2020 Hyundai Santa Fe Problems & Owner Complaints

Engine 70 1 crash 3 fire 2 injury

“The contact owned a 2020 Hyundai Santa Fe. The contact stated that while driving 40 MPH onto the ramp, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact was able to pull over to the side of the road. The vehicle stalled and shut off, and the contact was unable to restart the vehicle. The contact was calling for Roadside Assistance and noticed white smoke coming from under the hood. The stated that the smoke then turned dark brown and then black, and then flames appeared under the hood. The contact grabbed several things of value and exited the veh…”
NHTSA complaint #11701574, 2025 · fire · 1 injury(ies)

“On Thursday, May 11, 11:45 am, I experienced a distressing incident at Moulton Elementary School in Laguna Niguel, CA, 92677. my car was parked near the school building, with the engine turned off and the gear set to park. I was there to pick up my children, and at that time, nobody was inside the vehicle. Unexpectedly, my car started moving backward as if in neutral gear, despite being in park mode. I estimate I was approximately 10 feet from the vehicle in front of the school building. The situation was alarming because numerous children were nearby, which could have resulted in a tragedy. T…”
NHTSA complaint #11522585, 2023 · crash · 1 injury(ies)

“After having a warranty repair for a valve cover gasket' at CENTEREACHHYUNDAI, I picked up my car. Only 8 minutes into my drive home the engine light went on and engine error code appeared. At that piont smoke was coming from the hood when I heard a pop and flames appeared at my passenger side window. I turned the car off removed my phone and exited the vehicle. No one else was in the car but within minutes the fire was totally involved. I also noted it took the fire department very long to arrive. If anyone was trapped in the car they would have peristed.”
NHTSA complaint #11553828, 2023 · fire

Unknown Or Other 38 2 crash 4 fire 2 injury

“I am writing to formally express my serious concerns regarding an ongoing safety issue with a certified used vehicle I purchased from McDonough Hyundai, [XXX] , in December 2024 and the dealership’s repeated failure to resolve the issue, even after a car accident occurred due to this malfunction. Two months after purchase, I discovered that my horn did not work when I attempted to use it. I brought the vehicle back for service and was told the issue had been resolved. However, the horn continued to malfunction. I have returned to the dealership approximately five times with the same complaint.…”
NHTSA complaint #11689845, 2025 · crash · 1 injury(ies)

“I have a 202 Hyundai Sante Fe. I was pulling into a parking garage parking spot, going about 3 miles per hours. Suddenly about 3 feet away from the wall (with my foot on the break) my SUV's engine suddenly race and propelled me forward into the wall. No warning lights or messages. No front- end auto breaking, I have reported it to Hyundai. I was injured from the air bag and the seat belt, my passenger was not injured. I am waiting for my SUV to be assessed by my insurance and my auto body company. I have read many articles about circumstances like these and am considering contacting an a…”
NHTSA complaint #11465643, 2022 · crash · 1 injury(ies)

“A few days ago, while driving on one of Chicago’s busiest expressways, my Hyundai 2020 Santa Fe with only 56,000 miles and a complete record of up-to-date maintenance, suddenly started smoking, smoke coming from under the front hood then caught fire without any warning. The fire consumed the entire front end of the vehicle from underneath the car to the top hood of car, to make matters worse, my seatbelt temporarily locked up during those critical moments, compounding the terror of the situation, potential risk to my life and property. I am incredibly grateful that I was able to escape unharme…”
NHTSA complaint #11665954, 2025 · fire

Electrical System 23 1 crash 1 fire 1 injury

“On Thursday, May 11, 11:45 am, I experienced a distressing incident at Moulton Elementary School in Laguna Niguel, CA, 92677. my car was parked near the school building, with the engine turned off and the gear set to park. I was there to pick up my children, and at that time, nobody was inside the vehicle. Unexpectedly, my car started moving backward as if in neutral gear, despite being in park mode. I estimate I was approximately 10 feet from the vehicle in front of the school building. The situation was alarming because numerous children were nearby, which could have resulted in a tragedy. T…”
NHTSA complaint #11522585, 2023 · crash · 1 injury(ies)

“The vehicle seat caught fire overnight, Sept 26th, and was discovered the morning of Sept 27th 2024. The fire was contained to inside the vehicle and melted parts of the driver seat and lower part of steering wheel. The vehicle interior was covered in orange dust and had extremely toxic smell inside. Insurance 3rd party inspected and declared it a total loss. A few weeks later, a neighbor and fellow Hyundai SantaFe owner mentioned that he had heard of an issue with the Santa Fe catching fire. With this new information, I called Hyundai to alert them. Hyundai opened an investigation, but clo…”
NHTSA complaint #11629667, 2024 · fire

“Vehicle experiences severe, intermittent, un-commanded steering inputs from the Lane Keeping Assist (LKA) system at highway speeds (55-70 MPH). The steering wheel violently jerks toward adjacent traffic lanes/shoulders without operator input, lane drift, or warning, requiring immediate high-force manual intervention to overpower mechanical torque and prevent a collision or roadway departure. Chronology of manufacturer notice: - Oct 2024: Initial consumer dispute logs flagged steering safety concerns and unresolved campaign items. - Dec 2024: Opened Corporate Case 24164934, formally alerting c…”
NHTSA complaint #11743968, 2026

Power Train 23

“I am currently burning through 2.5 quarts of oil approximately every 800 miles.”
NHTSA complaint #11751503, 2026

“The contact owns a 2020 Hyundai Santa Fe. The contact stated that he received an unknown service campaign from the manufacturer indicating that a software update for emissions was needed. The vehicle was taken to a dealer where an ECU update was completed and an NP001-SC9C2 was installed for the engine and transmission. The contact stated that when his wife drove the vehicle home from the dealer, she noticed that something was wrong with the vehicle but did not specify the failures. The contact stated that the next day, while driving at an undisclosed speed, the vehicle hesitated and shifted i…”
NHTSA complaint #11740021, 2026

“I was driving on the road and all of the sudden my car went limp and would only move 45 miles per hour. I took it to the dealer which I have lifetime powertran on my car. It has been there for over a month at the dealer. They asked me to provide all oil changes,services, and registrations. I did that and then fidelity asked them to tear down the engine again to see if I had carbon build up. Then after the dealer did that they ask the dealer to tear the motor down even further to see if the exhaust valve was bad and if it was bad they would not replace my motor. My car consumed so much oil th…”
NHTSA complaint #11720704, 2026

Forward Collision Avoidance 14 1 crash 2 injury

“I was at a standstill waiting for oncoming traffic to pass with my foot on the brake and all of a sudden the car accelerated and the forward collision warning fail to come on and I hit a trailer because of it”
NHTSA complaint #11731625, 2026 · crash · 1 injury(ies)

“I was pulling out of a sidestreet and realized a car was coming and used the brake. The Automatic Braking system activated and VIOLENTLY stopped the car. I was only going about 5 miles an hour but the tremendous force from the Braking system caused my rotator cuff and my bicep to tear. It cost me thousands to pay for surgery and physical therapy. I am very worried about all the injuries that this system causes. I have since had the dealership turn it off. I can not risk being injured like that because the car thinks that there will be a collision when I know that my manual braking was suffici…”
NHTSA complaint #11533367, 2022 · 1 injury(ies)

“I am reporting severe safety risks and inspection fraud on my AWD 2020 Hyundai Santa Fe (VIN: [XXX]) caused by Universal Hyundai in Orlando. Inspection Fraud: The dealer falsified safety metrics, marking my brakes as a failing 4mm to push a $659.90 repair (RO# XXX), then passed those exact brakes at 5mm eleven days later (RO# XXX). Tire Malpractice: Mechanics over-inflated my tires to a dangerous 39 PSI and botched the alignment. This caused structural tire belt separation and severe sidewall bulges. The rear tire has suffered rapid, catastrophic deflation, dropping flat to 14.5 PSI and down t…”
NHTSA complaint #11749944, 2026

Visibility 14

“The contact owns a 2020 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 21V00M000 (Visibility); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.”
NHTSA complaint #11751040, 2026

“The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving 50-55 MPH, the sunroof made an abnormal, exploding sound and shattered. The shade cover was closed during the failure. There was no injury sustained. The vehicle was driven to the workplace of the contact's brother-in-law, and the sunroof was taped to prevent the shattered glass from flying off. The vehicle was then taken to the dealer, where it was inspected. The contact was informed that it was a common failure caused by the intermittent expansion of the body of the vehicle under certain temperatures. The vehicle…”
NHTSA complaint #11734584, 2026

“The contact owns a 2020 Hyundai Santa Fe. The contact stated that while his wife was driving approximately 60 MPH, the sunroof shattered outward. The contact stated that his wife was able to drive the vehicle safely back to the residence. The vehicle had not been taken to a dealer nor an independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 72,000.”
NHTSA complaint #11725909, 2026

Fuel/Propulsion System 11 2 crash 1 injury

“I parked my 2020 Hyundai Santa Fe in a hospital parking garage on the morning of July 30, 2024. I was getting ready to leave after my doctor’s appointment. I slowly reversed my car and hit a pillar behind me. As I put the car into drive to come forward slowly, the car accelerated forward at a very fast speed. I took my foot off of the gas and kept pressing the brake pedal, but the car kept speeding forward on its own and I crashed headfirst into a concrete wall. The impact cracked the concrete barrier on the outside of the parking garage. The air bags deployed, causing fractures in my st…”
NHTSA complaint #11605859, 2024 · crash · 1 injury(ies)

“I PULLED INTO THE DRIVEWAY AND PUT ON THE BRAKES WHEN THE VEHICLE ACCELERATED AND RAN INTO THE GARAGE AND THE FRAME. THERE ARE TIRE MARKS ON THE CEMENT SHOWING THE BRAKES WERE APPLIED. I'VE HAD PROBLEMS WITH THE ACCELERATE CUTTING OUT WHILE ON THE FREEWAY ON RAMP.”
NHTSA complaint #11354175, 2020 · crash

“I took my vehicle in to the dealership on April 24, 2026 for a software update after receiving notice in the mail. The update changed my auto stop/start so that it is on whenever the vehicle is started. When removing my foot from the brake the car surges forward without me touching the gas peddle. I took my Hyandai back in to the dealership on May 4, 2026, and was told that the auto stop/start was supposed to now be staying on as that was in the software update. They said they could not duplicate the surging of the vehicle. It has surged strong enough to move forward, while stopped at an i…”
NHTSA complaint #11739708, 2026

Service Brakes 10 4 crash 3 injury

“I was at a standstill waiting for oncoming traffic to pass with my foot on the brake and all of a sudden the car accelerated and the forward collision warning fail to come on and I hit a trailer because of it”
NHTSA complaint #11731625, 2026 · crash · 1 injury(ies)

“I parked my 2020 Hyundai Santa Fe in a hospital parking garage on the morning of July 30, 2024. I was getting ready to leave after my doctor’s appointment. I slowly reversed my car and hit a pillar behind me. As I put the car into drive to come forward slowly, the car accelerated forward at a very fast speed. I took my foot off of the gas and kept pressing the brake pedal, but the car kept speeding forward on its own and I crashed headfirst into a concrete wall. The impact cracked the concrete barrier on the outside of the parking garage. The air bags deployed, causing fractures in my st…”
NHTSA complaint #11605859, 2024 · crash · 1 injury(ies)

“On Thursday, May 11, 11:45 am, I experienced a distressing incident at Moulton Elementary School in Laguna Niguel, CA, 92677. my car was parked near the school building, with the engine turned off and the gear set to park. I was there to pick up my children, and at that time, nobody was inside the vehicle. Unexpectedly, my car started moving backward as if in neutral gear, despite being in park mode. I estimate I was approximately 10 feet from the vehicle in front of the school building. The situation was alarming because numerous children were nearby, which could have resulted in a tragedy. T…”
NHTSA complaint #11522585, 2023 · crash · 1 injury(ies)

Lane Departure 8

“I am reporting severe safety risks and inspection fraud on my AWD 2020 Hyundai Santa Fe (VIN: [XXX]) caused by Universal Hyundai in Orlando. Inspection Fraud: The dealer falsified safety metrics, marking my brakes as a failing 4mm to push a $659.90 repair (RO# XXX), then passed those exact brakes at 5mm eleven days later (RO# XXX). Tire Malpractice: Mechanics over-inflated my tires to a dangerous 39 PSI and botched the alignment. This caused structural tire belt separation and severe sidewall bulges. The rear tire has suffered rapid, catastrophic deflation, dropping flat to 14.5 PSI and down t…”
NHTSA complaint #11749944, 2026

“Vehicle experiences severe, intermittent, un-commanded steering inputs from the Lane Keeping Assist (LKA) system at highway speeds (55-70 MPH). The steering wheel violently jerks toward adjacent traffic lanes/shoulders without operator input, lane drift, or warning, requiring immediate high-force manual intervention to overpower mechanical torque and prevent a collision or roadway departure. Chronology of manufacturer notice: - Oct 2024: Initial consumer dispute logs flagged steering safety concerns and unresolved campaign items. - Dec 2024: Opened Corporate Case 24164934, formally alerting c…”
NHTSA complaint #11743968, 2026

“Just read possible recalls on Hyundai Santa Fe's 2025 and 2026's. Just spent $1727.68 at the Hyundai dealership in Gilbert, AZ to replace the front camera do to the faults showing up on the dash. By reading that article it made aware of what may have occurred had we not taken it in for service. This vehicle is a 2020 Sante Fe. You may want to check into it. Oh, I want a refund.”
NHTSA complaint #11739954, 2026

Structure 8

“OVER THE LAST 4 WEEKS (NOTICED APRIL 15 AROUND 6PM GOING TO CHURCH) THE PASSENGER FRONT DOOR OPENS AUTOMATIOCALLY WITHOUT ANYONE OPENING IT. THE DOOR IS LITTERALLY LOCKED AND SFERT DRIVEING THE DOOR JUST OPENS. FROM 4/15/26 UNITL 5/7/2026 THIS HAS HAPPENDED 5 TIMES.”
NHTSA complaint #11736577, 2026

“2020 Hyundai Santa Fe quartz white pearl paint and the paint is blowing off as I drive in multiple places. I took it to the dealer because when I called they said there's a Z05 recall on white Hyundai paint and it would be covered. When I take it in, they say 2020's weren't covered because the paint issue was corrected in 2020, when clearly it wasn't. In any case Hyundai agreed to pay 65% of the cost, nothing more. THEY NEED to include all years that present this issue. Unfortunately I've now picked my car up and the paint in the areas that were painted are a different color white. I'm n…”
NHTSA complaint #11734970, 2026

“The roof of my car between the sunroof and the windshield (called panoramic sunroof) shattered as I was driving down the highway. It was about 10:00 pm on a weeknight and there were no cars within sight distance in front of me. When it happened it sounded like a gun shot going off at point blank range and I immediately pulled over and checked for bullet holes. Since it was dark I could not see any damage. Today I took the car and had a small chip fixed in my windshield down by the windshield wipers and the service tech pointed out to me that the roof was shattered. He told me that this happens…”
NHTSA complaint #11718307, 2025

Air Bags 7 4 crash 7 injury

“We were driving on interstate 49 going south near Chester Arkansas when traffic came to a stop. I was rear ended by a vehicle driving 75 mph. My car hit the car in front of me where there was damage to both the passenger and driver side front area of the car. No airbags deployed in spite of the severity of the front and rear impact of the vehicle. I sustained three compression fractures to my back with several abrasions and bruises. Both my vehicle and the vehicle in front of me were declared total losses.”
NHTSA complaint #11740682, 2026 · crash · 3 injury(ies)

“Air bags didn’t deploy on a front crash. Safety of my entire family in car was put at risk without airbags deploying. The problem has not been confirmed. The vehicle has not been inspected, a first responder on scene of crash said we should check into why our air bags didn’t deploy. No warnings signs”
NHTSA complaint #11739408, 2026 · crash · 2 injury(ies)

“To Whom It May Concern, I am writing to formally report repeated safety system failures in my Hyundai vehicle that have resulted in significant injury and ongoing hardship. The first incident occurred in 2021, when my vehicle was struck from the front by another driver who fled the scene. Despite the impact causing visible front-end damage, the airbags did not deploy, and the seatbelt did not engage properly. The vehicle was repaired by an authorized Hyundai dealership, yet at no point was I informed that the vehicle’s safety systems might be compromised or that it should not be driven. The…”
NHTSA complaint #11693361, 2024 · crash · 1 injury(ies)

Engine And Engine Cooling 6

“The contact's daughter owns a 2020 Hyundai Santa Fe. The contact received a notification for an unknown emissions recall. The vehicle was taken to a local dealer, where it remained for three weeks, and an ECU software update was completed. The vehicle was then driven to the contact's residence. Upon restarting the vehicle, the vehicle jerked and chugged while driving. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was approximately 84,000.”
NHTSA complaint #11749004, 2026

“The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at 45 MPH, the check engine warning light illuminated. After scanning the vehicle, the contact received a code for torque converter damage. The vehicle was taken to the local dealer, where it was diagnosed, and the TCM update was needed. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, where it was diagnosed with transmission failure. The vehicle was repaired, but the failure persisted. The oil light was illuminated and then turned off. The contact became aware tha…”
NHTSA complaint #11690708, 2025

“The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving at higher speeds, the vehicle experienced a momentary loss of motive power. The check engine warning light was illuminated. An unknown local dealer was contacted, but the vehicle was not diagnosed or repaired due to the cost. The contact stated that prior to the failure, the vehicle was taken to Auto Zone where a diagnostic scanner was used to diagnose the vehicle. The contact was informed that the MAP sensor had failed and needed to be replaced. The vehicle was taken to Advance Auto Parts where, the DTC code: P2565; wa…”
NHTSA complaint #11627682, 2024

Steering 6

“Vehicle experiences severe, intermittent, un-commanded steering inputs from the Lane Keeping Assist (LKA) system at highway speeds (55-70 MPH). The steering wheel violently jerks toward adjacent traffic lanes/shoulders without operator input, lane drift, or warning, requiring immediate high-force manual intervention to overpower mechanical torque and prevent a collision or roadway departure. Chronology of manufacturer notice: - Oct 2024: Initial consumer dispute logs flagged steering safety concerns and unresolved campaign items. - Dec 2024: Opened Corporate Case 24164934, formally alerting c…”
NHTSA complaint #11743968, 2026

“While driving, the engine catastrophically failed without warning, causing an immediate loss of power-assisted braking and steering. The failure occurred while traveling downhill. I was unable to slow or control the vehicle properly and was forced to proceed through a school bus’s flashing lights to avoid a potentially catastrophic collision, resulting in a traffic citation. My son was in the vehicle at the time. A sudden loss of engine power, braking assist, and steering assist while driving presents a serious safety defect. Vehicle was towed to Fred Beans Hyundai in Doylestown where it has b…”
NHTSA complaint #11716098, 2026

“Engine oil disappear at 2,000 miles. Car dead stop while driving without any warning ️ break fails at 95 degrees curves. Steering wheel loose and make noise. Hyundai dealer refused to fix the issue.”
NHTSA complaint #11649290, 2025

Visibility/Wiper 5

“2020 Hyundai Santa Fe Limited. The panoramic sunroof glass suddenly shattered/exploded without a collision and without any known impact. Glass shattered completely and created a safety hazard to occupants and traffic. Vehicle was purchased as Hyundai Certified Pre-Owned in 2021. Hyundai corporate case has been opened and advised dealer inspection. Dealer inspection is pending. Photos are available. Request that this be logged as a potential safety issue involving panoramic sunroof glass failure.”
NHTSA complaint #11744729, 2026

“The front piece of the panoramic sunroof spontaneously shattered while sitting in my parked vehicle. I heard a loud pop and saw that the entire piece of glass was totally shattered. I took it to the dealership and they told me it is a known problem with this type of sunroof on their vehicles, they said it is not covered by warranty. The estimated repair cost was over $800. Had I been driving down the road with the sunroof open, it could have presented serious safety risks.”
NHTSA complaint #11720545, 2025

“I had been driving my vehicle for about 5 minutes when I heard what sounded like a loud bang or gunshot followed by the sound debris falling. I realized the front piece of my panoramic sun roof had literally exploded. When I got out to look at it the glass around the hole was pointed upwards so it looked like it exploded from the inside out. The glass had no prior damage and nothing hit it before the explosion. I was on a paved road by myself.”
NHTSA complaint #11544448, 2023

Tires 4

“Failed tire in question: Tire failed immediately when apparent road hazard occurred on a major freeway. Exited freeway and located a area where I was able to pull over. After changing said tire (Kumho 235.60/R18) I attempted to inspect tire and found the steel belt failed (punctured). Upon further investigation I observed that the steel belt has covered with less than as less than a 1/6th inch of rubber thereby exposing the belt for a potential failure. At this point the mileage said tire was 7700. As of yet the tire warranty has not been confirmed. This tire was delivered on a new 2020…”
NHTSA complaint #11432499, 2021

“The driver rear tire may be leaking air and the pressure monitoring system shows the pressure is 27-28. The car was brought brand new from Hyundai of Torrance, CA on 20 Jan 2020 and as of this date, 23 May 2021, the mileage is 2,007 miles. I have taken the car into the dealership twice about the tire (second time was on 20 May 2021) and they keep saying they don't fix tires and it may have a slow leak. I find this unacceptable and I feel like I'm being taken advantage of (I'm a senior citizen). I plan on driving to another state and I want to ensure the safety of myself and passengers. J…”
NHTSA complaint #11418228, 2021

“WAS DRIVING DOWN THE ROAD ABOUT 40 MPH, SLOWED DOWN TO ABOUT 10 TO 15 MPH TO MAKE A RIGHT HAND TURN WHEN THE RIGHT REAR TIRE ON MY 2020 HYUNDAI SANTA FE VIN: [XXX], EXPLODED RIPPING SEVERAL INCHES INTO THE SIDEWALL. HAD NO KNOWLEDGE OF HITTING ANYTHING ANY TIME PRIOR TO THE TIRE EXPLODING AND NOTHING IN THE ROADWAY TO CAUSE SAID DAMAGE AT THE SIGHT OF THE EXPLOSION. TEMPERATURE AT THE TIME OF THE EXPLOSION WAS ABOUT 55 DEGREES, NOT TO COLD OR TO HOT. HAD ONLY DRIVEN ABOUT 3 OR 4 MILES ON THE TIRE PRIOR TO EXPLOSION, SO HEAT WAS MOST LIKELY NOT PART OF THE PROBLEM. TIRES WERE MADE BY HANKOOK TI…”
NHTSA complaint #11402818, 2021

Vehicle Speed Control 4 2 crash

“I was backing out of a parking spot and suddenly the car accelerated backwards into a wall. The floor mat was NOT on the accelerator pedal. Obviously, I might have accidently pressed the gas pedal. But, I strongly believe I did not. For me to be mistaken, all three of the following would have to be true: 1) I would have had to put my foot on the accelerator by mistake, even though I am of sound mind and body, I was not distracted, and I have been driving for decades without having done such a thing. 2) I would have had to continue holding my foot to the gas pedal even as I felt myself rac…”
NHTSA complaint #11650148, 2025 · crash

“On May 17th, I had an oil change completed on my 2020 Hyundai Santa Fe at a Hyundai dealership. On May 18th, I was parking my Santa Fe in a parking lot with which I am very familiar. I parked in front of the building, but realized that I had not pulled up far enough to the curb. I went to pull up a couple feet and as I started to put my foot on the gas pedal, I heard the engine roar and take off. I hit the brake, but it didn't stop, and I drove through the window and into the building. I was stunned. I have been driving for 44 years, and I have never had an accident that has been my fault…”
NHTSA complaint #11471608, 2022 · crash

“Frequent intermittent dash warning lights, no speed indicated, no tach indicated, cycles through warnings of safety systems malfunctioning. No lane departure, no adaptive cruise, no cruise, no forward collision warning, no blind spot warning. The disabling of these systems puts all drivers at risk. Dealership replaced front camera and windshield to fix this issue. Not fixed, continues to alarm at random times while driving.”
NHTSA complaint #11663466, 2025

Wheels 4 1 injury

“The Driver's-side rear wheel came completely off the vehicle while traveling at 65 mph on Interstate 75. The vehicle violently swerved into the left lane, and then my wife was able to pull off to the right side of the road. She almost tipped over from the side of the road being on a steep incline. A couple of days before this, the vehicle was at the Hyundai dealership getting a 'Service' where they changed the oil and performed a 'safety' inspection. They did NOT perform the inspection, but lied on the form saying all systems passed. They reluctantly admitted that they didn't do the inspect…”
NHTSA complaint #11470577, 2022 · 1 injury(ies)

“I am reporting severe safety risks and inspection fraud on my AWD 2020 Hyundai Santa Fe (VIN: [XXX]) caused by Universal Hyundai in Orlando. Inspection Fraud: The dealer falsified safety metrics, marking my brakes as a failing 4mm to push a $659.90 repair (RO# XXX), then passed those exact brakes at 5mm eleven days later (RO# XXX). Tire Malpractice: Mechanics over-inflated my tires to a dangerous 39 PSI and botched the alignment. This caused structural tire belt separation and severe sidewall bulges. The rear tire has suffered rapid, catastrophic deflation, dropping flat to 14.5 PSI and down t…”
NHTSA complaint #11749944, 2026

“Front drivers side wheelwell cover come off on the highway, I could have had a wreck”
NHTSA complaint #11589505, 2024

Fuel System 3

“The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving approximately 40 MPH, the vehicle started shaking and lost power. The check engine warning light was illuminated. The vehicle was restarted immediately. The vehicle was taken to a dealer, where it was diagnosed and determined that the engine had an air leak with the fuel. The contact added that the leak was stopped after an undisclosed repair, but the failure reoccurred a day later. The vehicle was taken to the same dealer however, the failure could not be duplicated. The vehicle was then taken to the same dealer a…”
NHTSA complaint #11699220, 2025

“The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle suddenly lost motive power. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that one bolt on the fuel pump was sheared off and another was extremely loose. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 63,000.”
NHTSA complaint #11574032, 2024

“TL* THE CONTACT OWNS A 2020 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING TRANSPORTED, THE CONTACT LEARNED THAT THE GAS CAP HAD DETACHED FROM THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO O'BRIEN HYUNDAI OF FORT MYERS (2850 COLONIAL BLVD, FORT MYERS, FL 33966; (239) 277-1222) WHERE THE GAS CAP WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND OPENED A CASE. THE APPROXIMATE FAILURE MILEAGE WAS 4,862.”
NHTSA complaint #11378654, 2020

Seat Belts 3 1 crash 1 injury

“To Whom It May Concern, I am writing to formally report repeated safety system failures in my Hyundai vehicle that have resulted in significant injury and ongoing hardship. The first incident occurred in 2021, when my vehicle was struck from the front by another driver who fled the scene. Despite the impact causing visible front-end damage, the airbags did not deploy, and the seatbelt did not engage properly. The vehicle was repaired by an authorized Hyundai dealership, yet at no point was I informed that the vehicle’s safety systems might be compromised or that it should not be driven. The…”
NHTSA complaint #11693361, 2024 · crash · 1 injury(ies)

“Nothing just have a question for me and my friends that all own newer Hyundai SUV’s that seem to be having similar seatbelt issues”
NHTSA complaint #11674369, 2025

“Front passenger seat belt will no longer click and lock into place. When held in place by hand, the warning lamp turns off and the audible warning alert turns off. It has not yet been checked by any service department.”
NHTSA complaint #11636032, 2025

Exterior Lighting 2

“There is a problem with the car's headlights. They are having to be replaced every couple months. I have taken it to the dealership and they told me it would be several hundreds of dollars to diagnose, but cannot tell me anything upon inspection other than needs replacement. We are having to purchase new bulbs every 2-3 months. One side goes out, then the other. We are being careful when replacing them, not to handle them with our fingers and using the bulb lubricant as advised per the parts store. I have receipts for multiple headlamp purchases.”
NHTSA complaint #11683923, 2025

“Intermittently when you turn the left turn signal, it will be a delay of 2-3 seconds to actually turn on the lights. Usually it happens in the morning when cold.”
NHTSA complaint #11548093, 2023

Trailer Hitches 2 1 fire 1 injury

“The contact owned a 2020 Hyundai Santa Fe. The contact stated that while driving 40 MPH onto the ramp, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact was able to pull over to the side of the road. The vehicle stalled and shut off, and the contact was unable to restart the vehicle. The contact was calling for Roadside Assistance and noticed white smoke coming from under the hood. The stated that the smoke then turned dark brown and then black, and then flames appeared under the hood. The contact grabbed several things of value and exited the veh…”
NHTSA complaint #11701574, 2025 · fire · 1 injury(ies)

“The contact owns a 2020 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number:23V181000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.”
NHTSA complaint #11525587, 2023

Back Over Prevention 1

“We are experiencing exactly what is listed in HYUNDAI TSB #21-BE-005H: intermittent abnormal camera image display conditions on the instrument cluster when the turn left signal is turned on or the radio screen when transmission is in reverse.”
NHTSA complaint #11458051, 2022

Chest Clip 1

“The harness adjustment button on my Nuna RAVA car seat has failed, preventing the harness from being properly tightened. This makes it impossible to securely restrain my child. This issue involves the same harness adjustment mechanism that Nuna previously addressed in a voluntary recall, where debris could cause the adjuster to malfunction and result in a loose harness. The seat has not been misused and is within its expected usable lifespan. Despite this, Nuna has refused to repair or replace the seat, stating it is out of warranty. This is a safety-critical failure that directly impacts ch…”
NHTSA complaint #11741452, 2026

Latches/Locks/Linkages 1

“Driver’s door is not opening brought it to freeman Hyundai here in Irving and after a month I am still experiencing the same problem.”
NHTSA complaint #11482863, 2022

Suspension 1

“La guagua a tenido problemas con el tren delantero. Comenzó con un sonido en el Guía. La Hyundai le reparo esa pieza y luego continuó con el mismo ruido. Ahora tienen que cambiarle el Rack and Piñogn. Mi guagua tiene solo 19,750 millas creo que vino mala de fábrica.”
NHTSA complaint #11559501, 2023