2021 Ford Bronco Problems & Owner Complaints

Engine 68 1 crash

“Ford has issued a recall (24S55) stating the Intake valves on the ford bronco with engine2.7L and 3.0L will harden and crack or break and loss of power. I had the same issue in my 2021 Ford Bronco with the 2.3L engine while I was driving in the highway I got a check engine light then it started cutting out horribly so I slowed down to pull off the road through a metal gate that was open with a cattle guard and the engine died as I was turning in and loss power steering trying to turn the wheel back in time I didn’t and ended up side swiping the pole and knocking off my side mirror and damaging…”
NHTSA complaint #11679626, 2025 · crash

“Fuel pump.has low pressure therefore making vehicle stop running completely. Has happened twice , once while driving on highway. This is extremly dangerous to have your vehicle just come to complete dead stop in middle.of road. FORD has no remedy to fix and now i am without a car I am paying for since it wont start now.”
NHTSA complaint #11754851, 2026

“A Safety Recall was issued on the vehicle with no remedy. The recall was in reference to the Engine Intake Valves and stated; "The engine intake valves may crack and break, which could result in loss of motive power and increase the risk of a crash". It also stated, " Prior to losing motive power, an engine malfunction indicator lamp may illuminate in the cluster and the driver may notice that the vehicle is running rough". This issue was the result of Ford manufacturing using a material that had "hardness issues". This all came out prior to the vehicle reaching the end of its warranty mile…”
NHTSA complaint #11718771, 2025

Electrical System 28 1 fire

“The contact owns a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, the electrical system and the engine seized. The contact noticed fire and smoke which exited from the engine compartment. The contact was the only occupant of the vehicle when the failure occurred. The fire department arrived and extinguished the fire. The vehicle was towed to the dealer. The vehicle was inspected and diagnosed with a faulty alternator. The contact was informed that the seized gears overheated the alternator motor, which caused the fire. The vehicle was repaired. In add…”
NHTSA complaint #11655385, 2024 · fire

“Window actuator does not properly open or close passenger window to open door properly, which is a safety risks to a child. Window could shatter because window will not roll down the inch or so to pull the door open. In order to open the door, the window will shake vibrantly and risk of a child of a possible window shatter. Ford says this is a normal wear and tear and it’s at owners cost to replace. To me that’s unacceptable.”
NHTSA complaint #11744621, 2026

“I am submitting a safety complaint regarding my Ford vehicle’s infotainment screen failure, which has been identified under a recall but currently has no available remedy or repair timeline. When the screen goes blank or becomes unresponsive, I lose access to critical safety features, including the rearview camera, which is federally required. This significantly increases the risk of accidents while reversing, especially in areas with pedestrians. The system also affects access to navigation, hands-free communication, and important vehicle alerts, forcing me to either drive without these feat…”
NHTSA complaint #11735509, 2026

Unknown Or Other 28 1 fire 1 injury

“I was towing the vehicle with my Class A RV. It was a total loss nothing could be inspected. I was in hour number 6 of our long drive to Key West. I looked out of my left side mirror and noticed smoke coming from behind my RV. I immediately pulled off the interstate onto the shoulder. I moved behind my RV and noticed the vehicle was on fire. Within in seconds the fire engulfed the whole vehicle. I had seconds to unhook it from my RV. It took me three tries to unhook because of the smoke. I eventually got it unhooked and went back to the front of the RV and pulled forward out of harms way.”
NHTSA complaint #11583179, 2023 · fire · 1 injury(ies)

“Corrosion of the entire spare tire carrier mount”
NHTSA complaint #11753780, 2026

“Component or system that failed/malfunctioning:Climate Control System / Rear Passenger Cabin Ventilation.Is the component available for inspection?Yes, the vehicle and the climate control system are completely intact, unaltered, and available for physical inspection upon request.Description of Incident & Safety Risks:There is little to no airflow reaching the rear passenger seating area of the vehicle. The 4-Door 2021 Ford Bronco relies entirely on hidden, under-seat floor ducts to regulate back-seat temperatures, as it lacks center console or upper B-pillar vents. Under normal operation, the…”
NHTSA complaint #11750401, 2026

Suspension 24 1 injury

“Our family was traveling from Lake George New York to Boston MA on Wednesday [XXX]. As we passed another vehicle in the far left lane on [XXX] the vehicle bounced and we lost control of the backend of the vehicle and it "fish tailed" across the highway nearly causing a collision at 65 miles per hour. The anti-lock breaks were activated and we nearly collided with several cars but managed to pull into the emergency lane. The vehicle was not drivable after this incident because any pothole or bump on the highway, at speeds over 50 MPH, made the rear of the vehicle very unstable. It will skid and…”
NHTSA complaint #11648104, 2025 · 1 injury(ies)

“After my Ford dealer applied their recall "fix" on the rear shocks of my 2021 Bronco with Sasquatch package my passenger side rear shock reservoir came off while driving down the freeway. It didn't hit anyone but it was scary never the less.”
NHTSA complaint #11741008, 2026

“The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle was bouncing. Additionally, the rear-end swayed while driving over a bump. The dealer was made aware of the failure but confirmed that parts were on backorder. The vehicle was not repaired. The manufacturer was made aware of the failu…”
NHTSA complaint #11706745, 2025

Back Over Prevention 23

“The wiring harness is rubbing against the bumper, causing it to wear and eventually cut through. This causes an error to my BSM/Cross Traffic alert. I have an extended warranty, but it doesn't cover it. This is a problem I have seen on the Bronco6G forums.”
NHTSA complaint #11715858, 2026

“I received an alert on the dash stating there was an issue with the blind spot monitoring/rear cross traffic system. It was erroring off and on for that entire drive. When I got home, I googled the issue and it appears it's a known issue with '21 and some early '22 broncos where they factory installed the blind spot module wiring harness too close to the rear bumper. Over time, the wires rub and eventually rub bare and corrode or short out. I went out to take a look and sure enough, I had rubbed through on the driver side (photo) and the passenger side was nearly rubbed through. I have an e…”
NHTSA complaint #11712311, 2026

“3 separate safety-related components have failed on my 2021 Ford Bronco, all of which correspond to open federal safety recalls that remain unremedied: 1. Infotainment/APIM Module & Backup Camera System (Recall Campaign 26V124): my infotainment screen fails to turn on, particularly in high-temperature conditions. When this occurs, the rearview/backup camera is completely non-functional. The vehicle displays no image when in reverse gear, eliminating all camera-assisted visibility behind the vehicle. This directly matches the conditions described in Recall 26V124, issued March 4, 2026. No reme…”
NHTSA complaint #11731872, 2025

Fuel/Propulsion System 19

“Fuel pump.has low pressure therefore making vehicle stop running completely. Has happened twice , once while driving on highway. This is extremly dangerous to have your vehicle just come to complete dead stop in middle.of road. FORD has no remedy to fix and now i am without a car I am paying for since it wont start now.”
NHTSA complaint #11754851, 2026

“Ford has failed to remedy RECALL 25V455 issued OVER 1 YEAR AGO !!!!!!!! My fuel pump failed in August of 2025 and left me (single female) stranded on side of interstate highway in 100' heat. Dealer confirmed in-tank fuel pump failed and replaced with another recalled pump. There was no warning that failure was happening until vehicle stopped in traffic. Had over 1/4 tank of gas at the time. Afraid to drive vehicle out of town because it could strand me again. Can not trade in vehicle because open recall reduces value of vehicle”
NHTSA complaint #11747918, 2025

“3 separate safety-related components have failed on my 2021 Ford Bronco, all of which correspond to open federal safety recalls that remain unremedied: 1. Infotainment/APIM Module & Backup Camera System (Recall Campaign 26V124): my infotainment screen fails to turn on, particularly in high-temperature conditions. When this occurs, the rearview/backup camera is completely non-functional. The vehicle displays no image when in reverse gear, eliminating all camera-assisted visibility behind the vehicle. This directly matches the conditions described in Recall 26V124, issued March 4, 2026. No reme…”
NHTSA complaint #11731872, 2025

Service Brakes 19 3 crash 3 injury

“Kepts getting hills stop brake malfunctioning anti collusion failures ant lock brake failure”
NHTSA complaint #11476660, 2022 · crash · 2 injury(ies)

“The contact owns a 2021 Ford Bronco. The contact stated that while her son was driving at an undisclosed speed, the brake pedal was depressed but failed to stop the vehicle immediately. The brake pedal was extremely stiff while depressed. The brake warning light was illuminated. The vehicle struck a speed sign, causing the front driver's side mirror to shatter, and glass shards flew inside the vehicle, cutting the contact's son's left hand and arm. Medical attention was not received. The air bags did not deploy. No police report was filed. The vehicle was taken to the dealer, where it was dete…”
NHTSA complaint #11551594, 2023 · crash · 1 injury(ies)

“I was pulling into a residential driveway and as soon as the front tires entered the driveway the pre-collision alert warning went off and when I applied the brakes they did nothing. I proceeded to roll 25+ feet and crashed into the back of a parked car in the driveway. There were people standing just to the right of the parked car I hit. The Ford dealer has had the vehicle for over 4 weeks now and all they've said is certain modules aren't communicating properly.”
NHTSA complaint #11471430, 2022 · crash

Visibility/Wiper 14

“While driving home in the evening I drove through a swarm of insects. I pushed the button to spray washer fluid and engage the wipers to clear the windshield. No fluid came out and the windshield became smeared there by obscuring visibility. I thought that odd as I always top off windshield washer fluid on all my vehicles as part of routine maintenance. When I arrived home I put approximately 1 gallon of fluid into the washer reservoir which quickly emptied onto the fender liner and the ground. Apparently there is a known defect with the washer fluid reservoir that causes it to split along th…”
NHTSA complaint #11678485, 2025

“Ford Bronco windshield washer reservoir will no longer hold fluids. Multiple attempts to refill lead to the reservoir being empty. This is problematic as the windshield CANNOT be cleaned while driving the vehicle. Finally got an appointment with a Ford dealer to be told that the washer reservoir needs to be replaced, that they know these crack and fail, and that I was 9 days out of warranty. Dealership also stated there was a long backlog to get a replacement washer reservoirs (3-4 weeks minimum). There is no way that the reservoir could have been damaged by us (the owner) - it is nestled…”
NHTSA complaint #11604442, 2024

“The wiper will work for about 20 minutes. the slow to a very slow intermittent wipe no matter the rain amount. Once this has started you can adjust the speed of the wiper and it will work for about 30 seconds the fall back into the slow intermittent wipe. I took it to the dealer, and they said the wipers were working normally, even though I have a video of the issue happening. There are no indications of a malfunction on the dashboard.”
NHTSA complaint #11548808, 2023

Lane Departure 10

“My BLIS module on the passenger side does not work and I have a constant warning light displayed that there is a system malfunction. Under further investigation, this is a KNOWN design issue caused by the rear wiring harness that contains the BLIS sensor rubbing against components in the rear bumper. My vehicle has 31000 miles on it and is now out of warranty. Ford dealers are aware of this issue but claim it is not a recall and not under warranty. This is a safety issue.”
NHTSA complaint #11724615, 2026

“The wiring harness is rubbing against the bumper, causing it to wear and eventually cut through. This causes an error to my BSM/Cross Traffic alert. I have an extended warranty, but it doesn't cover it. This is a problem I have seen on the Bronco6G forums.”
NHTSA complaint #11715858, 2026

“I received an alert on the dash stating there was an issue with the blind spot monitoring/rear cross traffic system. It was erroring off and on for that entire drive. When I got home, I googled the issue and it appears it's a known issue with '21 and some early '22 broncos where they factory installed the blind spot module wiring harness too close to the rear bumper. Over time, the wires rub and eventually rub bare and corrode or short out. I went out to take a look and sure enough, I had rubbed through on the driver side (photo) and the passenger side was nearly rubbed through. I have an e…”
NHTSA complaint #11712311, 2026

Structure 10

“Component/System Involved: Molded-in-Color (MIC) Hardtop – Composite Roof Panel What happened: The molded-in-color (MIC) hardtop on my 2021 Ford Bronco (2-door) has developed multiple visible stress cracks above the passenger-side window. These are not surface scratches — they are embedded, structural fractures in the composite roof material. The cracks have formed under normal, garage-kept driving conditions at just over 10,400 miles and continue to worsen. Safety risk: I am concerned these cracks pose a potential safety risk, particularly involving water intrusion during rainfall or car wa…”
NHTSA complaint #11676532, 2025

“The contact owns a 2021 Ford Bronco. The contact stated the rear translucent heavy plastic panel was loosened due to the breakdown of the plastic tabs used to secure the rear panel in place. The contact stated that the vehicle was equipped with a soft top, and when the weather was warm, the side panels and rear panel would be removed to open the rear of the vehicle like a convertible. The contact was concerned that the clear panel could fall from the rear of the vehicle and strike the vehicle behind. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined tha…”
NHTSA complaint #11655838, 2025

“The contact's daughter owns a 2021 Ford Bronco. The contact stated that the sides of the soft top material above the B-pillar and the A-pillar were detaching, which could cause the soft top to separate from the vehicle while driving. The vehicle was taken to the dealer, where it was inspected, and the dealer determined that the soft top needed to be replaced. The vehicle was not repaired. The contact related the failure to TSB Number: 23-2229. The manufacturer was notified of the failure and informed the contact that there was no guarantee that assistance would be provided in covering the cost…”
NHTSA complaint #11663889, 2024

Power Train 9 1 fire

“My drive shaft/coupling caught fire at the front transfer case. I was able to extinguish it safely. This is the same description as: NHTSA Recall No.: 26V236 Manufacturer Recall No.: 26S26 And the description “ Vehicle 1: 2021-2025 FORD BRONCO‘ includes my vehicle, however, my VIN/license plate number do not show this recall in effect.”
NHTSA complaint #11736856, 2026 · fire

“Persistent highway-speed vibration (45 to 82 mph) present since July 2022, documented at five Ford dealerships between 21,000 and 100,000 miles, and still unresolved and undiagnosed after four years. It is a whole-vehicle shake felt primarily through the seat and from the rear of the vehicle at highway speed, occurring on highways nationwide (documented in [XXX], [XXX], and [XXX]). Wheel and tire causes were controlled for and eliminated: three complete wheel-and-tire set swaps (two on factory stock sets) did not change the vibration; a dealer road-force balance (08/2024) did not resolve it; i…”
NHTSA complaint #11751184, 2026

“Component or system that failed or malfunctioned: The fuel delivery system, specifically the fuel pump, which is subject to an active safety recall. The recall states that fuel pump failure can result in loss of fuel pressure and flow, leading to engine stall. The vehicle is available for inspection upon request. How safety was put at risk: A sudden engine stall while driving would result in an immediate loss of propulsion and power, creating a significant risk of collision, particularly at highway speeds or in traffic. This creates a dangerous situation for the driver, passengers, and surrou…”
NHTSA complaint #11714757, 2025

Air Bags 7 2 crash 1 injury

“The contact owns a 2021 Ford Bronco. The contact stated while at a stop light, a Kia vehicle driving at approximately 45-50 MPH rear-ended his vehicle causing him to collide with in vehicle in front on the driver's-side. No air bags were deployed and the rear bumper was detached. The vehicle was towed to Diamond Auto Works. The contact stated that he sustained head, neck, upper, and lower back as well as bruising from the left arm and his wrist that required medical attention and was bedridden. A police report was filed.  The vehicle was not diagnosed or repaired. The contact was unsure if the…”
NHTSA complaint #11640940, 2025 · crash · 1 injury(ies)

“I was driving in the northbound left hand lane on creasy lane in Lafayette, Indiana, approaching Rome Drive. A driver from a side street took an illegal left hand turn to head towards the northbound lanes of creasy lane, I was traveling over 30 mph, maybe 40 at the time of the collision. I was unable to see the other driver until it was too late as they passed by drivers turning from the right hand lane onto the side road they had been at. My airbags did not deploy during the collision, nor did my pre collision assist alert nor did my brake system engage. I suffered extensive front end damage…”
NHTSA complaint #11746859, 2026 · crash

“I have a 2021 ford bronco and the rear shock absorbers are both bad on my car it is dangerous to drive I have taken it to 2 different ford dealerships one in Morgantown wv and one in fairmont wv and was told there was nothing they could do about it. Then I contacted ford motor company and spoke to someone and was told there was nothing they could do and the vehicle was safe to drive although it states in the recall it increases risk of crash. I was told to file a complaint and on top of all that they won’t give me an inspection sticker. When you hit a pothole bump or any other obstruction is…”
NHTSA complaint #11676360, 2025

Forward Collision Avoidance 7 3 crash 3 injury

“Kepts getting hills stop brake malfunctioning anti collusion failures ant lock brake failure”
NHTSA complaint #11476660, 2022 · crash · 2 injury(ies)

“Our family was traveling from Lake George New York to Boston MA on Wednesday [XXX]. As we passed another vehicle in the far left lane on [XXX] the vehicle bounced and we lost control of the backend of the vehicle and it "fish tailed" across the highway nearly causing a collision at 65 miles per hour. The anti-lock breaks were activated and we nearly collided with several cars but managed to pull into the emergency lane. The vehicle was not drivable after this incident because any pothole or bump on the highway, at speeds over 50 MPH, made the rear of the vehicle very unstable. It will skid and…”
NHTSA complaint #11648104, 2025 · 1 injury(ies)

“I was driving in the northbound left hand lane on creasy lane in Lafayette, Indiana, approaching Rome Drive. A driver from a side street took an illegal left hand turn to head towards the northbound lanes of creasy lane, I was traveling over 30 mph, maybe 40 at the time of the collision. I was unable to see the other driver until it was too late as they passed by drivers turning from the right hand lane onto the side road they had been at. My airbags did not deploy during the collision, nor did my pre collision assist alert nor did my brake system engage. I suffered extensive front end damage…”
NHTSA complaint #11746859, 2026 · crash

Fuel System 6

“The contact owns a 2021 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V721000 (Seats); however, the parts to do the recall repairs were not yet available. The local dealer was contacted but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure.”
NHTSA complaint #11731407, 2025

“The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. The VIN was not available.”
NHTSA complaint #11694791, 2025

“The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE). The local dealer was contacted; however, the contact was informed that parts were not yet available for the recall repair. The vehicle was not repaired. The manufacturer was contacted about parts availability. The contact had not experienced a failure.”
NHTSA complaint #11681725, 2025

Engine And Engine Cooling 5

“The contact owns a 2021 Ford Bronco. The contact had received notifications of NHTSA Campaign Numbers: 24V635000 (Engine and Engine Cooling), 25V025000 (Suspension), 25V315000 (Back Over Prevention) and 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The local dealer was made aware of the issue and confirmed that parts for all four recalls were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the rear camera intermittently displayed a distort…”
NHTSA complaint #11673354, 2025

“The contact owns a 2021 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 24V635000 (ENGINE AND ENGINE COOLING) and 25V025000 (SUSPENSION); however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.”
NHTSA complaint #11662334, 2025

“The contact owns a 2021 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V025000 (SUSPENSION) and 24V635000 (ENGINE AND ENGINE COOLING); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.”
NHTSA complaint #11654482, 2025

Vehicle Speed Control 4

“I was driving on the highway with standard cruise control (I don't have adaptive cruise) and I went to press the brakes and the brake pedal was SUPER stiff and I had to press unreasonably hard to disengage the cruise control and slow down. When the pedal finally gave, I ended up slamming on the bakes so much that my passenger was startled and we both lurched forward due to our momentum. Afterwards, my brake light light came on, on the dashboard. I went to AutoZone to get a reading and it said it was the brake assist vacuum or something like that. This could have caused a very bad accident in t…”
NHTSA complaint #11744011, 2026

“I was driving on the highway at a speed of approximately 70 miles per hour when the Bronco driver screen gave multiple warning notices and at the same time, the accelerator would not react. Steering power was fine. I was in the second from far left lane on a six lane highway and losing speed quickly. I was able to move to the right and drift to the side of the road without incident. Once stopped, I turned the ignition off and waited a few seconds and then turned it back on again. The error messages all cleared and the Bronco accelerator reacted appropriately. I drove it straight to the d…”
NHTSA complaint #11698141, 2025

“Multiple times the engine has failed to respond to the accelerator pedal when engaged from a cold stop. The delayed response has happened several times while attempting to merge into moving traffic so even a 1 second delay is both dangerous and scary from a driver perspective. The vehicle was taken in for service recently and no problems were identified after mechanic testing. However, I wonder if this problem is related to the ongoing investigation of defective valves in the 2.7L EcoBoost engine.”
NHTSA complaint #11474089, 2022

Exterior Lighting 3

“While driving in snowy conditions the headlights become covered with snow to the point of not illuminating enough to see. Which then makes trying to find a spot to pull over safely to wipe them becomes extremely dangerous. The snow covered lights happens quickly. Creating hazardous driving conditions. The data provided is the most recent. This happens every winter since purchasing this vehicle. I was not familiar with notifying your agency until recently.”
NHTSA complaint #11702446, 2025

“The contact owns a 2021 Ford Bronco. The contact stated that water was entering the vehicle through the roof. While the vehicle was parked, the vehicle started rolling down the hill. The contact stated that the brake pedal was continuously pumping while being depressed. The contact stated that the brake lights were illuminated. Additionally, the vehicle occasionally failed to start. The vehicle was taken to an independent mechanic who replaced the battery. The vehicle was taken to the local dealer where the battery was replaced. The vehicle was returned to the contact with rust and mold throug…”
NHTSA complaint #11672876, 2025

“The contact owns a 2021 Ford Bronco. The contact stated that while operating the vehicle, the brake warning lamp remained illuminated. The vehicle was taken to the local dealer, who diagnosed that the brake booster vacuum line was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 30,000.”
NHTSA complaint #11653165, 2025

Steering 3 1 injury

“Our family was traveling from Lake George New York to Boston MA on Wednesday [XXX]. As we passed another vehicle in the far left lane on [XXX] the vehicle bounced and we lost control of the backend of the vehicle and it "fish tailed" across the highway nearly causing a collision at 65 miles per hour. The anti-lock breaks were activated and we nearly collided with several cars but managed to pull into the emergency lane. The vehicle was not drivable after this incident because any pothole or bump on the highway, at speeds over 50 MPH, made the rear of the vehicle very unstable. It will skid and…”
NHTSA complaint #11648104, 2025 · 1 injury(ies)

“Car began flashing multiple warnings including power steering, brakes, basically all warnings. Power steering and brakes both failed. Took to dealership. Found wires and wire harnesses burnt and melted. Delaliship says it was due to a pinched wire on an after market winch however the winch was installed in 2022 and never had any issue before. They cited damage underneath on the skid plate which is very minor in nature and should not be able to cause such egregious errors.”
NHTSA complaint #11653791, 2025

“Within days of buying this 2021 Bronco in April 2022, the power steering and drive modes (e.g., Eco, Sport) stopped working and we got the following error message: [See Steering Assist Fault - Service Required] We called the dealership in Georgia, which is far from our home, and they advised us to take it to one closer to us; the problem would be covered under warranty. We made the first available appointment with the dealership in Havana FL and took our vehicle in on July 11th. We showed the photo saying "service required" and explained that every morning the drive modes don't work and th…”
NHTSA complaint #11474809, 2022

Visibility 3

“The contact owns a 2021 Ford Bronco. The contact stated that after replacing the windshield wipers a crack formed on the bottom passenger’s side corner of the windshield. The contact stated that the crack then spread up to the top corner of the window shield. The contact stated he called the local dealer who informed him they were unable to repair the vehicle due to not having the part available. The manufacturer was made aware of the failure and a case was opened. The contact stated that he called his insurance company who then referred him to Safelite. Once the contact called Safelite they s…”
NHTSA complaint #11484819, 2022

“The contact owns a 2021 Ford Bronco. The contact stated the front windshield cracked and was repaired by the dealer; prior to the second crack that occurred while driving approximately 35 MPH. The vehicle was taken back to the dealer; however, they diagnosed no failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 9,000.”
NHTSA complaint #11475172, 2022

“The contact owns a 2021 Ford Bronco. While starting the vehicle the contact became aware of a line crack on the front of the windshield. The vehicle was not taken to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 7,337.”
NHTSA complaint #11467210, 2022

Seats 2

“3 separate safety-related components have failed on my 2021 Ford Bronco, all of which correspond to open federal safety recalls that remain unremedied: 1. Infotainment/APIM Module & Backup Camera System (Recall Campaign 26V124): my infotainment screen fails to turn on, particularly in high-temperature conditions. When this occurs, the rearview/backup camera is completely non-functional. The vehicle displays no image when in reverse gear, eliminating all camera-assisted visibility behind the vehicle. This directly matches the conditions described in Recall 26V124, issued March 4, 2026. No reme…”
NHTSA complaint #11731872, 2025

“The contact owns a 2021 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V721000 (Seats); however, the parts to do the recall repairs were not yet available. The local dealer was contacted but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure.”
NHTSA complaint #11731407, 2025

Seat Belts 1 1 injury

“My toddler in his car seat while we were driving, reached over and grab the seatbelt that was closest to his car seat with his hand. As we were driving, he pulled the seatbelt as far out as he could, so that the locking mechanism was activated. After he pulled the seatbelt all the way out, he had wrapped around his neck and let go of it, and the seatbelt ended up tightening around his neck. Luckily, he was able to tell me what happened and I was able to pull off and grab the seatbelt and keep tension on it so it wouldn’t get any tighter around his neck. We had to call the fire department to cu…”
NHTSA complaint #11501595, 2023 · 1 injury(ies)