2021 BMW 3 Series Problems & Owner Complaints

Electrical System 15 3 fire

“The contact owned a 2021 BMW 330i. The contact received notification of NHTSA Campaign Number: 26V056000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 45 MPH, there was smoke coming from under the passenger side fender. The contact entered a nearby parking lot off the highway when the vehicle caught fire. The contact was able to exit the vehicle, and someone inside a nearby building extinguished the fire with…”
NHTSA complaint #11731768, 2026 · fire

“The contact owns a 2021 BMW 330I. The contact stated while driving 50 MPH and coming to a stop at a red traffic light, the contact started smelling smoke. There was no warning light illuminated. The contact turned off the vehicle, but the vehicle failed to restart with a message that the vehicle was unable to be restarted displayed. The contact turned on the hazard lights with the vehicle stopped in the middle of the road. The contact then noticed that there was smoke coming from the front end of the vehicle and immediately called 911. The contact stated that while a Metro service employee was…”
NHTSA complaint #11700817, 2025 · fire

“My BMW 330i 2021 caught on fire while I was driving. Smoke came from the hood, and I open the hood and seen the Fire, and I called the Newark NJ Fire Department. see attached photo of the BMW after the fire.”
NHTSA complaint #11690303, 2025 · fire

Engine 10 1 fire 1 injury

“In Buford GA at the corner of Elm Tree Terrace and Buford Dam road, I was waiting for the light to turn on a decline. It is important to note that the car was driving in all-electric mode on a full charge. Once the light turned green I stepped on the accelerator to go and the car stalled. I believe the transmission slipped. The gears caught at high torque and jolted the car involuntarily forward. I didn't notice it at first but after a couple of sleepless nights with shoulder pain: I got an MRI and was found to have a torn rotator cuff. It is difficult to associate the injury as it is hard to…”
NHTSA complaint #11444952, 2021 · 1 injury(ies)

“My BMW 330i 2021 caught on fire while I was driving. Smoke came from the hood, and I open the hood and seen the Fire, and I called the Newark NJ Fire Department. see attached photo of the BMW after the fire.”
NHTSA complaint #11690303, 2025 · fire

“I am submitting a claim pertaining to NHTSA Recall Number 25V636000 which pertains to a engine starter issue that can result in fire. This recall was reported first on September 23, 2025 and has been gone without a remedy. Since as of today, it has been 212 days without a solution that I am driving a car that may catch fire. This is too long and I am seeking remediation in the form of a replacement vehicle.”
NHTSA complaint #11732736, 2026

Unknown Or Other 5 1 fire

“My BMW 330i 2021 caught on fire while I was driving. Smoke came from the hood, and I open the hood and seen the Fire, and I called the Newark NJ Fire Department. see attached photo of the BMW after the fire.”
NHTSA complaint #11690303, 2025 · fire

“While driving approximately 70 mph on the highway, my vehicle’s sunroof suddenly and violently shattered without any warning. There was no impact from debris, no vehicle in front of me throwing objects, and no prior damage to the glass. The explosion was extremely loud, resembling a gunshot. The sunroof glass appeared to burst outward and then collapse inward, sending broken glass downward. Thankfully, my vehicle has a canvas sunshade beneath the sunroof, which was closed at the time. The sunshade prevented glass from falling directly onto me and my passenger. Without the shade, we likely wou…”
NHTSA complaint #11718178, 2026

“I just became aware from Consumer Reports about an upcoming recall on BMWs because of a potential fire hazard with the engine starter relays. I own a 2021 BMW 330i which is one of the models listed. I entered my VIN on the NHTSA and BMW websites and both sites indicated my vehicle has no open recalls. According to NHTSA, BMW will start notifying owners on November 14 about the recall. In the Consumer Reports article and several other articles I read about the recall, owners are being directed to park their vehicles outside and away from buildings and other vehicles. Owners are expected to wa…”
NHTSA complaint #11690249, 2025

Air Bags 4 1 crash 1 injury

“Going into a parking spot. Applied brakes, then the car did not brake, then it accelerated hitting a Jeep and finally stopped when the driver side front hit a parking barrier and then the air bags deployed. Sudden unintended acceleration was the cause of this accident. Car was totaled.”
NHTSA complaint #11633498, 2024 · crash · 1 injury(ies)

“The contact owns a 2021 BMW 330I. The contact stated that while entering the vehicle, there was an audible alert heard, and a red air bag light was displayed on the instrument panel. The vehicle was taken to the dealer, where it was diagnosed with a failure in the driver’s side knee air bags. The air bags were replaced, and the airbag module was reprogrammed. The manufacturer was notified of the failure. The failure mileage was 30,868.”
NHTSA complaint #11751173, 2026

“My car has ver been wrecked or received any damage to any part of it. While driving to work the following warning popped up on screen. RESTRAINT SYSTEM WARNING, functionality of the airbags, seatbelt tensions, belt force limits reduced.”
NHTSA complaint #11641504, 2025

Forward Collision Avoidance 3 1 crash 1 injury

“Going into a parking spot. Applied brakes, then the car did not brake, then it accelerated hitting a Jeep and finally stopped when the driver side front hit a parking barrier and then the air bags deployed. Sudden unintended acceleration was the cause of this accident. Car was totaled.”
NHTSA complaint #11633498, 2024 · crash · 1 injury(ies)

“This BMW vehicle's odometer readings are inconsistent and inaccurate resulting in overage of mileage for lessee. This cars BMW tires were not verifiable to be from BMW and tires subsequently failed within 15,000 miles. No entity at BMW, not the dealership, not the sales, not BMW Financial Services or BMW of North America LLC could provide any information regarding the original tires or provide any warranty information regarding the tires - this impact mileage efficiency, miles per gallon and is a way to game the systems. BMW front sensors on act erratically sometimes working and sometimes goin…”
NHTSA complaint #11603482, 2024

“When driving the car when dark enough to activate auto headlights and raining enough to activate auto wipers, after 20 minutes the following message comes on the screen EVERYTIME: Drive Assistance temporarily limited Lane departure also turns on and off while driving in these conditions Also attached are BMW's response after inspecting the car on 3 separate occasions”
NHTSA complaint #11508878, 2023

Power Train 3 1 injury

“In Buford GA at the corner of Elm Tree Terrace and Buford Dam road, I was waiting for the light to turn on a decline. It is important to note that the car was driving in all-electric mode on a full charge. Once the light turned green I stepped on the accelerator to go and the car stalled. I believe the transmission slipped. The gears caught at high torque and jolted the car involuntarily forward. I didn't notice it at first but after a couple of sleepless nights with shoulder pain: I got an MRI and was found to have a torn rotator cuff. It is difficult to associate the injury as it is hard to…”
NHTSA complaint #11444952, 2021 · 1 injury(ies)

“1. The engine starter motor (specifically the pinion starter) has failed, and the auxiliary battery is also showing reduced capacity (only a portion of its 660 cold cranking amps). The vehicle is currently at a service center where the technician has diagnosed these issues. The components should be available for inspection upon request, as they have not yet been replaced. 2. The failure of the starter motor and battery primarily affects the vehicle's ability to start. While this could potentially strand you in an unsafe location, the information provided does not indicate any specific sa…”
NHTSA complaint #11720299, 2026

“Engine Wiring is made of Soy products with attracts Rodents to feed and destroy the wiring. When this occurs it puts the driver ad passengers in danger because certain functions such as brake light, Headlights and windshield wipers may not work properly. This is becasue when the wiring is compromised , circuits are broken which causes the vehicle's systems connected to that circuit to partially or completely fail, Rending a vehicle partially or completely inoperable. The vehicle was inspected the the BMW dealership service center and they confirmed it was rodent damage . Geico insurance also…”
NHTSA complaint #11452849, 2022

Lane Departure 2

“This BMW vehicle's odometer readings are inconsistent and inaccurate resulting in overage of mileage for lessee. This cars BMW tires were not verifiable to be from BMW and tires subsequently failed within 15,000 miles. No entity at BMW, not the dealership, not the sales, not BMW Financial Services or BMW of North America LLC could provide any information regarding the original tires or provide any warranty information regarding the tires - this impact mileage efficiency, miles per gallon and is a way to game the systems. BMW front sensors on act erratically sometimes working and sometimes goin…”
NHTSA complaint #11603482, 2024

“When driving the car when dark enough to activate auto headlights and raining enough to activate auto wipers, after 20 minutes the following message comes on the screen EVERYTIME: Drive Assistance temporarily limited Lane departure also turns on and off while driving in these conditions Also attached are BMW's response after inspecting the car on 3 separate occasions”
NHTSA complaint #11508878, 2023

Service Brakes 2 1 crash 1 injury

“Going into a parking spot. Applied brakes, then the car did not brake, then it accelerated hitting a Jeep and finally stopped when the driver side front hit a parking barrier and then the air bags deployed. Sudden unintended acceleration was the cause of this accident. Car was totaled.”
NHTSA complaint #11633498, 2024 · crash · 1 injury(ies)

“On 5/22/24 had a catastrophic failure of the Electric Motor Electronics and 12v Battery. I have requested that the BMW Serice Assistant provide me with all affected parts for inspection. Shutdown of the vehicle high voltage system could result in a crash. When this part fails along with the 12v battery you lose control of all vehicle electronics (steering, braking, electrical power, and propulsion). Yes, there was a previous voluntary recall campaign 19V-599s Service Information Bulletin (Revision 2) which replaced SI B12 27 19 dated October 2019 by BMW for this device. The vehicle and compone…”
NHTSA complaint #11590355, 2024

Suspension 2

“I bought my car in 2023 with 12,000 miles. I currently have 43,000 on it. I don’t drive it hard and have always had the maintenance done. I had my rear brakes replaced today at BMW and I was told my engine mounts have failed and need to be fixed asap. Was given a quote of 3000.00. My warranty expired literally 2 months ago. I’m told it’s dangerous to drive but how does this happen? Everything I read says they should be lasting 60,000-100,000 miles at least.”
NHTSA complaint #11700913, 2025

“The front axle support and the right front control arm bearing bracket may be separating, which is causing my vehicle to continually fall out of alignment. This ongoing issue is leading to accelerated tire wear, despite the fact that I have not driven many miles. The manufacturer needs to address the underlying cause, as the dealership continues to recommend alignments without resolving the root problem. I have already paid for two alignments, yet the vehicle consistently goes out of alignment again.”
NHTSA complaint #11700215, 2025

Engine And Engine Cooling 1 1 fire

“The contact owns a 2021 BMW 330I. The contact stated while driving 50 MPH and coming to a stop at a red traffic light, the contact started smelling smoke. There was no warning light illuminated. The contact turned off the vehicle, but the vehicle failed to restart with a message that the vehicle was unable to be restarted displayed. The contact turned on the hazard lights with the vehicle stopped in the middle of the road. The contact then noticed that there was smoke coming from the front end of the vehicle and immediately called 911. The contact stated that while a Metro service employee was…”
NHTSA complaint #11700817, 2025 · fire

Fuel/Propulsion System 1 1 injury

“In Buford GA at the corner of Elm Tree Terrace and Buford Dam road, I was waiting for the light to turn on a decline. It is important to note that the car was driving in all-electric mode on a full charge. Once the light turned green I stepped on the accelerator to go and the car stalled. I believe the transmission slipped. The gears caught at high torque and jolted the car involuntarily forward. I didn't notice it at first but after a couple of sleepless nights with shoulder pain: I got an MRI and was found to have a torn rotator cuff. It is difficult to associate the injury as it is hard to…”
NHTSA complaint #11444952, 2021 · 1 injury(ies)

Steering 1

“On 5/22/24 had a catastrophic failure of the Electric Motor Electronics and 12v Battery. I have requested that the BMW Serice Assistant provide me with all affected parts for inspection. Shutdown of the vehicle high voltage system could result in a crash. When this part fails along with the 12v battery you lose control of all vehicle electronics (steering, braking, electrical power, and propulsion). Yes, there was a previous voluntary recall campaign 19V-599s Service Information Bulletin (Revision 2) which replaced SI B12 27 19 dated October 2019 by BMW for this device. The vehicle and compone…”
NHTSA complaint #11590355, 2024

Structure 1

“My sunroof exploded randomly, without warning as I was traveling on the highway at approximately 65 MPH. There was no impact from an object. The cloth cover beneath the sunroof was fully intact and undamaged after the incident.”
NHTSA complaint #11449667, 2022

Visibility/Wiper 1

“While I was driving down the highway, sunroof has exploded without any apparent reason. I really didn’t realize what had happened at first, all I heard was a loud bang which could’ve lead to distraction and cause an accident. Luckily it wasn’t the case for me. Although, broken pieces of the sunroof has came off and flown to roadway. I brought the vehicle to BMW dealership, by the time I got there there was an apparent hole in the sunroof, they inspected it and saying it happened because something making contact with sunroof but when I asked for a proof for their claim they told me there is…”
NHTSA complaint #11509033, 2023

Wheels 1

“The front axle support and the right front control arm bearing bracket may be separating, which is causing my vehicle to continually fall out of alignment. This ongoing issue is leading to accelerated tire wear, despite the fact that I have not driven many miles. The manufacturer needs to address the underlying cause, as the dealership continues to recommend alignments without resolving the root problem. I have already paid for two alignments, yet the vehicle consistently goes out of alignment again.”
NHTSA complaint #11700215, 2025