinking about this you quickly find yourself going 90mph. It never resets at 80 or 85- always 90mph. Going 15 or 20 mph faster than thought or planned certainly grabs your attention and is a safety risk.”
NHTSA complaint #11638586, 2025

Fuel System 7

“The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 26V204000 (Visibility), and 26V368000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.”
NHTSA complaint #11749999, 2026

“The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while depressing the accelerator pedal, the vehicle hesitated before accelerating to the intended speed. The dealer was contacted and confirmed that the part to do the recall repair was not available. The manufacturer was not made aware of the issue. The failure mileage was u…”
NHTSA complaint #11727497, 2025

“The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the recall was initiated in July 2025, and parts were still not available. The contact stated that the recall repair was urgently needed because the contact travelled with her grandchildren inside the vehicle. In addition, the contact was stuck in another State because the contact was afraid to drive the vehicle due to the safety recall. The manufacturer was made aware of…”
NHTSA complaint #11701437, 2025

Back Over Prevention 6

“The contact owns a 2022 Ford Expedition. The contact stated that after reversing, the rear-view camera displayed a rear-view image but failed to turn off when the vehicle was shifted back into drive(D). No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the rear-view camera. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V315000 (Back Over Prevention), but the VIN was not included. The manufacturer was notified of the failure and referred the contact to t…”
NHTSA complaint #11675658, 2025

“My vehicle doesn’t alert me of incoming vehicles and the reverse camera stays on. When I turn on my vehicle the dash stays on with ford sign so when I put on reverse my back up camera doesn’t turn on at all. I have to use all my mirrors to back out of parking. This feature hasn’t been working properly for a year. They keep telling me ford is working to fix this issue.”
NHTSA complaint #11625709, 2024

“Since purchase in 2022, the vehicle has experienced repeated failures of multiple safety systems. These include frequent warnings that “Pre-Collision Assist is Not Available,” repeated failures of Blind Spot Detection with Cross Traffic Alert, Tire Pressure Monitoring warnings, and messages to “Check 12-Volt Battery.” These system malfunctions occur intermittently and unpredictably, creating unsafe driving conditions. In addition to the warning messages, the rear liftgate has failed to latch properly and on at least one occasion opened while the vehicle was in motion. This poses a serious haz…”
NHTSA complaint #11689641, 2023

Visibility 6

“The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 26V204000 (Visibility), and 26V368000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.”
NHTSA complaint #11749999, 2026

“The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 26V204000 (Visibility); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.”
NHTSA complaint #11732792, 2026

“The contact owns a 2022 Ford Expedition. The contact stated that while driving in the rain at 60 MPH with the windshield wipers at max speed, the driver’s side windshield wiper started hanging off the side of the windshield and failed to operate as needed. The contact pulled into the nearest gas station and attempted to move the wiper back to the original position; however, the driver’s side windshield wiper failed to move. Despite the failure, the contact continued to drive the vehicle. Upon investigation, the contact discovered NHTSA Campaign Number: 22V250000 (Visibility), which was linked…”
NHTSA complaint #11651292, 2025

Fuel/Propulsion System 5

“While driving on the highway, my 2022 Ford Expedition suddenly lost acceleration. The gas pedal stopped responding completely and the vehicle gradually lost power until it shut off. It had to be towed and the battery was fully drained afterward. It was later diagnosed as a fuel pump failure. This was a sudden loss of propulsion in traffic and created a serious safety concern. Police pulled over and were able to get me towed to the nearest safe stop as my car stopped on a bridge with no shoulder.”
NHTSA complaint #11743375, 2026

“My vehicle shutters like it’s is going to die/shit off. When will this issue be resolved with the fuel pump system failure? I will be doing some research with the BBB to find out if this will be an actionable lawsuit. Most consumers who own these types of SUVs are mothers! This needs to be resolved asap!”
NHTSA complaint #11726375, 2026

“Ford has a recall on the low pressure fuel pump but no fix yet. My fuel pump failed and I am being charged to fix it. But that also puts me back on the road with an unsafe vehicle. They will not provide me a rental until the recall has a solution or fix.”
NHTSA complaint #11725500, 2026

Lane Departure 5

“The ipma module which controls the lane keep assist has stopped working permanently. The dealership has quoted the cost to replace the ipma at over $1,000. The warning light stating that the front camera module and lane keep assist are unavailable appears each time the vehicle is started up.”
NHTSA complaint #11754394, 2025

“My vehicle doesn’t alert me of incoming vehicles and the reverse camera stays on. When I turn on my vehicle the dash stays on with ford sign so when I put on reverse my back up camera doesn’t turn on at all. I have to use all my mirrors to back out of parking. This feature hasn’t been working properly for a year. They keep telling me ford is working to fix this issue.”
NHTSA complaint #11625709, 2024

“Since purchasing this vehicle in January of 2023, it has been to the dealer three times to repair a failed blind spot monitoring system and rear cross traffic alert system due to corroded pins in the connectors of the sensors. According to the dealer, this is due to the connector utilizing only four of eight pins which leaves four pins unused and open to corrosion. On the third trip in, the dealer applied, "super glue" to try and prevent any future corrosion. While there was not a specific accident related to this, I do believe this has the potential to cause issues in the future if not proper…”
NHTSA complaint #11562381, 2023

Equipment 3

“Upon starting vehicle, loud pop sound and then excruciatingly painful white noise throughout the sound system. No controls will work to turn audio down. Upon shutting vehicle off, painful white noise continued for another 10sec or more. Waited a few minutes tried again, same thing happened with sound. Unable to drive vehicle with sound this loud. Tried 5x to shut off vehicle and restart, white noise continued. Hours later, ears are still ringing the noise was so loud. No controls on the touch screen would work and even shutting off car, disconnecting all phones excruciating white noise…”
NHTSA complaint #11576395, 2024

“Bought car new last year. Current 15,000 miles. On Saturday, September 2, I turned the ignition off and then opened the drivers door. Suddenly there was a horrendous loud static noise coming from I assume the radio speakers. It was deafening, and lasted about 3 seconds. I have read about other Ford trucks having this problem, but it is the first time for me. I will take it to my Ford dealer tomorrow morning. Apparently there is a quick program update to correct the issue. If this happened while I was driving, it may have caused an accident.”
NHTSA complaint #11542518, 2023

“On start-up, vehicle had an ear-piercing noise coming through all speakers. All of the dashboard screens were black, buttons were not responsive, but the vehicle would still move. Even after getting the vehicle to turn off, the sound persisted. I had to manually disconnect the battery to get it to stop. I have video of the incident if helpful. Ford service had no idea how to handle.”
NHTSA complaint #11540428, 2022

Exterior Lighting 3

“The component that failed is the left front driver side headlight of the vehicle, resulting in low visibility and inability to see or drive the vehicle in it's current condition at night. The only "warning" that could potentially have been a "warning", was the blinker began rapidly blinking the day before the headlight stopped functioning; the blinker no longer worked in the headlight but still worked on the driver mirror and back taillight. By the next day, the driver side headlight no longer functioned. It is my knowledge that Ford has a lifetime guarantee on the headlights for this make,…”
NHTSA complaint #11676322, 2025

“The coating and plastic is failing in the headlights, this can reduce visibility and by extension safety.”
NHTSA complaint #11666972, 2025

“Rear cabin lights do not come on when doors are opened. When manually turned on, at times, rear cabin lights will turn on and not be able to be turned off. This created a hazard while driving at night/early morning. We had to cover interior lighting to be able to drive safely. I feel this is a product issue. Dealer said it’s normal working order.”
NHTSA complaint #11510921, 2023

Air Bags 2 1 crash 3 injury

“The contact owns a 2022 Ford Expedition. The contact stated that while driving at approximately 45 MPH, a vehicle that was making a U-turn crashed into the rear passenger side door and that after the impact, all of the air bags failed to deploy. The contact's son, who was seated in the front passenger seat, had his seatbelt retractor failed to lock as a result he lunged forward from the impact and causing him to hit his chest against the instrument panel. Additionally, the contact stated that her other son was seated in the rear passenger seat and that after the impact, his seat belt was unlat…”
NHTSA complaint #11488096, 2022 · crash · 3 injury(ies)

“The contact owns a 2022 Ford Expedition. The contact stated that while the vehicle was parked, it failed to start with several unknown warning lights illuminated. The vehicle was jump-started. The dealer was contacted, but the vehicle was not repaired. The manufacturer was notified of the failure. Additionally, the contact stated that the air bag warning light continuously remained illuminated. The failure was associated with NHTSA Campaign Number: 23V847000 (Steering, Air Bags); however, the VIN was not associated with the recall. The vehicle was not diagnosed or repaired. The manufacturer w…”
NHTSA complaint #11734069, 2026

Seat Belts 2 1 crash 3 injury

“The contact owns a 2022 Ford Expedition. The contact stated that while driving at approximately 45 MPH, a vehicle that was making a U-turn crashed into the rear passenger side door and that after the impact, all of the air bags failed to deploy. The contact's son, who was seated in the front passenger seat, had his seatbelt retractor failed to lock as a result he lunged forward from the impact and causing him to hit his chest against the instrument panel. Additionally, the contact stated that her other son was seated in the rear passenger seat and that after the impact, his seat belt was unlat…”
NHTSA complaint #11488096, 2022 · crash · 3 injury(ies)

“The collision avoidance system repeatedly faults and becomes unusable. Also, the 2nd row bench seat belt locks without warning. This posses a great risk in a crash.”
NHTSA complaint #11742078, 2025

Steering 2

“The contact owns a 2022 Ford Expedition. The contact stated that while the vehicle was parked, it failed to start with several unknown warning lights illuminated. The vehicle was jump-started. The dealer was contacted, but the vehicle was not repaired. The manufacturer was notified of the failure. Additionally, the contact stated that the air bag warning light continuously remained illuminated. The failure was associated with NHTSA Campaign Number: 23V847000 (Steering, Air Bags); however, the VIN was not associated with the recall. The vehicle was not diagnosed or repaired. The manufacturer w…”
NHTSA complaint #11734069, 2026

“The vehicle stopped running while driving, my wife stopped at a stop sign after vehicle had run ~ 10 minutes. Upon entering the inter-section the vehicle started to run rough, and ultimately stalled and would not restart. She was able to coast into a parking lot entrance within On Top of World subdivision where we live and get off of main road. After multiple AAA attempts to jump start, AAA confirmed the vehicle was unable to be jump started, therefore vehicle was towed to local ford dealership for diagnostics. They tried to jump start multiple times and after 2 days, pushed it into garage…”
NHTSA complaint #11681839, 2025

Tires 2

“The contact owns a 2022 Ford Expedition equipped with Hankook, Tire Line: Dynapro, Tire Size: 275/55/R20, DOT Number: (N/A). The contact stated that while the vehicle was parked, the contact became aware that the tire pressure was low. Additionally, the check engine warning light was illuminated. The contact drove to Discount Tire to inflate the tire. The contact stated that there was an abnormal sound coming from the brake pedal. The vehicle was taken to a dealer where it was diagnosed and determined that the battery needed to be replaced, and the brake pedal needed to be cleaned. The battery…”
NHTSA complaint #11631881, 2024

“The contact owns a 2022 Ford Expedition. The contact stated while driving 40-80 MPH, there was an abnormal vibration in the vehicle. There was an abnormal humming sound coming from the vehicle. The vehicle was taken to the local dealer, where it was diagnosed and determined that the wheels, drive shaft, and u-joint needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken to another local dealer, Bob Moore Ford (8948 S I-35 Service Rd., Oklahoma City, OK 73149); where it was diagnosed and determined that the tires and the rims needed to be replaced. The…”
NHTSA complaint #11616891, 2024

Visibility/Wiper 2

“Wipers are the recalled version missing the little block. HOWEVER, the recall is not for my VIN. Coolant keeps disappearing. Hard shifting and or no movement at all while transmission is cold.”
NHTSA complaint #11642675, 2025

“I was driving in the express lane NB I-15 in Utah. I was at highway speeds with no one around me. I had the visor that closed on my sunroof when all of a sudden I hear a loud explosion, it scared me and I immediately slowed and pulled off the road. I first thought maybe it was a tire, I checked and all were intact, then I saw glass and looked up on my roof and noticed that the sunroof was completely blown out. I apparently lost my Panoramic portion of my sunroof, not the part that actually opens, the fixed portion. The glass is angled out like a slope up a mountain. I am lucky the visor…”
NHTSA complaint #11480869, 2022

Carry Handle 1

“Summary of Safety Issues with Chicco Car Seat 1.) Magnetic Chest Clip Disassembly (October 2023) • At [XXX] old, my daughter disassembled the magnetic chest clip while seated in the car. • She placed a small part in her mouth, creating a choking hazard. • I was stranded until a replacement car seat could be brought. • I replaced the clip with a plastic version Chicco provided, but the original design posed a serious and unacceptable safety risk. 2.Child Unlocking Base Mechanism (April 2025) • My daughter is able to unlatch the seat from its base while rear-facing. • She does this repeatedly…”
NHTSA complaint #11685775, 2023

Chest Clip 1

“Summary of Safety Issues with Chicco Car Seat 1.) Magnetic Chest Clip Disassembly (October 2023) • At [XXX] old, my daughter disassembled the magnetic chest clip while seated in the car. • She placed a small part in her mouth, creating a choking hazard. • I was stranded until a replacement car seat could be brought. • I replaced the clip with a plastic version Chicco provided, but the original design posed a serious and unacceptable safety risk. 2.Child Unlocking Base Mechanism (April 2025) • My daughter is able to unlatch the seat from its base while rear-facing. • She does this repeatedly…”
NHTSA complaint #11685775, 2023

Seats 1

“3rd row seat has metal frame coming through cushion. Had seat cushion replaced once. Ford technician said was design flaw in vehicle and issue will continue to happen. Just had vehicle in again for same issue but Ford will not replace cushion this time because they confirmed other like vehicles are having same issue and deeming is a normal condition. This is a huge safety issue for my children. This is not a normal condition to have a cushion fall through and the metal seat frame is exposed.”
NHTSA complaint #11607119, 2024

Suspension 1

“The contact owns a 2022 Ford Expedition. The contact stated while driving 40-80 MPH, there was an abnormal vibration in the vehicle. There was an abnormal humming sound coming from the vehicle. The vehicle was taken to the local dealer, where it was diagnosed and determined that the wheels, drive shaft, and u-joint needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken to another local dealer, Bob Moore Ford (8948 S I-35 Service Rd., Oklahoma City, OK 73149); where it was diagnosed and determined that the tires and the rims needed to be replaced. The…”
NHTSA complaint #11616891, 2024

Wheels 1

“The contact owns a 2022 Ford Expedition. The contact stated while driving 40-80 MPH, there was an abnormal vibration in the vehicle. There was an abnormal humming sound coming from the vehicle. The vehicle was taken to the local dealer, where it was diagnosed and determined that the wheels, drive shaft, and u-joint needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken to another local dealer, Bob Moore Ford (8948 S I-35 Service Rd., Oklahoma City, OK 73149); where it was diagnosed and determined that the tires and the rims needed to be replaced. The…”
NHTSA complaint #11616891, 2024