2021 Chevrolet Trax Problems & Owner Complaints

Electrical System 8 1 crash 1 fire

“The contact owns a 2021 Chevrolet Trax. The contact stated that while driving approximately 45 mph, the AC unit was distributing hot air. The contact detected white smoke emerging from the engine compartment and the vehicle caught fire. The contact was able to pull over and exit the vehicle without injury. There were no warning indicator lights illuminated. The fire department extinguished the fire. A police report was filed. There was the deployment of air bags. The vehicle was towed to a tow yard. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufac…”
NHTSA complaint #11500450, 2023 · fire

“The vehicle has 2 permanent codes. One is a communication blackout, the other code means the hardware is melting. GM is doing a formal inspection in April. The Ucode meant that the engine stopped talking to the transmission or visa versa. The vehicle “ran my daughter and I” off the highway into the dirt, on 2 different occasions. They are described as “catastrophic engine failures”. The last one occurred on MLK Jr Day 2026, before the vehicle was permanently grounded. It could have been fatal. GM is doing a formal investigation to see what liability the have for it because the vehicle is now c…”
NHTSA complaint #11725693, 2026 · crash

“The Turbo Charger failed suddenly without a prior display of a warning light and was replaced by an independent service center in June 2025. I received a letter from GM in November 2025 stating there was a known "condition" that may cause the Turbo Charger to need replacing but a recall was not issued. On 1/22/26 the vehicle suddenly went into "Limp Mode" while driving. The Throttle Body Injection Unit, Engine Coolant Water Outlet, and Coolant were replaced. The coolant had been topped off on 1/20/26. On 1/27/26 the vehicle began shuddering and lost power while I was driving on the highway.…”
NHTSA complaint #11717127, 2026

Engine 6 1 crash

“The vehicle has 2 permanent codes. One is a communication blackout, the other code means the hardware is melting. GM is doing a formal inspection in April. The Ucode meant that the engine stopped talking to the transmission or visa versa. The vehicle “ran my daughter and I” off the highway into the dirt, on 2 different occasions. They are described as “catastrophic engine failures”. The last one occurred on MLK Jr Day 2026, before the vehicle was permanently grounded. It could have been fatal. GM is doing a formal investigation to see what liability the have for it because the vehicle is now c…”
NHTSA complaint #11725693, 2026 · crash

“The Turbo Charger failed suddenly without a prior display of a warning light and was replaced by an independent service center in June 2025. I received a letter from GM in November 2025 stating there was a known "condition" that may cause the Turbo Charger to need replacing but a recall was not issued. On 1/22/26 the vehicle suddenly went into "Limp Mode" while driving. The Throttle Body Injection Unit, Engine Coolant Water Outlet, and Coolant were replaced. The coolant had been topped off on 1/20/26. On 1/27/26 the vehicle began shuddering and lost power while I was driving on the highway.…”
NHTSA complaint #11717127, 2026

“The contact owns a 2021 Chevrolet Trax. The contact stated that while driving 70 MPH, while the roads were clear, dry, and the weather was good, the engine seized, and the vehicle lost motive power and decelerated to 55 MPH. The contact pulled over to the side of the road, and the brake pedal was depressed; however, the vehicle failed to respond and continued driving forward. While driving at 50 MPH, the failure reoccurred. The engine and stabili-trak illuminated after the vehicle came to a complete stop. The local dealer was contacted regarding loaner vehicles on two occasions. The vehicle w…”
NHTSA complaint #11713436, 2026

Service Brakes 6

“The Turbo Charger failed suddenly without a prior display of a warning light and was replaced by an independent service center in June 2025. I received a letter from GM in November 2025 stating there was a known "condition" that may cause the Turbo Charger to need replacing but a recall was not issued. On 1/22/26 the vehicle suddenly went into "Limp Mode" while driving. The Throttle Body Injection Unit, Engine Coolant Water Outlet, and Coolant were replaced. The coolant had been topped off on 1/20/26. On 1/27/26 the vehicle began shuddering and lost power while I was driving on the highway.…”
NHTSA complaint #11717127, 2026

“The contact owns a 2021 Chevrolet Trax. The contact stated that while driving 70 MPH, while the roads were clear, dry, and the weather was good, the engine seized, and the vehicle lost motive power and decelerated to 55 MPH. The contact pulled over to the side of the road, and the brake pedal was depressed; however, the vehicle failed to respond and continued driving forward. While driving at 50 MPH, the failure reoccurred. The engine and stabili-trak illuminated after the vehicle came to a complete stop. The local dealer was contacted regarding loaner vehicles on two occasions. The vehicle w…”
NHTSA complaint #11713436, 2026

“My car is only at around 37,7000 miles. My I have only had it since it was around 15,000 miles. My battery has died at least 4 times due to my alternator having problems charging. My brakes have also gone out on me at one point in the beginning. My battery is now trash and so is my alternator.”
NHTSA complaint #11603491, 2024

Air Bags 3 3 crash 3 injury

“The contact owns a 2021 Chevrolet Trax. The contact stated that while stopped at a stop light, another vehicle rear-ended the vehicle. The contact stated that both the driver and passenger seat belts failed to restrain both occupants. The air bags also failed to deploy upon impact. A police report was filed. The contact managed to drive away from the scene of the accident. The contact and the other occupant both sought medical attention the next day at a hospital. The contact was treated for multiple herniated, torn, and bulging discs on their vertebrae. The contact's passenger also sustained…”
NHTSA complaint #11580674, 2024 · crash · 2 injury(ies)

“The contact owns a 2021 Chevrolet Trax. While the contact's spouse was driving at an undisclosed speed, the vehicle was involved in a crash. While the driver was attempting to avoid striking a deer, the vehicle crashed into a barbed wire fence. The air bags did not deploy. In addition, the contact stated that the engine detached from the vehicle after the crash. The vehicle was towed to a local tow yard. The driver was transported to the local medical center. The driver sustained injuries to the neck and the middle of the back and burns on the left side of the neck from the seat belt. A Police…”
NHTSA complaint #11749612, 2026 · crash · 1 injury(ies)

“My wife was driving and we were hit hard enough to shove the vehicle into the next lane and crumple the undercarriage of the vehicle. Making it undrivable anymore. And any information I can find says side impact air bags will deploy if the vehicle is hit anywhere on the side of the vehicle. Which clearly did not happen in this case. A side note I can only ever find videos on direct side impact not indirect impacts that involves the wheels. In either case the front or back tire impacts will still involve the persons head being slammed into the door window causing head injury.”
NHTSA complaint #11482758, 2022 · crash

Power Train 3 1 crash

“The vehicle has 2 permanent codes. One is a communication blackout, the other code means the hardware is melting. GM is doing a formal inspection in April. The Ucode meant that the engine stopped talking to the transmission or visa versa. The vehicle “ran my daughter and I” off the highway into the dirt, on 2 different occasions. They are described as “catastrophic engine failures”. The last one occurred on MLK Jr Day 2026, before the vehicle was permanently grounded. It could have been fatal. GM is doing a formal investigation to see what liability the have for it because the vehicle is now c…”
NHTSA complaint #11725693, 2026 · crash

“1/23/25 This is the 3rd time the turbocharger has malfunction within 2 1/2 months and is once again at the dealership service department. Horrible smoke was filling the inside of the car while I was driving and smelled as though something was badly burning. The car had began shaking with minimal driving and loss of power. Electric dashboard not working which should indicate if there is any particular problems going on with my Trax. This is a real Safety Hazard. My car should be recalled in order to fix this hazardous problem once and for all!”
NHTSA complaint #11638576, 2025

“My car, which as of today, July 6, 2024 has a mileage of 45349, and is experiencing issues related to the EVAP purge pump under speed. I see that there is already been a recall on multiple models of the Chevrolet tracks, but not mine as it is a 2021 and not a 2020. I have owned this vehicle for two months, and have kept up with all of the maintenance as instructed. But I figured that this malfunction will lead to further damage, including but not limited to blown head gasket or blown engine.”
NHTSA complaint #11599593, 2024

Unknown Or Other 3

“The front exhaust flex pipe leaked by a corrosive hole that allowed exhaust and CO carbon monoxide to escape making the drivers dizzy, nauseated, and with a headache. This also caused the vehicle to smoke, run rough and stall in traffic. This also required the post 02 sensor to be replaced.”
NHTSA complaint #11654663, 2025

“My car, which as of today, July 6, 2024 has a mileage of 45349, and is experiencing issues related to the EVAP purge pump under speed. I see that there is already been a recall on multiple models of the Chevrolet tracks, but not mine as it is a 2021 and not a 2020. I have owned this vehicle for two months, and have kept up with all of the maintenance as instructed. But I figured that this malfunction will lead to further damage, including but not limited to blown head gasket or blown engine.”
NHTSA complaint #11599593, 2024

“The vehicle is very hard to control in high winds. I was driving down the highway on a very windy day the vehicle fishtailed the entire time. Almost rolled the vehicle it’s very dangerous”
NHTSA complaint #11536470, 2023

Fuel/Propulsion System 2

“UNKNOWN I’ve had my car for 11 months. When I first got the car I got it fully inspected and there were minor issues like tires and brakes. However, now the ac compressor is completely damaged and there may be contamination in my lines. This is not an owner issue. I take really good care of my car. I just don’t know how this could’ve happened if this wasn’t a manufacturer related issue.”
NHTSA complaint #11669633, 2025

“On 11/25/24 while my daughter was driving my 2021 Trax all of a sudden the engine light came on and my car lost power while lots of smoke began coming out of the exhaust pipe the car started to shake she thankfully made it to the Dealership service department where the codes showed a FUEL TRIM PROBLEM once that problem was serviced my daughter picked the car up drove my car home and the very next day my Trax engine light came on again and once again it Lost Power my daughter went back to the Dealership service department where the codes showed aTurbocharger problem. I have 33,440 miles on my 2…”
NHTSA complaint #11629369, 2024

Electronic Stability Control (Esc) 1

“The contact owns a 2021 Chevrolet Trax. The contact stated that while driving 70 MPH, while the roads were clear, dry, and the weather was good, the engine seized, and the vehicle lost motive power and decelerated to 55 MPH. The contact pulled over to the side of the road, and the brake pedal was depressed; however, the vehicle failed to respond and continued driving forward. While driving at 50 MPH, the failure reoccurred. The engine and stabili-trak illuminated after the vehicle came to a complete stop. The local dealer was contacted regarding loaner vehicles on two occasions. The vehicle w…”
NHTSA complaint #11713436, 2026

Engine And Engine Cooling 1 1 fire

“The contact owns a 2021 Chevrolet Trax. The contact stated that while driving approximately 45 mph, the AC unit was distributing hot air. The contact detected white smoke emerging from the engine compartment and the vehicle caught fire. The contact was able to pull over and exit the vehicle without injury. There were no warning indicator lights illuminated. The fire department extinguished the fire. A police report was filed. There was the deployment of air bags. The vehicle was towed to a tow yard. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufac…”
NHTSA complaint #11500450, 2023 · fire

Lane Departure 1

“At roughly 20,000 miles, my cars' carplay connection begain to intermittently disconnect. Never could get it to reproduce the same results when at the dealership. At roughly 60,000 miles the VCU (vehicle cockpit unit) began glitching. It would flicker, go black and then come back after a few seconds. Now at 92,xxx miles (don't know how many miles because it's black right now) its off more than its on. I can't get access to important vehicle information including digital speedometer, milage, tire pressure, oil life span, miles left until my gas tank is empty, and more. This makes it impossible…”
NHTSA complaint #11675210, 2023

Seat Belts 1 1 crash 2 injury

“The contact owns a 2021 Chevrolet Trax. The contact stated that while stopped at a stop light, another vehicle rear-ended the vehicle. The contact stated that both the driver and passenger seat belts failed to restrain both occupants. The air bags also failed to deploy upon impact. A police report was filed. The contact managed to drive away from the scene of the accident. The contact and the other occupant both sought medical attention the next day at a hospital. The contact was treated for multiple herniated, torn, and bulging discs on their vertebrae. The contact's passenger also sustained…”
NHTSA complaint #11580674, 2024 · crash · 2 injury(ies)

Structure 1

“The contact owns a 2021 Chevrolet Trax. The contact stated that while driving approximately 50-55 MPH, the driver's side roof rack exterior trim detached and flew off the vehicle. The vehicle was taken to the dealer, where it was inspected. The manufacturer was notified of the failure, and the dealer informed the contact that the manufacturer would partially cover the cost of the repair. The contact declined to pay a fee because the contact believed that the failure was a factory defect. The vehicle was not repaired. The failure mileage was approximately 35,000.”
NHTSA complaint #11729901, 2026

Suspension 1 1 crash 1 injury

“It appears the rear axle separated from the vehicle. This appears to prevented braking ability. My conclusion is from skid marks at the crash scene. Also Front wheels disengaged. I have photos.”
NHTSA complaint #11527411, 2023 · crash · 1 injury(ies)

Visibility 1

“The contact owns Ac condenser became inoperable cluster Mask (ICM). The dealer diagnosed with a failed internal cluster mask. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 115,000.”
NHTSA complaint #11741550, 2026