2020 Toyota RAV4 Problems & Owner Complaints

Engine 179 1 crash 2 injury

“On May 12, 2022 I was driving our 2022 Rav4 Hybrid. At about 10 am that morning I arrived at the Sherwin Williams store in Chandler, AZ. I applied the brakes and put the car in park. But the car did not stop! It continued to forge ahead, smashing into the building barrier and even then it kept trying to move forward. 1.The whole front end was smashed. 2.The first responders had to pry open the door to extract me from the car. 3.It was later determined that I had broken a rib. (I was lucky it was not more.) 4.The car was later declared “totaled” by the insurance company. By -standers imme…”
NHTSA complaint #11478017, 2022 · crash · 1 injury(ies)

“My Toyota 2020 RAV 4 Hybrid accelerates in REVERSE when in drive mode and parked on an incline. My car ran over me on 2 occasions while outside the vehicle. Both times I pulled into my driveway, came to a complete stop, and believed I was parked and the car engine was off. Once I exited, I realized my car was still on, reached inside my car to push the off engine button, and the car IMMEDIATELY ACCELERATED in reverse (while in DRIVE MODE/not REVERSE or PARK MODE), knocked me down and pulled me under the front driver side tire and ran over my legs/body. The fire dept and police arrived to t…”
NHTSA complaint #11524904, 2021 · 1 injury(ies)

“Coolant bypass valve leak. An known issue however dealership will not pay for repairs due to vehicle having 106000 mile. 6000 over what the bulletin 24TE04 states it will cover.”
NHTSA complaint #11739682, 2026

Electrical System 119 1 crash 1 fire 4 injury

“The contact owned a 2020 Toyota Rav4. The contact stated that while driving 45 mph with the cruise control activated and while coming to a red light, the driver depressed the brake pedal and the braking system malfunctioned causing the vehicle to not stop. The vehicle drove through a red light causing a collision with a second vehicle. During the crash the driver sustained rib and torso injuries, the front passenger sustained injured ribs and fractured tailbone and the rear passenger side occupant sustained a fractured tailbone. No further information was available regarding the second vehicl…”
NHTSA complaint #11447512, 2021 · crash · 3 injury(ies)

“On 8/25/21, Toyota Rav 4 Vehicle was parked in garage and caught fire burning down garage and house, minor injuries to occupants in house. Vehicle had recently 7/01/21 been repaired at dealership for battery discharge when parked by installation of new update to DCM Software according to TSB-0095-20 Rev2. The vehicle has been inspected by police, Hidalgo County, Texas Fire Marshall and Progressive Insurance Company Progressive. Origin of fire started in vehicle but cause of vehicle fire undetermined by Fire Marshall, Insurance Company related fire to charger plugged into dash of vehicle.”
NHTSA complaint #11447823, 2021 · fire · 1 injury(ies)

“If I don't drive the car for 1 to 2 weeks, the car's 12v is completely drained of power and the care needs to be jumped, otherwise, it will not start. This is consistent. I've taken this to several Toyota dealerships and they all have reported my 12v battery is healthy. However, Toyota is aware and is charging for the fix, labelled as T-SB-0089-21. The known issue is a piece of electronics in the car that continually drains power because it does not properly shut off. This should not be a paid fix. This should be a recall. When the car is jumped and the car finally starts, it reports a…”
NHTSA complaint #11741051, 2026

Unknown Or Other 119 3 crash 1 fire 3 injury

“On May 12, 2022 I was driving our 2022 Rav4 Hybrid. At about 10 am that morning I arrived at the Sherwin Williams store in Chandler, AZ. I applied the brakes and put the car in park. But the car did not stop! It continued to forge ahead, smashing into the building barrier and even then it kept trying to move forward. 1.The whole front end was smashed. 2.The first responders had to pry open the door to extract me from the car. 3.It was later determined that I had broken a rib. (I was lucky it was not more.) 4.The car was later declared “totaled” by the insurance company. By -standers imme…”
NHTSA complaint #11478017, 2022 · crash · 1 injury(ies)

“ON JULY 3, 2020 AT 2:30PM I WAS PARKING THE CAR INTO A PARKING SPACE IN A STRIP MALL WHEN I HAD MY FOOT ON THE BRAKE TO STOP THE CAR BUT THE CAR IMMEDIATELY ACCELERATED AND CRASHED INTO THE PARKED CAR IN FRONT OF ME. WITH MY FOOT STILL ON THE BRAKE, I PUT THE CAR INTO REVERSE, WHEN THE CAR ACCELERATED AGAIN AND JERKED BACKWARDS, WITH MY FOOT STILL ON THE BRAKE, I PUT THE CAR INTO DRIVE AND THE CAR ACCELERATED AND CRASHED INTO THE PARKED CAR IN FRONT ON ME AGAIN FOR THE 2ND TIME. THE AIR BAGS DID NOT DEPLOY. I WAITED FOR THE OWNER OF THE PARKED VEHICLE, THE POLICE ARRIVED ON SITE AND THE CA…”
NHTSA complaint #11338404, 2020 · crash · 1 injury(ies)

“My Toyota 2020 RAV 4 Hybrid accelerates in REVERSE when in drive mode and parked on an incline. My car ran over me on 2 occasions while outside the vehicle. Both times I pulled into my driveway, came to a complete stop, and believed I was parked and the car engine was off. Once I exited, I realized my car was still on, reached inside my car to push the off engine button, and the car IMMEDIATELY ACCELERATED in reverse (while in DRIVE MODE/not REVERSE or PARK MODE), knocked me down and pulled me under the front driver side tire and ran over my legs/body. The fire dept and police arrived to t…”
NHTSA complaint #11524904, 2021 · 1 injury(ies)

Fuel/Propulsion System 89

“Coolant bypass failed at 55,000 miles. This car has barely been used. This car is almost in mint condition and the coolant bypass has failed resulting the car not being able to be driven at all until fixed. The dealer is charging over $600 to repair. This is an ongoing issue with hundreds of Toyota RAV4 owners.”
NHTSA complaint #11600961, 2024

“1. I had to have Injector Fuel Service due to my vehicle having a sluggish feeling while driving from Stop to Start. The vehicle also had a throttling motion while driving. 2. A message appeared on dashboard after a recent visit to the dealership after normal maintenance service, “Engine Maintenance Required” “Reach out to Dealer.” This message specifically shows while I start up my vehicle and will not disappear if cancelled. “This is a warning for a coolant bypass valve failure””
NHTSA complaint #11590766, 2024

“A week prior to this incident, the 2020 RAV4 was taken to Toyota for its maintenance check where everything was checked, replaced and changed. However, the last two days an incessant message keeps popping up on the dash stating “engine maintenance required… Visit your dealer” taking up the entirety of the middle screen inhibiting my ability from seeing my speed, mileage, distance to empty , time, lane assist and other car information that I normally rely on. I have pressed the “arrow back” or “back” button numerous times but three seconds later the message pops again inhibiting me from being a…”
NHTSA complaint #11579309, 2024

Structure 59 2 crash 2 fire 1 injury

“ON JULY 3, 2020 AT 2:30PM I WAS PARKING THE CAR INTO A PARKING SPACE IN A STRIP MALL WHEN I HAD MY FOOT ON THE BRAKE TO STOP THE CAR BUT THE CAR IMMEDIATELY ACCELERATED AND CRASHED INTO THE PARKED CAR IN FRONT OF ME. WITH MY FOOT STILL ON THE BRAKE, I PUT THE CAR INTO REVERSE, WHEN THE CAR ACCELERATED AGAIN AND JERKED BACKWARDS, WITH MY FOOT STILL ON THE BRAKE, I PUT THE CAR INTO DRIVE AND THE CAR ACCELERATED AND CRASHED INTO THE PARKED CAR IN FRONT ON ME AGAIN FOR THE 2ND TIME. THE AIR BAGS DID NOT DEPLOY. I WAITED FOR THE OWNER OF THE PARKED VEHICLE, THE POLICE ARRIVED ON SITE AND THE CA…”
NHTSA complaint #11338404, 2020 · crash · 1 injury(ies)

“The contact owns a 2020 Toyota Rav4. The contact stated that the mirror housings of the vehicle were melting. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 8,500.”
NHTSA complaint #11434064, 2021 · fire

“The contact owns a 2020 Toyota Rav4. The contact stated that the mirror housings of the vehicle were melting. The dealer was made aware of the failure and informed the contact that they could not assist as the failure was a manufacturer defect. The dealer referred the contact to the manufacturer. The manufacturer was notified of the failure advised the contact that they would follow up with the dealer. A case was opened. The contact stated the dealer took photographs of the failure. The contact stated the manufacturer contacted her and informed her that their field experts determined that the…”
NHTSA complaint #11434066, 2021 · fire

Air Bags 55 8 crash 4 injury

“I was traveling at approximately 40mph when a car ran a light and came across in front of me at an intersection. I T-boned the other persons car which totaled my vehicle. The airbags in my vehicle did not deploy and I feel they should have. I was injured and have been to a doctor.”
NHTSA complaint #11534669, 2023 · crash · 1 injury(ies)

“The contact owns a 2020 Toyota RAV4 Hybrid. The contact stated that the vehicle had unintended acceleration at stop signs and red lights. The vehicle was taken to the dealer and diagnosed as having no failure. Four days later, the failure recurred and the vehicle crashed approximately 6 - 8 feet into the corner of the contact's residence. None of the air bags deployed upon impact. The contact received medical treatment the next day for bruising from her neck to groin, a torn rotator cuff, and neck and back injuries. Police and fire department reports were filed. The insurance company had not d…”
NHTSA complaint #11448769, 2021 · crash · 1 injury(ies)

“the car simply a LEMON big time was bought on 08/2020 thru the Santa Monica city Toyota Dealers...they are awful too. let my dad, 80, buy all extra insurances when its brand new car and has 3 years bumper to bumper warranty. he and me his daughter that is dedicated driver sometimes keep complain that its get bazuka after 35--39 and move up miles per hours, power steering wheel Out of control basically. can be turn 65 to 90 degree angle without even sorry to say spitting on it..., the UGLY safety feature that will help you to change the lane on freeway, we wouldn't even will be mentioning th…”
NHTSA complaint #11435490, 2021 · crash · 1 injury(ies)

Power Train 36 1 injury

“My Toyota 2020 RAV 4 Hybrid accelerates in REVERSE when in drive mode and parked on an incline. My car ran over me on 2 occasions while outside the vehicle. Both times I pulled into my driveway, came to a complete stop, and believed I was parked and the car engine was off. Once I exited, I realized my car was still on, reached inside my car to push the off engine button, and the car IMMEDIATELY ACCELERATED in reverse (while in DRIVE MODE/not REVERSE or PARK MODE), knocked me down and pulled me under the front driver side tire and ran over my legs/body. The fire dept and police arrived to t…”
NHTSA complaint #11524904, 2021 · 1 injury(ies)

“The contact owns a 2020 Toyota Rav4. The vehicle was previously taken to a dealer for maintenance, and it was discovered that there was an oil leak underneath the vehicle. The contact stated that the transmission was shifting roughly while driving. The vehicle was driven to a local dealer, where it was diagnosed with transmission failure. There were metal fragments found in the transmission fluid. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 133,000.”
NHTSA complaint #11726424, 2026

“When trying to start my vehicle this morning, the car was having a noticeable issue the minute I turned on the vehicle. It was making some weird noises under the hood, and it was starting to lose power. Then the engine would cut out and a warning would appear on my dash that read, "Engine Stopped, Steering Power Low" Thank God this happened while I was at home. What if this had happened while I was driving down the road, at a red light. I would have been a sitting duck in the middle of the road and would not want to put my kids or I in jeopardy of being hit.”
NHTSA complaint #11713174, 2026

Steering 27 1 crash 1 injury

“the car simply a LEMON big time was bought on 08/2020 thru the Santa Monica city Toyota Dealers...they are awful too. let my dad, 80, buy all extra insurances when its brand new car and has 3 years bumper to bumper warranty. he and me his daughter that is dedicated driver sometimes keep complain that its get bazuka after 35--39 and move up miles per hours, power steering wheel Out of control basically. can be turn 65 to 90 degree angle without even sorry to say spitting on it..., the UGLY safety feature that will help you to change the lane on freeway, we wouldn't even will be mentioning th…”
NHTSA complaint #11435490, 2021 · crash · 1 injury(ies)

“The contact owns a 2020 Toyota Rav4. The contact stated that while driving 20 MPH and making a turn, the vehicle felt like it was going to flip over. There was no warning light illuminated. The contact stated that the dealer was made aware of the failure, but the vehicle was not repaired. The manufacturer was made aware of the issue. The contact stated that the VIN was not included in NHTSA Campaign Number: 20V373000 (Steering). The contact associated the failure with the recall. The failure mileage was approximately 74,000.”
NHTSA complaint #11744881, 2026

“The contact owns a 2020 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with an electronic power steering module failure. The contact was advised to take the vehicle to the dealer. The contact was informed of an unknown recall; however, the VIN was not associated with the recall. The vehicle was not inspected. The contact was provided a diagnostic test fee, and the contact declined. The manufacturer…”
NHTSA complaint #11722079, 2026

Service Brakes 19 4 crash 5 injury

“The contact owned a 2020 Toyota Rav4. The contact stated that while driving 45 mph with the cruise control activated and while coming to a red light, the driver depressed the brake pedal and the braking system malfunctioned causing the vehicle to not stop. The vehicle drove through a red light causing a collision with a second vehicle. During the crash the driver sustained rib and torso injuries, the front passenger sustained injured ribs and fractured tailbone and the rear passenger side occupant sustained a fractured tailbone. No further information was available regarding the second vehicl…”
NHTSA complaint #11447512, 2021 · crash · 3 injury(ies)

“The contact owned a 2020 Toyota Rav4. The contact stated that while pulling into a vertical spot and making a right turn, the vehicle suddenly accelerated, jumped the curb, the sidewalk, and continued driving down the sidewalk and crashed into a building. The brake pedal was depressed but was stuck. The vehicle failed to turn off, and the parking brake failed to engage. There were no warning lights illuminated. The air bags deployed as needed. A Police report was filed. The EMS workers were unable to depress the brake pedal. The undercarriage of the dashboard ripped the skin off both shins. Th…”
NHTSA complaint #11750253, 2026 · crash · 1 injury(ies)

“ON JULY 3, 2020 AT 2:30PM I WAS PARKING THE CAR INTO A PARKING SPACE IN A STRIP MALL WHEN I HAD MY FOOT ON THE BRAKE TO STOP THE CAR BUT THE CAR IMMEDIATELY ACCELERATED AND CRASHED INTO THE PARKED CAR IN FRONT OF ME. WITH MY FOOT STILL ON THE BRAKE, I PUT THE CAR INTO REVERSE, WHEN THE CAR ACCELERATED AGAIN AND JERKED BACKWARDS, WITH MY FOOT STILL ON THE BRAKE, I PUT THE CAR INTO DRIVE AND THE CAR ACCELERATED AND CRASHED INTO THE PARKED CAR IN FRONT ON ME AGAIN FOR THE 2ND TIME. THE AIR BAGS DID NOT DEPLOY. I WAITED FOR THE OWNER OF THE PARKED VEHICLE, THE POLICE ARRIVED ON SITE AND THE CA…”
NHTSA complaint #11338404, 2020 · crash · 1 injury(ies)

Engine And Engine Cooling 15 1 fire

“The contact owned a 2020 Toyota RAV4. The contact stated that the vehicle was parked for approximately nine hours and unoccupied, it spontaneously caught fire without warning. The fire department extinguished the fire. The fire department informed him the fire was due to a failure with the electrical system or fuel pump. There were no reported injuries, air bag deployment or police reports filed. The vehicle was towed to the contact's residence. The local dealer was contacted but the vehicle was not diagnosed or repaired. The insurance company adjuster deemed the vehicle a total loss. The m…”
NHTSA complaint #11494151, 2022 · fire

“The contact owns a 2020 Toyota RAV4. The contact stated that while the vehicle was parked, coolant was observed leaking from the engine compartment with no warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed that the engine casing had failed, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but denied the engine replacement request because the vehicle had previously been serviced by an independent mechanic for engine maintenance. The contact stated that the failure…”
NHTSA complaint #11736379, 2026

“Shortly after having vehicle serviced at Toyota the engine maintenance light came on. Imagine my surprise at learning that many other Rav4 owners have the same exact issue right around the 65,000 mile mark. But regardless I toke it to the Toyota dealer to have them diagnose the issue and under the advisement of the technician opt in for the repair so that my car “wouldn’t have more serious problems as a result [of not fixing the coolant bypass valve].” So now I have to pay $1000 for repair when I have had the car just the tiniest bit over 4 years (which is how long the warranty lasted).”
NHTSA complaint #11655992, 2025

Vehicle Speed Control 14 4 crash 5 injury

“The contact owns a 2020 Toyota RAV4. The contact stated that while driving at 8 MPH to an appointment and making several turns in the parking lot, the vehicle suddenly accelerated and crashed into the building. There were no warning lights illuminated. The top of the vehicle had to be cut off. The driver had a concussion, soft tissue injuries to the neck and back. The passenger sustained a fractured sternum, soft tissue damage, and dementia injuries, The two occupants were provided medical attention. Both of the occupants were wearing seatbelts. The airbags deployed. There was smoke inside th…”
NHTSA complaint #11663963, 2025 · crash · 2 injury(ies)

“The contact owned a 2020 Toyota Rav4. The contact stated that while pulling into a vertical spot and making a right turn, the vehicle suddenly accelerated, jumped the curb, the sidewalk, and continued driving down the sidewalk and crashed into a building. The brake pedal was depressed but was stuck. The vehicle failed to turn off, and the parking brake failed to engage. There were no warning lights illuminated. The air bags deployed as needed. A Police report was filed. The EMS workers were unable to depress the brake pedal. The undercarriage of the dashboard ripped the skin off both shins. Th…”
NHTSA complaint #11750253, 2026 · crash · 1 injury(ies)

“On May 12, 2022 I was driving our 2022 Rav4 Hybrid. At about 10 am that morning I arrived at the Sherwin Williams store in Chandler, AZ. I applied the brakes and put the car in park. But the car did not stop! It continued to forge ahead, smashing into the building barrier and even then it kept trying to move forward. 1.The whole front end was smashed. 2.The first responders had to pry open the door to extract me from the car. 3.It was later determined that I had broken a rib. (I was lucky it was not more.) 4.The car was later declared “totaled” by the insurance company. By -standers imme…”
NHTSA complaint #11478017, 2022 · crash · 1 injury(ies)

Forward Collision Avoidance 10 2 crash

“I was making a turn into a turnaround on the turnpike and ended up sliding into a guardrail. I believe the brake assistance failed because although I slowed down and braked going into the turned, the vehicle felt like it had lost control and continued towards the guardrail rather than into the pathway I was turning into. My safety was at risk from going into the guardrail when my car didn't slow down as much as I would have expected. As of now, a braking problem with 2020 RAV4's has not been confirmed by Toyota but they are set to inspect the facility within the next couple weeks to colle…”
NHTSA complaint #11620437, 2024 · crash

“I bumped the car in front of me when starting from a red light at an intersection. Impact speed was less than 3 MPH. The damage from this impact resulted in repair cost of almost $4,200. This is outrageous and an example of poor design on the part of Toyota. It is my understanding that the standards require vehicles to absorb up to 5 MPH frontal impact with no damage. Had I known this vehicle was so poorly protected I would have chosen to purchase something else.”
NHTSA complaint #11421657, 2021 · crash

“i cant use my cruise control its not going straight and everytime im turning i can hear a grinding noise its coming from power steering”
NHTSA complaint #11673563, 2025

Lane Departure 10 2 crash 1 injury

“the car simply a LEMON big time was bought on 08/2020 thru the Santa Monica city Toyota Dealers...they are awful too. let my dad, 80, buy all extra insurances when its brand new car and has 3 years bumper to bumper warranty. he and me his daughter that is dedicated driver sometimes keep complain that its get bazuka after 35--39 and move up miles per hours, power steering wheel Out of control basically. can be turn 65 to 90 degree angle without even sorry to say spitting on it..., the UGLY safety feature that will help you to change the lane on freeway, we wouldn't even will be mentioning th…”
NHTSA complaint #11435490, 2021 · crash · 1 injury(ies)

“I bumped the car in front of me when starting from a red light at an intersection. Impact speed was less than 3 MPH. The damage from this impact resulted in repair cost of almost $4,200. This is outrageous and an example of poor design on the part of Toyota. It is my understanding that the standards require vehicles to absorb up to 5 MPH frontal impact with no damage. Had I known this vehicle was so poorly protected I would have chosen to purchase something else.”
NHTSA complaint #11421657, 2021 · crash

“Engine maintnance light came on dashboard. Was not aware of this issue until doing research. Parts that needs replace - Cooling Bypass Valve”
NHTSA complaint #11643103, 2025

Suspension 9

“The contact owns a 2020 Toyota Rav4. The contact stated that while driving or while the vehicle was parked, there was water leaking from the sunroof. While driving at an undisclosed speed, there was a loud clunking sound coming from the front of the vehicle. The vehicle was taken to the dealer, where it was diagnosed and determined that front alignment was needed, and that the roof rails needed to be repaired or replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 149,782.”
NHTSA complaint #11716210, 2026

“I took my car to the dealer this week and was told I need to replace both front lower control arms. I noticed other cars for that year have a recall for this specific problem so I called Toyota but I was told that I had 0 recalls on my vehicle.”
NHTSA complaint #11612737, 2024

“The front suspension has problem I noticed recently the sway bar and front studs of the car is not reliable and also the fuel tank also has issue even if the tank is not fuel it refuses to take more fuel”
NHTSA complaint #11517936, 2023

Visibility/Wiper 9

“Driving at highway speeds with no other vehicles around, sunroof closed but shade open, sunroof exploded. Edges of sunroof that didn't fall in were pushed up as if an over pressure condition had occurred. There was no evidence of anything striking the glass found upon inspection. Quick internet search confirms others with this same make/model have experienced the same issue.”
NHTSA complaint #11602886, 2024

“It is a common occurence on the 2020 models that the driver and passenger side mirrors begin to extrmely shake after being exposed to water. There are rentention clips that just fall out which results in the mirror itself beiginning to shake extremely making the driver disoriented along with making it very difficult to use see traffic coming from behind. Especially in high speed situations such as freeways.”
NHTSA complaint #11533188, 2023

“Windshield cracked right below windshield wiper on passenger side. No damage prior to crack, appears windshield failed. Car is not even two years old yet. Reading online this is a common failure point for the windshield on the Rav4, but Toyota will not acknowledge it.”
NHTSA complaint #11473898, 2022

Visibility 8 1 crash 2 fire 3 injury

“The contact owned a 2020 Toyota Rav4. The contact stated that while driving 45 mph with the cruise control activated and while coming to a red light, the driver depressed the brake pedal and the braking system malfunctioned causing the vehicle to not stop. The vehicle drove through a red light causing a collision with a second vehicle. During the crash the driver sustained rib and torso injuries, the front passenger sustained injured ribs and fractured tailbone and the rear passenger side occupant sustained a fractured tailbone. No further information was available regarding the second vehicl…”
NHTSA complaint #11447512, 2021 · crash · 3 injury(ies)

“The contact owns a 2020 Toyota Rav4. The contact stated that the mirror housings of the vehicle were melting. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 8,500.”
NHTSA complaint #11434064, 2021 · fire

“The contact owns a 2020 Toyota Rav4. The contact stated that the mirror housings of the vehicle were melting. The dealer was made aware of the failure and informed the contact that they could not assist as the failure was a manufacturer defect. The dealer referred the contact to the manufacturer. The manufacturer was notified of the failure advised the contact that they would follow up with the dealer. A case was opened. The contact stated the dealer took photographs of the failure. The contact stated the manufacturer contacted her and informed her that their field experts determined that the…”
NHTSA complaint #11434066, 2021 · fire

Seats 6

“on 5/28/24 the vehicle air bag lights and front passenger seat light was flashing and an alarm continuously went off with a message to visit a dealer for service. On 5/29/24 the vehicle was brought in for inspection to a Toyota dealer. I was told an electrical wiring needed to be replaced. Dealership did that but it did not correct the issue. Codes were not resetting. They are now saying it is a wiring/electrical issue under passenger seat and saying they have been communicating with Toyota. We do not have a Toyota extended warranty but vehicle has 32K miles and are told by dealership Toy…”
NHTSA complaint #11592133, 2024

“The contact called on behalf of her daughter who owns a 2020 Toyota Rav4. The contact stated while the vehicle was parked, her pregnant daughter attempted to move the driver's seat back, and the seat failed to respond as intended. The contact stated the vehicle could not be driven because the seat distance could not be adjusted to drive properly. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 32,000.”
NHTSA complaint #11590482, 2024

“I am reporting a PROBLEM - the headrests on the front driver and passenger seats will NOT stay down on my 2020 Toyota Rav4- they always slowly keep moving upwards- I guess from the natural vibrations of the road. I complained at the Toyota service department (at Wilde Toyota in Milwaukee Wisconsin) and they said that is how their headrests work in the Toyota Rav4 - they don't stay down. While this may not be an issue for a tall person, an average person of 5 ft 5 inch tall or shorter would have a serious problem with their head being smacked around when the headrest won't stay down - I have…”
NHTSA complaint #11432370, 2021

Latches/Locks/Linkages 4

“In March 2025 the driver door lock stopped working electronically and would only work manually. In August 2025 the passenger door lock stopped working noisy of the time. In Dec 2025 the rear passenger side does lock stopped working most of the time.”
NHTSA complaint #11745836, 2025

“The rear hatch liftgate hinges are not adequately structured to withhold pressure under normal use. Over varied short durations of time from the vehicle being new, the rear liftgate hinge's structure fails. The hinges split and crack. This damage occurs despite factory liftgate struts being in plate to assist in the opening of the liftgate. In my case this issue first appeared during and after a snowstorm. A multitude of similar complaints on forums. This has caused my liftgate to misalign and not close. I have had to turn off the auto liftgate and slowly close it despite it is now r…”
NHTSA complaint #11573768, 2024

“My 2020 Rav4 back trunk hinge is coming loose, there for the truck won't close evenly. I took it to dealership to get it fixed, but instead they blamed me but its clearly a manufacturing problem they don't want to take responsibility for it.”
NHTSA complaint #11572802, 2024

Seat Belts 4

“Rear middle seatbelt sensor keeps going off when driving.”
NHTSA complaint #11723797, 2026

“Rear seat seat belt warning and chimes comes up even when no one sitting in the back and no stuff is put on the back seat. It start chiming randomly and even when all 3 seat belts are buckled the chime comes up. It is security risk as the sudden sound of warnings can distract drive when driving and can cause accident. This model of Rav 4 does not have option to disable this feature, and cause lot of annoyance when random warning chimes start blaring through the vehicle without any reason and resolution. Toyota is refusing to do anything about it in spite of multiple forums reported this issue…”
NHTSA complaint #11679002, 2025

“The contact owns a 2020 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer, where the driver's side seat belt sensor was replaced. Additionally, the contact stated that the vehicle had failed to exceed 1,000 RPM while driving. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufactu…”
NHTSA complaint #11625465, 2024

Electronic Stability Control (Esc) 2

“BATTERY "DIED" THE BEGINNING OF AUGUST - JUMP STARTED AND DROVE TO THE DEALERSHIP SERVICE CENTER. I WAS TOLD THAT THE BATTERY WAS FINE AND THAT "SHORT DISTANCE" DRIVING CAN DRAIN THE BATTERY - SINCE I DRIVE 45 MILES A DAY TO AND FROM WORK, THAT IS NOT A VALID "EXCUSE". NOW, 3 WEEKS LATER, MY CAR WAS PARKED ON A FLAT SURFACE FOR 36 HOURS WITH NOTHING LEFT ON - AND THE CAR IS COMPLETELY DEAD. TESTED THE BATTERY MYSELF BEFORE JUMPSTARTING IT - AND IT FULL. ABSOLUTELY NO REASON WHY MY CAR SHOULD NOT START.”
NHTSA complaint #11350829, 2020

“I PURCHASED THE VEHICLE (NEW) ON 6/03/2020. ON 6/16/2020, WARNING LIGHTS AND BUZZERS WENT ON AS I WAS DRIVING THE VEHICLE. THE WARNINGS TOLD ME THAT THERE WAS A PROBLEM WITH MY BRAKES, AND THAT I SHOULD PULL OVER AS SOON AS POSSIBLE. I DROVE TO A NEARBY PARKING LOT. THE BRAKES CONTINUED TO WORK. I TURNED THE CAR OFF AND RESTARTED IT, THINKING IT MIGHT BE A COMPUTER GLITCH IN WHAT WAS A BRAND NEW CAR. WHEN I RESTARTED THE CAR, I BACKED OUT OF MY PARKING SPOT TO "TEST" THE BRAKES. THE CAR STOPPED, BUT THE BRAKES SEEMED WEAKER. ULTIMATELY, THE VEHICLE WAS TOWED TO THE DEALERSHIP. THE DEALER'S SER…”
NHTSA complaint #11330262, 2020

Exterior Lighting 2

“Vehicle was taken in for a oil change. At check-in I was told that I would be given a rental vehicle due to the overhead rails recall, leaking inside the vehicles at that time I advised of a gas smell which I have been smelling for several years and it was getting stronger. I was told that there was something wrong with the fuel pump and it would need to be replaced and they would also be replacing rails from the top of my vehicle because there was water leaks inside my car, I advised that water has been leaking in my car for several years and clips were already placedbout two years ago. Seve…”
NHTSA complaint #11571919, 2024

“BATTERY ISN'T HOLDING A CHARGE. TEMPS OUTSIDE ARE GETTING COLDER BUT NOT THAT COLD. DON'T DRIVE IT ON SUNDAYS, BATTERY IS DEAD DEAD ON MONDAY MORNINGS. DRIVE AN AVERAGE OF 30 MILES PER DAY. BATTERY WAS REPLACED BY DEALERSHIP AND STILL SLOW TO START IN THE MORNINGS. NOW RUN IT IDLING FOR 20 MINUTES SUNDAY EVENING TO ENSURE IT STARTS MONDAY MORNING”
NHTSA complaint #11375593, 2020

Wheels 2 1 crash

“TPS monitoring systems were reading or installed on the wrong tires. Asked if possibly the sensors need to be recalibrated after rotations, dealership said no the vehicle is suppose to relearn the new location. One morning my front tire said it was low, added air and rechecked it with a handheld PSI reader. Also visually checked it for nails or defects. Tire appeared fine so I got in to drive home. It was the rear tire that blew on the interstate driving home not the front left which was the one that was telling me was low. I did look at the rear while getting in the vehicle. It didn’t appea…”
NHTSA complaint #11452160, 2021 · crash

“TWO RIGHT HAND SIDE TIRES BLEW OUT WHEN EXITING THE FREEWAY. THERE WAS NO WARNING ABOUT LOW TIRE PRESSURE AND IN ADDITION TO THAT, THIS IS A BRAND NEW 2020 LEASED VEHICLE (1 YEAR OLD). ALL FOUR TIRES NEEDED TO BE REPLACED.”
NHTSA complaint #11415329, 2021

Carry Handle 1

“The shell latching mechanism is no longer latching and or latching to the base.”
NHTSA complaint #11576427, 2024