2020 Ford Ranger Problems & Owner Complaints

Power Train 45

“The truck is currently at a certified ford dealer for diagnosis with a drive train fault. I suspect it is transmission-related, but was not given the history of all stored, pending and history of the codes. The truck exhibits unprovoked forward acceleration/violent lunging when braking to a stop and when driving at low speeds, making intersection control dangerous. It also has severe delayed gear engagement, causing high engine RPM spikes followed by sudden gear slamming, creating a sudden loss of acceleration power while attempting to merge into active highway traffic. The transmission sym…”
NHTSA complaint #11752157, 2026

“I previously submitted another complaint about a 2020 Ford Ranger I own (tracking number 11707667). I own a 2020 Ford Ranger and had to have the transmission replaced at 86k miles. Since having it replaced, I have experienced all the same problems with the transmission. There have been extremely aggressive shifts, jolts, and lags. It has stalled when going through intersections and more. It has been extremely dangerous. The truck is now back in the shop and the new transmission is undergoing a valve body replacement. The new transmission has less than 15k miles and it is undergoing major repai…”
NHTSA complaint #11750072, 2026

“Transmission is awful jerky, jumps in and out of gear, causing engine rpm’s to go really high. Shifts erratically, causing me to almost rear end other vehicles. Very dangerous situations a many occasions. Won’t accelerate at times when pulling out in to traffic, causing other drivers to slow down or get in to another lane suddenly. This has happened on many occasions”
NHTSA complaint #11747502, 2026

Engine 16

“Coolant intrusion defect that affects other 4 cyl ecoboost Ford engines occurred on this regularly serviced per Ford recommendations vehicle as well. Engine failure at highway speeds could cause a severe accident as the engine can seize when coolant mixes with the oil. The vehicle has been inspected by a Ford dealership. The only warning sign that there was a problem was a coolant temperature threshold exceeded warning.”
NHTSA complaint #11753512, 2026

“Transmission replacement needed. Truck has been at dealership going on 3 months with continued delays. It was acknowledged cooperate was covering replacement now story changed that owner/myself having to pay $4000+. Cooperate covering $000 . Current owner/myself bought 2 years ago with 13000 miles and has only put 6000 miles on it. Dealership and cooperate admitted to known problem assured coverage however put fixing on hold because they are behind due to staffing issues. I have been bounced around to 3 different people at dealership who have taken case over. Dealership and cooperate blaming…”
NHTSA complaint #11750461, 2026

“Bought 2020 Ford Ranger Lariat in March 2024 with 13k miles. I have had no issues and have kept up maintenance needed. Vehicle currently has 19,128 miles and on 4/17/26 while driving the vehicle lost power. I was able to pull over and immediately called the dealership where vehicle was purchased and had towed to their facility for diagnosis. There we no warning lights prior to losing power. The dealership informed me a new transmission is needed pulling codes P0751 and P2700. The cost they informed me for replacement was $10k +/= indicating the Power Train warranty had expired in 2025. (5 yr/6…”
NHTSA complaint #11734620, 2026

Unknown Or Other 13

“Bought 2020 Ford Ranger Lariat in March 2024 with 13k miles. I have had no issues and have kept up maintenance needed. Vehicle currently has 19,128 miles and on 4/17/26 while driving the vehicle lost power. I was able to pull over and immediately called the dealership where vehicle was purchased and had towed to their facility for diagnosis. There we no warning lights prior to losing power. The dealership informed me a new transmission is needed pulling codes P0751 and P2700. The cost they informed me for replacement was $10k +/= indicating the Power Train warranty had expired in 2025. (5 yr/6…”
NHTSA complaint #11734620, 2026

“Back up camera intermittently fails to operate giving a squiggly picture or a blank black screen. I have seen many articles involving the same issues with Ford Broncos and where recalls have been issued for those vehicles. When will the NTSB be calling for Ford to recall other vehicles models having the same issues?”
NHTSA complaint #11727296, 2026

“Rear view camera screen freezes, has distortion and is sometimes blank. This has been an issue for several months and I keep seeing articles regarding this problem and that Ford is recalling various vehicles for the same issue but have not been notified of a recall for my vehicle model and year.”
NHTSA complaint #11695059, 2025

Electrical System 11

“I bought the 4x4 Ford Ranger specifically to be towed behind my motor home and followed the directions on how to set up the Flat-tow feature that allows the Ranger to be towed behind my motorhome. I had traveled to a number of Good Same Rallys without any trouble with the Ranger. I use it also as my main vehicle at home to go to store, church etc. On my last trip to Branson, MO while coming home there was a noise that sounded like my brakes on the Ranger were locked up. I took my foot off the gas pedal and it stopped, I proceeded on home when it did this several times. Each time it would…”
NHTSA complaint #11693049, 2025

“Rearview camera malfunction. Screen on rearview mirror goes from blue color to blank. The vehicle's air conditioning does not blow cold air. Stays at warm temperature. Cannot hear pump kick on for A/C.”
NHTSA complaint #11667906, 2025

“The blend door for HVAC controls sticks, makes clicking noises. From time to time it will stick in one position, for example cabin, when I need defrost, making it difficult to see safely potentially.”
NHTSA complaint #11626414, 2024

Service Brakes 9 3 crash 4 injury

“The contact owned a 2020 Ford Ranger. The contact stated that while driving at 5-10 MPH downhill onto a leveled road and approaching a traffic light, the brake pedal was depressed but failed to respond. The vehicle accelerated unintendedly. There were no warning lights illuminated. The contact continued to depress the brake pedal but it failed to respond. The vehicle crashed into two vehicles. However, the vehicle continued to accelerate unintendedly. The contact then purposely crashed into a tree on the side of the road in other to stop the vehicle. The air bags deployed. The contact sustaine…”
NHTSA complaint #11468410, 2022 · crash · 3 injury(ies)

“On 04-07-2021 I was traveling West on Florida S.R. 60 / US 301; WHEN A CAR IN FRONT OF ME WAS STOPPING. I APPLIED THE BRAKES AND FAILED TO STOP IN TIME; HITTING THE REAR END OF THE AUTO IN FRONT OF ME. IT APPEARS TO ME THAT THE BRAKES DID NOT WORK CORRECTLY TO STOP. I FEEL (FELT) LIKE THE BRAKE PEDAL WHEN APPLIED FELT LIKE AIR IN THE BRAKE LINE SYSTEM. THE BRAKE PETAL ALMOST WENT ALL THE WAY TO THE FLOOR. THEIR WAS ONLY ABOUT 3130 MILES ON THE VEHICLE AT THE TIME OF THIS INVIDENT. I STILL FEEL THAT THERE IS A PROBLEM WITH THE BRAKES AND HAD THEM CHECKED BY THE DEALER ON 08-20-2021 WHERE THEY…”
NHTSA complaint #11431344, 2021 · crash · 1 injury(ies)

“OUR NEW 2020 FORD RANGER XLT LISTED A FEATURE CALL PRE-COLLISION ASSIST W/AEB. THE TRUCK DID NOT GIVE A WARNING NOR DID IT APPLY THE BRAKES AUTOMATICALLY. NOTHING OCCURRED BEFORE WE RAN INTO THE REAR END OF THE CAR IN-FRONT OF US. THE CAR AHEAD WAS STOPPED AT A TRAFFIC LIGHT AND WE RAN INTO THE REAR END AT ABOUT 20 MPH.”
NHTSA complaint #11375688, 2020 · crash

Exterior Lighting 6

“Rear brake lights did not work, but high mount brake light functioned normally. I found a safety recall for the 2019 Ford Ranger for the same condition (19S43). This safety recall identifies connector C442 as the root cause for the incident. Based on this information, I located the connected. I disconnected the connector, did visual inspection. Visual inspection did not find any bent pins, so I reconnected connector. After inspection and reconnection of connector C442 the brake light now work. A little background on me. I’m a retire Service Engineer from Nissan and I have extensive ba…”
NHTSA complaint #11659506, 2025

“The taillight on the driver's side has never worked properly. Took it for repair to get a replacement bulb. Personnel at local auto parts store were aware of problems on this model vehicle. They stated no replacement bulbs were available because it required an electronic "bulb." Was informed that the part was VERY expensive, so was unable to get replacement part. Was pulled over by local police and told no lights in rear of vehicle, including brake lights were working. Consumer reports reported same problem with 2019 Ford Ranger and had article "Ford Recalls Ranger Pickup Trucks for Ta…”
NHTSA complaint #11651773, 2025

“I purchased a 2020 Ford Ranger truck which had, either a faulty "bulb," or other type of device which caused the driver side tail light to not illuminate. I was not made aware of this, as I do not commonly check to see if the taillights were when I turn on the lights to drive at night. However, I observed the faulty taillight probably a year or so after owning the vehicle. The vehicle is not frequently driven, as I brought the 2020 Ford Ranger truck new, and it presently as of April 2025 has about 7300 miles on it. When I became aware of the faulty taillight, I went to the local AutoZone store…”
NHTSA complaint #11651930, 2025

Forward Collision Avoidance 6 2 crash

“On two separate instances the truck accelerated on it own and the brakes were used but didn't stop the vehicle had to turn the key off and the second of these two incidences the truck hit a wall and kept accelerating digging the ground up”
NHTSA complaint #11464340, 2022 · crash

“OUR NEW 2020 FORD RANGER XLT LISTED A FEATURE CALL PRE-COLLISION ASSIST W/AEB. THE TRUCK DID NOT GIVE A WARNING NOR DID IT APPLY THE BRAKES AUTOMATICALLY. NOTHING OCCURRED BEFORE WE RAN INTO THE REAR END OF THE CAR IN-FRONT OF US. THE CAR AHEAD WAS STOPPED AT A TRAFFIC LIGHT AND WE RAN INTO THE REAR END AT ABOUT 20 MPH.”
NHTSA complaint #11375688, 2020 · crash

“The contact owns a 2020 Ford Ranger. The contact stated that while driving at unknown speeds, the front camera fault service required and pre-collision assist not available, messages were displayed. There was an abnormal chiming sound detected. The safety features were disabled. The vehicle was taken to the local dealer, who informed the contact to clean the camera. The dealer used an ODB scanner but retrieved no codes and informed the contact to schedule a service appointment. The vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that there were no open recalls…”
NHTSA complaint #11586502, 2024

Vehicle Speed Control 6 2 crash 3 injury

“The contact owned a 2020 Ford Ranger. The contact stated that while driving at 5-10 MPH downhill onto a leveled road and approaching a traffic light, the brake pedal was depressed but failed to respond. The vehicle accelerated unintendedly. There were no warning lights illuminated. The contact continued to depress the brake pedal but it failed to respond. The vehicle crashed into two vehicles. However, the vehicle continued to accelerate unintendedly. The contact then purposely crashed into a tree on the side of the road in other to stop the vehicle. The air bags deployed. The contact sustaine…”
NHTSA complaint #11468410, 2022 · crash · 3 injury(ies)

“On two separate instances the truck accelerated on it own and the brakes were used but didn't stop the vehicle had to turn the key off and the second of these two incidences the truck hit a wall and kept accelerating digging the ground up”
NHTSA complaint #11464340, 2022 · crash

“Date/Time: [XXX] Approximately 3:00PM local Weather: About 10F, light wind. No precipitation. Event Description: Vehicle had sat for > 12 hours. Started vehicle and operated wipers to clear snow. Vehicle was in 2WD; Shifted to “D” and began driving forward down driveway slowly; normal throttle response. Shifted from 2WD to 4WD. 4WD engaged, and there was normal throttle response. After driving for about 15 seconds, near end of driveway, removed foot from accelerator to slow to see if there was traffic. I saw that there was none and tried to accelerate. No throttle response; the vehicle came to…”
NHTSA complaint #11643926, 2025

Back Over Prevention 5

“Backup camera isn't working a recall on some 2020 rangers has been issued but not mine. Parking collision warning isn't as loud as it used to be. Took it t ford garage but they wanted to charge me to do diagnostics. Warning onbackup camera call your service department”
NHTSA complaint #11689153, 2025

“My rearview camera sometimes will not work. Ford has many recalls for this but not for my 2020 Ranger.”
NHTSA complaint #11654040, 2025

“Wiring in components failed resulting in non functioning cross traffic alerts and blind spot detection. Problem found by independent mechanic, ford warranty does not cover.”
NHTSA complaint #11663676, 2024

Seat Belts 5

“The contact owns a 2020 Ford Ranger. The contact stated that while parking and removing the seat belt, the belt retracted quickly wrapping around their child's neck. The contact was able to stop the vehicle and release the child; however, the seat belt still failed to retract properly. No injuries were reported. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,000.”
NHTSA complaint #11586126, 2024

“Rear seat latch does not work resulting in seat collapsing forward when braking and would also collapse in an accident. Seat belts and child car seat would not be functional. Appears to be a common problem based on our research on the Internet. Salinas Ford dealership rep stated repairs are not covered because it is not a seat belt. This vehicle only has 2,758 miles, even though it is a 2020.”
NHTSA complaint #11573596, 2024

“Driver seat belt will not automatically/fully return. I have brought the issue to the attention of Service Advisors at two different Ford dealership's. They acknowledge the problem but note there is no fix available from Ford. Aside from having to manually feed the belt back each time used a safety issue could exist if slack remains in the belt when driving.”
NHTSA complaint #11481442, 2022

Structure 5

“Presently, my mileage is approximately 42770. It has started to exhibit vibration throughout the cab. It wasn't as prevalent during the cold and would only last about 30 seconds, after warm up, and around 70 mph. Now that it has gotten warmer, it is happening after warm up at all speeds. I haven't take it to the dealership yet, but have read reports of the problem with the same model year.”
NHTSA complaint #11569621, 2024

“The contact owns a 2020 Ford Ranger. The contact stated that while driving at various speeds, an abnormal squeaking sound was coming from the rear passenger’s side of the vehicle. There was no warning light illuminated. The vehicle was taken to a dealer however, the dealer was unable to determine the cause of the failure. The manufacturer was also notified of the failure and the contact was given a case number. The vehicle was not diagnosed or repaired. The failure mileage was approximately 10,000. The contact stated that the vehicle was totaled and there is no need to proceed with this compl…”
NHTSA complaint #11553994, 2021

“REAR PASSENGER SIDE DOOR IS HARD TO OPEN AND CLOSE. MY SEVEN YEAR OLD CAN'T OPEN IT WITHOUT HELP ON THAT SIDE. WARNING LIGHT COMES ON WHILE DRIVING SOMETIMES WHEN IT IS CLOSED. AFTER PARKING THE PROBLEM CAUSES THE REAR TAILGATE TO STAY ON TO DRAIN BATTERY BECAUSE TRUCK REGISTERS THE DOOR AS AJAR. HAVE TO SLAM AND RELOCK SEVERAL TIMES TO GET WARNING AND LIGHTS TO TURN OFF. WHEN AN OBJECT IS IN THAT DOOR'S POCKET THE PROBLEM IS WORSE AND IT MAY MAKE THE ALARM GO OFF HOURS AFTER PARKING. OFTEN TAKES SEVERAL ATTEMPTS OF OPENING AND CLOSING DOORS AND TURNING INTERIOR LIGHTS ON AND OFF TO GET THE TR…”
NHTSA complaint #11395113, 2021

Visibility 5

“The contact owns a 2020 Ford Ranger. The contact stated while starting the vehicle, the heating system became inoperable. The contact stated that the heater would not function properly. The vehicle was taken to the dealer where it was diagnosed that the HVAC blower motor failed and needed to be replaced. The vehicle was not repaired. The contact was referred to the NHSTA Hotline for assistance. The approximate failure mileage was 86,000.”
NHTSA complaint #11635073, 2025

“Vehicle has 51,532 miles and a blend door actuator needs to be replaced - inconsistent air flow coming in. The desired air wanted whether it be hot or cold, is being diverted incorrectly, so we are not getting a consistent temperature out of the A/C system. This item was recalled previously In the 2019 Ford Ranger.”
NHTSA complaint #11560748, 2023

“At one point, the heat/ac would blow air but would not heat or cool. This was about a month and a half ago., There was an electrical burning smell, and at that point the system would not heat or cool. The burning smell has since subsided. I took the truck to Santa Maria Ford to have it looked at and have my oil changed. I was told that it would cost 3500.00 to repair the issue. I looked the issue up and I found that the 2019 Ford Ranger had been recalled for this exacted issue. I felt that it was just a matter of time before the 2020 Ford Ranger would be recalled for this item. I decided to I…”
NHTSA complaint #11559859, 2023

Suspension 4

“2020 Ford Ranger XL: Total failure of both rear leaf spring assemblies (detached from bushing). Discovered during routine maintenance at approximately 47K miles. Both rear leaf spring assemblies failed in the same location where spring meets the bushing at fwd spring attachment leaving the rear of the truck supported by the rear shock assemblies only. Technician assessment showed no damage to associated rear suspension components, minimal corrosion, and no sign of collision or impact causing failure - suspect latent manufacturing defect in original OEM part as OEM has since updated original pa…”
NHTSA complaint #11726096, 2026

“Brought the vehicle to the dealer for standard 40,000 mile service. When it was raised on their lift, the rear end dropped out because both driver and passenger side leaf springs had broken at the mount bushings. The springs had been broken for some time, as there was significant rust at the broken points. The truck drove normally. This was only discovered once the truck was on a service lift. The weight of the truck was resting on the intact part of the springs, but may have completely disconnected if I had hit a large enough bump while the springs were broken. This would certainly have ca…”
NHTSA complaint #11706732, 2025

“The dri er side leaf spring broke at the fro t bushing attachment. The bushing is completely rusted and cracked.”
NHTSA complaint #11682178, 2025

Visibility/Wiper 4

“Clicking sound coming from under the dash. I traced it to the blend door assy. Defrost intermittently will disengage. Vehicle has 29,600 miles on it”
NHTSA complaint #11733994, 2026

“The blend door for HVAC controls sticks, makes clicking noises. From time to time it will stick in one position, for example cabin, when I need defrost, making it difficult to see safely potentially.”
NHTSA complaint #11626414, 2024

“Early model 2019-2020 Ford Rangers have a known defect where the blend door actuator fails. The assembly was redesigned mid 2020 and is now the common fix for all who are affected by this issue. During this failure the blend door cannot and will not actuate as it should causing in ability to defrost the windshield causing visibility issues. Additionally, it causes unbearable heat to be released inside the vehicle with no warning causing additional safety issues for drivers and passengers. The issue is widely observed for all owners of early generations. Even though ford has known about the is…”
NHTSA complaint #11615914, 2024

Air Bags 3 2 crash 2 injury

“WE WERE HEADING EAST ON A CITY STREET WHEN WE CAME TO AN INTERSECTION. THE LIGHT WAS GREEN SO WE CONTINUED THROUGH THE INTERSECTION. THERE WAS ANOTHER CAR HEADING WEST ON THE SAME STREET AND TURNED LEFT DIRECTLY IN FRONT OF US AT THE INTERSECTION. WE WERE TRAVELING BETWEEN 40-45 MPH. WE COULD NOT AVOID THE CAR THAT TURNED IN FRONT OF US. WE HIT THE SIDE OF THE SECOND VEHICLE (THE ONE TURNING SOUTH) HEAD ON WITH OUR VEHICLE. THE AIRBAGS IN OUR VEHICLE DID NOT DEPLOY. BOTH THE FIREMAN AND SHERIFF ON THE SEEN COMMENTED ON THE FACT THAT OUR AIRBAGS SHOULD HAVE DEPLOYED. ALSO AFTER OUR VEHICLE WAS…”
NHTSA complaint #11360875, 2020 · crash · 2 injury(ies)

“Hit a tree head-on going 30+mph. Impact point on the vehicle was next to the airbag sensor. Air bags did not deploy”
NHTSA complaint #11715693, 2026 · crash

“Truck continues to have airbag lights on even after repairs at ford dealership. The first time it happened it would only come on when cold and would go off after 30-45 minutes. When airbag light was on gauges, heat and air and stereo would not work. That was November 2020. The dealership replaced Body Control Module and other electrical components. June 2021 the airbag light is on again. The code it’s giving is short in passenger airbag circuit. The truck is also saying that rear driver door is open when shut and continually tries to lock and unlock doors. Interior lights stay on because the…”
NHTSA complaint #11423070, 2021

Engine And Engine Cooling 2 1 fire

“The contact owned a 2020 Ford Ranger. The contact stated that his wife had parked the vehicle in the residence driveway and was bringing purchases into the residence when she returned to the vehicle she observed that gray smoke was being emitted from under the hood. The contact came out to the driveway, observed the smoke, and saw that flames were coming from the driver's and passenger side of the hood. The contact stated that the fire department was called but when they arrived the vehicle was engulfed from the front to the rear. The contact stated that the fire department extinguished the fl…”
NHTSA complaint #11649542, 2024 · fire

“The contact owns a 2020 Ford Ranger. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to restart; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into the engine, which caused a failure with the spark plugs. The contact was informed that the spark plugs needed to be replaced. Additionally, the contact was informed that an engine appearance shield needed to be installed over the engine. The vehicle was not repaired. The manufacturer…”
NHTSA complaint #11607514, 2024

Fuel/Propulsion System 2

“When driving between 40 & 45 miles per hour truck start jerking and skipping also burning lots more fuel.”
NHTSA complaint #11592574, 2024

“I jumped in the truck to run an errand, started the engine, rolled down the windows and got a faint whiff of gasoline. Checked the back seat to see if I had thrown rag or something, didn't see anything and started to pull down my driveway (about 250ft - gravel - rural area). The gas smell quickly became very strong. I stopped at the end of the driveway, got out of the truck to inspect what the issue might be. It was RAINING gasoline under my truck. Quickly turned off ignition (which stopped the gas pouring out). Had it towed to the dealer to get it fixed. Diagnosis was that a rodent (sq…”
NHTSA complaint #11478004, 2022

Steering 2

“Presently, my mileage is approximately 42770. It has started to exhibit vibration throughout the cab. It wasn't as prevalent during the cold and would only last about 30 seconds, after warm up, and around 70 mph. Now that it has gotten warmer, it is happening after warm up at all speeds. I haven't take it to the dealership yet, but have read reports of the problem with the same model year.”
NHTSA complaint #11569621, 2024

“I just purchased a vehicle from Autex Mazda of Keene. (1/2/24) A 2020 Ford Ranger with 36K miles and extended warranty. When driving on the highway at 60MPH my steering wheel started shimming very bad as I was passing a school bus that I felt I might of hit because it startled me and never felt a steering wheel shimmy so bad like that. Called dealer and they balanced the tires and leaving to return home the shimmy was back almost out of the lot. Are there any recalls on this issue and my backup camera is barely visible. I feel I was taking advantage of knowing there was a problem with this ve…”
NHTSA complaint #11565694, 2024

Lane Departure 1

“Wiring in components failed resulting in non functioning cross traffic alerts and blind spot detection. Problem found by independent mechanic, ford warranty does not cover.”
NHTSA complaint #11663676, 2024

Seats 1

“Rear seat latch does not work resulting in seat collapsing forward when braking and would also collapse in an accident. Seat belts and child car seat would not be functional. Appears to be a common problem based on our research on the Internet. Salinas Ford dealership rep stated repairs are not covered because it is not a seat belt. This vehicle only has 2,758 miles, even though it is a 2020.”
NHTSA complaint #11573596, 2024