2019 Toyota Tacoma Problems & Owner Complaints

Fuel/Propulsion System 55 2 crash

“Fuel system - vehicle surged (high RPMS) while gearshift lever was in the Drive position after release of pressure on the accelerator as I was parking the vehicle surged and smashed into a cement post, the vehicle traveled approximately 10 to 15 feet. The vehicle is currently at the dealership where an independent contractor, who is contracted by Toyota, will be doing a visual and diagnostic analysis. I expect the vehicle to be returned to me on 1/19/2023. The vehicle and components have not been inspected by any other individual at this time. There were no warning lights on prior to the surge…”
NHTSA complaint #11502194, 2022 · crash

“1. INTERSTATE DRIVING ENGINE SPUTTERED AND SHUT DOWN . 2. REPORTED INCIDENT TO LOCAL TOYOTA SERVICE DEPARTMENT & WAS INFORMED TOYOTA CORPORATE WAS AWARE OF FUEL PUMP DEFECT IN MY VEHICLE VIN-SAFETY ARE ALL AND HAD PROVIDED THE TOYOTA DEALERSHIP NO DIRECTION ON HOW REMEDY . 3. THE TOYOTA PHONE APP DOCUMENTS OWNERS OF DEFECTIVE-VIN FUEL PUMP VEHICLES MAY RECEIVE BY LETTER OR APP SAFETY RECALL REMEDY DIRECTION MARCH 20 , 2020 . 4. FEBRUARY 19, 2020 SLOWING DOWNHILL FOR STOP LIGHT TRAVELING ESTIMATED LESS THAN 20 MPH WITH DRY ROAD CONDITIONS TOYOTA TACOMA 2019-IN VIN SAFETY RECALL ,…”
NHTSA complaint #11315601, 2020 · crash

“low pressure fuel pump in fuel tank failed. This part was already repaired from previous recall and failed again. Error code P0087. Vehicle shuttered and stopped in traffic. Broken bits of fuel pump were left in gas tank.”
NHTSA complaint #11736679, 2026

Service Brakes 52 5 crash 2 injury

“TL* THE CONTACT OWNS A 2019 TOYOTA TACOMA. WHILE ATTEMPTING TO PARK THE VEHICLE, THE BRAKES FAILED. AS A RESULT, THE VEHICLE ACCELERATED FORWARD AND CRASHED INTO A CEMENT WALL. THE CONTACT AND A PASSENGER WERE INJURED AND TRANSPORTED TO A HOSPITAL FOR MEDICAL ATTENTION. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE'S FRONT END WAS SMASHED IN AND THE VEHICLE WAS TOWED FROM THE SCENE. THE CONTACT'S INSURANCE COMPANY HANDLED THE CLAIM AND THE ADJUSTERS PLANNED TO EVALUATE THE VEHICLE. THE DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 2,000.”
NHTSA complaint #11186358, 2019 · crash · 2 injury(ies)

“Approximately 100 feet from the vehicle, I rear end of the car in front of me. when I hit the brake pedal it didn’t seem like it stopped the vehicle I ran into another car and totaled the Toyota Tacoma. Conditions for dry and cloudy and road construction nearby.”
NHTSA complaint #11576735, 2024 · crash

“Brake pedal went to floor as I tried to stop truck from hitting a VW that rear ended a truck in front of them. I can still press brake pedal to floor taking just a few seconds to do so. I have forward this fact to my insurance adjuster, along with the dash camera footage of the accident.”
NHTSA complaint #11440597, 2021 · crash

Power Train 40

“The transmission cooling line in my 2019 Toyota Tacoma was never installed by an authorized repair shop following an accident. This critical component failure led to the transmission failing just 1.5 hours after I retrieved the vehicle from the shop. My safety was compromised, as the failure occurred while driving at highway speeds, without any warning lights or messages indicating an issue. The failure has been confirmed by the dealership (MotorWorld Toyota) currently inspecting my vehicle. The shop responsible for the initial repairs has taken liability for missing the installation of the t…”
NHTSA complaint #11621816, 2024

“the differential skid plate was manufactured in a way that one of the brackets make contact with the fuel tank of the truck. It rubs and compromises the integrity of the tank. Possibly leading to a puncture and leak. I brought it to the attention of the manufacturer, and they have stated that they received several complaints from customers and redesigned the skid plate to prevent this. However they refused to replace mine and others, they also have taken NO steps to notify owners of this safety hazard.”
NHTSA complaint #11617943, 2024

“About 70,000 miles, bearings on the idler pulley and tensioner on serpentine belt failed. These have been replaced. About 75,000 miles, the rack and pinion began leaking from one end. I'm watching power steering fluid levels and expect to replace the rack and pinion soon. Note: I'm being told the design of this vehicle requires that the engine be partially pulled to replace the rack and pinion.”
NHTSA complaint #11557772, 2023

Engine 27 2 crash 1 fire 1 injury

“I was driving my truck a 2019 TRD off road Tacoma from San Diego to LA I was on the 605 freeway in the fast lane when I noticed smoke smell and then I noticed fire flames by the air conditioner and the phone charging plate I proceed to Exit the freeway thankfully I did not get in a car accident with any other vehicles however I was unable to stop and put out the fire. It's very upsetting because at no fault of my own I am now lob obligated to find another vehicle and I am not in the financial or credit position that I was when I bought my truck that is now a total loss by my insurance it cov…”
NHTSA complaint #11419291, 2021 · fire · 1 injury(ies)

“Fuel system - vehicle surged (high RPMS) while gearshift lever was in the Drive position after release of pressure on the accelerator as I was parking the vehicle surged and smashed into a cement post, the vehicle traveled approximately 10 to 15 feet. The vehicle is currently at the dealership where an independent contractor, who is contracted by Toyota, will be doing a visual and diagnostic analysis. I expect the vehicle to be returned to me on 1/19/2023. The vehicle and components have not been inspected by any other individual at this time. There were no warning lights on prior to the surge…”
NHTSA complaint #11502194, 2022 · crash

“I STARTED TO NOTICE WHEN YOU WOULD STOP AT A RED. LIGHT AND APPLY THE BRAKES THE PEDAL WOULD SLOWLY EASE OFF LIKE IT HAD AIR IN THE BRAKE LINE.THIS WENT ON FOR A COUPLE OF MONTHS.I HAD A DOCTORS APPOINTMENT AND WHEN I GOT TO THE OFFICE AND WAS PULLING IN THE PARKING SPACE I PRESSED THE BRAKE AND IT WENT TO THE FLOOR SO I PRESSED THE SECOND TIME AND THE SAME THING I DIDN'T HAVE TIME TO TRY THE THIRD TIME BECAUSE I HIT THE CONCRETE WALL AND DID APPROXIMATELY $5200 DAMAGES TO MY VEHICLE.THE ENGINE HAS A NOISE IN ENGINE COMPARTMENT ON THE PASSENGER SIDE THAT SOUNDS LIKE A LIFTER MAKING A NOISE THA…”
NHTSA complaint #11329562, 2020 · crash

Unknown Or Other 24

“Lower driver door locking bracket corrosion. Beyond surface corrosion. Been monitoring. Passenger side bracket is free of corrosion. Base of corroded bracket has heavy rust. Appears this part was not plated or treated for rustproofing. Appears this locking bracket might fail over time. See attached photos. Passenger side (no corrosion) is last photo.”
NHTSA complaint #11750645, 2026

“On 10/9/25 said vehicle was brought to Central Florida Toyota (CFT) for the investigation of water intrusion into the rear passenger compartment. The cause of water intrusion was due to a defective duct (vent) assy (PN: 62930-04040. There are 2 vents located at the rear of the passenger cab.). The cost for the repair was estimated to be $15,153.39. This exorbitant fee includes the replacement of the entire carpeting system and the need to remove the vehicle bed to access the vents. Based on a musty smell CFT assumed that the carpet had been damaged by molds. Subsequently, CFT was requested to…”
NHTSA complaint #11693447, 2025

“Water leaked through the third brake light assembly into the cab roof, soaking the ceiling, seats, and carpet. This caused extensive mold growth and electrical corrosion near the control modules. The affected systems include the third brake light seal, cab roof, interior materials, and ECM (documentation attached). The truck remains at the dealer and is available for inspection upon request. The entire interior is contaminated with mold, creating a serious health hazard, and the vehicle cannot be safely driven or occupied. The leak also damaged electrical components, posing a risk of malfuncti…”
NHTSA complaint #11691503, 2025

Electrical System 20 1 fire 1 injury

“I was driving my truck a 2019 TRD off road Tacoma from San Diego to LA I was on the 605 freeway in the fast lane when I noticed smoke smell and then I noticed fire flames by the air conditioner and the phone charging plate I proceed to Exit the freeway thankfully I did not get in a car accident with any other vehicles however I was unable to stop and put out the fire. It's very upsetting because at no fault of my own I am now lob obligated to find another vehicle and I am not in the financial or credit position that I was when I bought my truck that is now a total loss by my insurance it cov…”
NHTSA complaint #11419291, 2021 · fire · 1 injury(ies)

“Water leaked through the third brake light assembly into the cab roof, soaking the ceiling, seats, and carpet. This caused extensive mold growth and electrical corrosion near the control modules. The affected systems include the third brake light seal, cab roof, interior materials, and ECM (documentation attached). The truck remains at the dealer and is available for inspection upon request. The entire interior is contaminated with mold, creating a serious health hazard, and the vehicle cannot be safely driven or occupied. The leak also damaged electrical components, posing a risk of malfuncti…”
NHTSA complaint #11691503, 2025

“Truck has 33,XXX miles. Was driving and the fuel gauge needle dropped to E. Dash screen stated 225 miles till empty please refuel. I tried turning it on and off, no change. Filled the gas tank numerous times, no change. Needle remains on E with warning message to please refuel. Mechanic checked and there are no codes or CELs.”
NHTSA complaint #11670295, 2025

Fuel System 20

“the differential skid plate was manufactured in a way that one of the brackets make contact with the fuel tank of the truck. It rubs and compromises the integrity of the tank. Possibly leading to a puncture and leak. I brought it to the attention of the manufacturer, and they have stated that they received several complaints from customers and redesigned the skid plate to prevent this. However they refused to replace mine and others, they also have taken NO steps to notify owners of this safety hazard.”
NHTSA complaint #11617943, 2024

“The contact owns a 2019 Toyota Tacoma. The contact stated that after starting the vehicle, the vehicle was idling abnormally rough. After shifting into driving and releasing the brake pedal with his foot off the accelerator pedal, the vehicle briefly independently accelerated. Upon reaching an undisclosed speed, the vehicle returned to normal functionality, but the failure became a regular occurrence. The contact stated that the failure first occurred after the dealer had replaced the high-pressure fuel pump. No warning lights were illuminated. The vehicle was taken to the dealer, who was unab…”
NHTSA complaint #11560009, 2023

“TL* THE CONTACT OWNS A 2019 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V682000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRM PARTS NOT AVAILABLE.”
NHTSA complaint #11400188, 2021

Vehicle Speed Control 12 1 crash 2 injury

“TL* THE CONTACT OWNS A 2019 TOYOTA TACOMA. WHILE ATTEMPTING TO PARK THE VEHICLE, THE BRAKES FAILED. AS A RESULT, THE VEHICLE ACCELERATED FORWARD AND CRASHED INTO A CEMENT WALL. THE CONTACT AND A PASSENGER WERE INJURED AND TRANSPORTED TO A HOSPITAL FOR MEDICAL ATTENTION. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE'S FRONT END WAS SMASHED IN AND THE VEHICLE WAS TOWED FROM THE SCENE. THE CONTACT'S INSURANCE COMPANY HANDLED THE CLAIM AND THE ADJUSTERS PLANNED TO EVALUATE THE VEHICLE. THE DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 2,000.”
NHTSA complaint #11186358, 2019 · crash · 2 injury(ies)

“The transmission cooling line in my 2019 Toyota Tacoma was never installed by an authorized repair shop following an accident. This critical component failure led to the transmission failing just 1.5 hours after I retrieved the vehicle from the shop. My safety was compromised, as the failure occurred while driving at highway speeds, without any warning lights or messages indicating an issue. The failure has been confirmed by the dealership (MotorWorld Toyota) currently inspecting my vehicle. The shop responsible for the initial repairs has taken liability for missing the installation of the t…”
NHTSA complaint #11621816, 2024

“The contact owns a 2019 Toyota Tacoma. The contact stated that after starting the vehicle, the vehicle was idling abnormally rough. After shifting into driving and releasing the brake pedal with his foot off the accelerator pedal, the vehicle briefly independently accelerated. Upon reaching an undisclosed speed, the vehicle returned to normal functionality, but the failure became a regular occurrence. The contact stated that the failure first occurred after the dealer had replaced the high-pressure fuel pump. No warning lights were illuminated. The vehicle was taken to the dealer, who was unab…”
NHTSA complaint #11560009, 2023

Structure 11 2 crash

“On 2 seperate occassions I had a wheel on my 2019 Toyota Tacoma come off while driving. Both after Toyota signed off on work orders and bill of sales showing they accessed the wheels. On 4/11/26 the front left drivers side fell off. Upon picking it up after repairs on April 28, May 6th the left rear wheel fell off while driving again. My safety could have been fatal but luckily no injuries for me and a passanger occurred. Toyota used a Certified Toyota body shop to do the repairs on the first incident not sure who worked on the 2nd as I have not yet been notified the truck is ready.…”
NHTSA complaint #11737733, 2026 · crash

“I STARTED TO NOTICE WHEN YOU WOULD STOP AT A RED. LIGHT AND APPLY THE BRAKES THE PEDAL WOULD SLOWLY EASE OFF LIKE IT HAD AIR IN THE BRAKE LINE.THIS WENT ON FOR A COUPLE OF MONTHS.I HAD A DOCTORS APPOINTMENT AND WHEN I GOT TO THE OFFICE AND WAS PULLING IN THE PARKING SPACE I PRESSED THE BRAKE AND IT WENT TO THE FLOOR SO I PRESSED THE SECOND TIME AND THE SAME THING I DIDN'T HAVE TIME TO TRY THE THIRD TIME BECAUSE I HIT THE CONCRETE WALL AND DID APPROXIMATELY $5200 DAMAGES TO MY VEHICLE.THE ENGINE HAS A NOISE IN ENGINE COMPARTMENT ON THE PASSENGER SIDE THAT SOUNDS LIKE A LIFTER MAKING A NOISE THA…”
NHTSA complaint #11329562, 2020 · crash

“On 10/9/25 said vehicle was brought to Central Florida Toyota (CFT) for the investigation of water intrusion into the rear passenger compartment. The cause of water intrusion was due to a defective duct (vent) assy (PN: 62930-04040. There are 2 vents located at the rear of the passenger cab.). The cost for the repair was estimated to be $15,153.39. This exorbitant fee includes the replacement of the entire carpeting system and the need to remove the vehicle bed to access the vents. Based on a musty smell CFT assumed that the carpet had been damaged by molds. Subsequently, CFT was requested to…”
NHTSA complaint #11693447, 2025

Steering 10 1 crash

“On 2 seperate occassions I had a wheel on my 2019 Toyota Tacoma come off while driving. Both after Toyota signed off on work orders and bill of sales showing they accessed the wheels. On 4/11/26 the front left drivers side fell off. Upon picking it up after repairs on April 28, May 6th the left rear wheel fell off while driving again. My safety could have been fatal but luckily no injuries for me and a passanger occurred. Toyota used a Certified Toyota body shop to do the repairs on the first incident not sure who worked on the 2nd as I have not yet been notified the truck is ready.…”
NHTSA complaint #11737733, 2026 · crash

“While having routine maintenance performed on 8/5/2025, I was advised that the steering rack must be replaced at an approximate cost of $2,200. I was told this should be done as soon as possible because it poses a safety issue. The vehicle only has 29,000 miles and has not been driven off road or in extreme conditions. I researched the issue and it seems that a number of complaints have been filed for the same concern, specifically because this is happening at such low mileage. If Toyota does not come up with a resolution and recall for faulty equipment, will I be doing this repair again i…”
NHTSA complaint #11687938, 2025

“Steering rack was found to be leaking fluid onto the rubber boot during the 52,000 mile oil change and general maintenance by the Toyota dealership. This leak requires the complete steering rack to be replaced for approximately $2,100.”
NHTSA complaint #11601792, 2024

Forward Collision Avoidance 6 1 crash

“Approximately 100 feet from the vehicle, I rear end of the car in front of me. when I hit the brake pedal it didn’t seem like it stopped the vehicle I ran into another car and totaled the Toyota Tacoma. Conditions for dry and cloudy and road construction nearby.”
NHTSA complaint #11576735, 2024 · crash

“This describes false alarms by the vehicle electronics. About once every four to six months, the center display on the dash says, "BRAKE," and a Sonalert-type steady beep comes out of the dash. This happens with cruise control on. In two cases, there was no vehicle in front of me on the road. I could not see any source of radio signal or radar interference (EMI) in the area or nearby. In one case, there were no vehicles nearby, no weather or other radars nearby, only a television translator station about two miles away. The brakes may have been applied in some cases but generally are not. We…”
NHTSA complaint #11557768, 2023

“I currently own a 2019 Tacoma with around 70,000 miles on it. I keep up with all the Toyota recommended maintenance services to make sure my vehicle is well taken care of. So, while driving the vehicle on the interstate it drastically slowed down on its own and I could not get the gas pedal to engage almost causing a rear end collision. This also happened on two other occasions at lower speeds. My display stated I was having issues with ABS, Collision, and that I was pressing the gas pedal and break at the same time. My vehicle has been at the dealership for 4 days now with no resolve or any a…”
NHTSA complaint #11548974, 2023

Seat Belts 4

“Passenger Side Back Seat Seatbelt ripped under normal wear and tear.”
NHTSA complaint #11506107, 2023

“THE PASSENGER SEATBELT LIGHT KEEPS BLINKING WHEN SEAT BELT IS BUCKLED AND IT SAYS PASSENGER AIRBAG IS OFF WHILE THERE IS SOMEONE IN THERE AND BUCKLED UP. THIS HAPPENS WHEN PARKED OR DRIVING, WE HAVE UNHOOKED THE BATTERY TO TRY TO RESET IT. NO LUCK. I AM AFRAID IF WE WERE TO GET IN AN ACCIDENT THE PASSENGER AIRBAG WOULD NOT DEPLOY.”
NHTSA complaint #11414204, 2021

“THE SEATBELT IN THE DRIVER SEAT IS EXTREMELY HARD TO BUCKLE. I HAVE TO FORCE THE THE SEATBELT INTO THE BUCKLE SEVERAL TIMES BEFORE IT LATCHES. I FEEL LIKE IT'S A FAULTY LATCH AND NEEDS TO BE REPLACED.”
NHTSA complaint #11397338, 2021

Suspension 4

“the left side inner and outer tie rods pulled apart at threads at jam nut. The threads approx 2 to three inches of threads were 100% rotted. The jam nut showed no sign of being loose. It did not UNTHREAD. No noise or any indication ever of an issue. It happened at 5:15 am. It was dark. I was at best going 1 mph in reverse. If this had happened at road speeds the outcome could have been fatal for someone. For sure a lot of damage. I did not take a picture my bad. I did ask for the parts back but am 99%sure the part I got was not mine.it had a weld on it likely to move vehicle. The inner tie ro…”
NHTSA complaint #11733180, 2026

“Rear leaf springs are flat and curving in opposite direction causing vehicle to bottom out with only 100 pounds in the truck bed. This is a potential safety issue as control problems to keep vehicle going straight.”
NHTSA complaint #11671079, 2025

“1. VIBRATION FELT WHEN SLOWING DOWN. USUALLY BETWEEN 50 AND 20. BELOW 20 IT GOES AWAY. FEELS LIKE THE TIRES ARE OUT OF BALANCE BUT MY TRUCK HAS 8K MILES ON IT AND I HAVE FELT IT SINCE THE DAY I BOUGHT IT. 2. ALSO WHEN THE TRANSMISSION IS OUT OF GEAR AND CLUTCH IS OUT OR THE REAR END MAKES A SQUEAKING NOISE WHEN HITTING BUMPS. 3. CLUTCH MAKES A NOISE WHEN RELEASING IT. 4. HIGH PITCH HUM IN 3RD, 4TH, 5TH AND 6TH WHEN MAINTAINING CONSISTENT SPEED. TOOK IT TO THE DEALER, THE DEALER WAS ABLE TO REPLICATE THE ISSUES WITH COMPARABLE TRUCK ON THEIR LOT AND BRUSHED IT OFF AS NORM…”
NHTSA complaint #11297191, 2019

Air Bags 3 2 crash 2 injury

“The contact owned a 2019 Toyota Tacoma. The contact stated while driving at 60MPH; that he was cut off while on a turnpike and to avoid a collision the contact turned into and went over a guard rail, crashing into an embankment. The side curtain air bags deployed however, the front driver-side air bag did not deploy. The vehicle was deemed a total loss. A police report was filed however was not available. The contact did not seek medical attention however felt sore within the next few days. Personal items for his vision were destroyed during the accident. The local dealer was not contacted. Th…”
NHTSA complaint #11642741, 2025 · crash · 1 injury(ies)

“TL* THE CONTACT OWNED A 2019 TOYOTA TACOMA. THE CONTACT STATED WHILE HER SON WAS STOPPED IN TRAFFIC, HE WAS REAR ENDED BY ANOTHER VEHICLE WHICH CAUSED HIM TO MOVE FORWARD CRASHING INTO ANOTHER VEHICLE. THE CONTACTED STATED THAT THE CRASH AVOIDANCE SENSORS WERE ACTIVATED PRIOR TO THE COLLISION. THE CONTACT STATED THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED BACK INJURIES AND WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL. THE CONTACT WAS UNAWARE OF INJURIES TO THE OTHER VEHICLE OCCUPANTS. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN IMPOUND LOT AND DEEMED A TOTAL LOSS. THE CONTACT…”
NHTSA complaint #11246387, 2019 · crash · 1 injury(ies)

“THE PASSENGER SEATBELT LIGHT KEEPS BLINKING WHEN SEAT BELT IS BUCKLED AND IT SAYS PASSENGER AIRBAG IS OFF WHILE THERE IS SOMEONE IN THERE AND BUCKLED UP. THIS HAPPENS WHEN PARKED OR DRIVING, WE HAVE UNHOOKED THE BATTERY TO TRY TO RESET IT. NO LUCK. I AM AFRAID IF WE WERE TO GET IN AN ACCIDENT THE PASSENGER AIRBAG WOULD NOT DEPLOY.”
NHTSA complaint #11414204, 2021

Tires 2

“A severe crack formed around the full circumference of tire near where the sidewall joins to the tread. The tire started leaking air and the severe crack was found while mounting the spare tire. The crack was present on the inside of the tire and therefore not visible until the wheel was removed. This crack was on its way to a catastrophic failure of the tire. The crack was found at 23500 miles on a tire with claimed treadlife of 60,000. This was the tire sold with my new 2019 Tacoma: Goodyear Wrangler AT Adventure with Kevlar 265/70R16. The Toyota dealership said to take the problem to GY but…”
NHTSA complaint #11524504, 2023

“I have 4 Toyo Open Range A31, P25 45 R16 Tires on my 2019 Toyota Tacoma. They were new tires on the 2019 Tacoma when I purchased it new from the Toyota Dealership in August 2019. 4 tires on the Tacoma and 1 Spare tire. I noticed over he life of these 4 Toyo tires they wore rapidly and chunked and lost chunks of rubber in the tread areas. I always rotated and balanced my Toyo tires as required. I had yearly front end alignments done . 2020 and 2021. I do an air check every 30 days. There are no mechanical problems with my 2019 Toyota Tacoma. When these Toyo Open Range A31 Tires were ne…”
NHTSA complaint #11438541, 2021

Visibility/Wiper 2

“The rear cabin pressure vent leaks water into the cabin creating an unsafe vehicle to drive during rainy days. I took the vehicle to Sarasota Toyota and was told that my claim to get it fixed thru the Toyota warranty was denied because it is considered trim. I contacted the warranty company and Toyota about this issue but was told the same.NOT COVERED. I am also concerned that the water intrusion can affect the safety and health hazard of more drivers with this problem if not addressed by Toyota as soon as possible.”
NHTSA complaint #11689472, 2025

“I’m filing this complaint regarding a known issue with the A/C evaporator core on my Toyota Tacoma (3rd generation). The evaporator core has prematurely failed, leading to a complete loss of air conditioning and, more importantly, reduced defrosting and defogging capabilities that directly affect visibility and driver safety. This issue is widespread and well-documented among Tacoma owners, and Toyota has issued TSB T-SB-0145-20, acknowledging that corrosion in the evaporator core leads to refrigerant leakage. Despite the known defect, Toyota has not issued a recall and is charging owners tho…”
NHTSA complaint #11668776, 2025

Wheels 2 1 crash

“On 2 seperate occassions I had a wheel on my 2019 Toyota Tacoma come off while driving. Both after Toyota signed off on work orders and bill of sales showing they accessed the wheels. On 4/11/26 the front left drivers side fell off. Upon picking it up after repairs on April 28, May 6th the left rear wheel fell off while driving again. My safety could have been fatal but luckily no injuries for me and a passanger occurred. Toyota used a Certified Toyota body shop to do the repairs on the first incident not sure who worked on the 2nd as I have not yet been notified the truck is ready.…”
NHTSA complaint #11737733, 2026 · crash

“FROM DAY ONE THE TACOMA VIBRATES AND SHUTTERS WHEN BREAKING. THE DEALERSHIP SAID THAT TOYOTA WOULD NOT LOOK AT IT UNTIL I DROVE 1,500 MILES FIRST. THE FIRST TIME I BROUGHT IN TO THE DEALERSHIP THEY SAID THEY COULD NOT FIND ANYTHING WRONG AND IT WAS OK. THE SECOND TIME I BROUGHT IT TO THE DEALERSHIP THEY SAID THEY HAD TO SHAVE THE FRONT ROTORS AND SAND THE BRAKE PADS. THE THIRD TIME I BROUGHT IT TO THE DEALERSHIP THEY SAID IT HAD DEFECTIVE REAR BENT AXLES AND THEY HAD TO REPLACE THOSE COMPONENTS. I UNDERSTAND TOYOTA HAS BEEN AWARE OF THESE ISSUES FOR SEVERAL YEARS.”
NHTSA complaint #11208205, 2019

Equipment 1

“BLUETOOTH HANDSFREE DOESN'T WORK WITH TRUCK AND IPHONE. TALKING TO TACOMA, THEY SAID THAT THEIR SYSTEM CANT KEEP UP WITH APPLY AND THEIR TECHNOLOGY. THIS DOESN'T WORK FOR BEING HANDSFREE ON THE ROAD WHICH IS WHAT TOYOTA ADVERTISES AND IS THE LAW. *TR”
NHTSA complaint #11330150, 2020

Exterior Lighting 1

“EXTERIOR HEADLIGHTS ARE INADEQUATE AS THE ILLUMINATION IS INADEQUATE AND DOESN'T MEET MINIMUM SAFETY STANDARDS FOR A VEHICLE ON COUNTRY ROADS. THE INTERIOR SWITCHES ARE NOT ILLUMINATED AND DURING EVENING OPERATION MAKING SAFE ADJUSTMENTS AN IMPOSSIBILITY. AUTO-DIM OVERRIDES NORMAL SAFE HIGH BEAM OPERATION AS SENSOR IS ACTIVATED FROM ANY ROADSIDE REFLECTIVE SURFACE WHILE VEHICLE IS IN MOTION. THE PROBLEM ALMOST MANIFESTED IN SEVERAL NEAR ACCIDENTS. THIS IS A MAJOR LATENT DESIGN AND EQUIPMENT DEFECT AND IS UNSAFE IN NIGHTTIME OPERATION. *JS THE CONSUMER STATED THAT ON THE COMPUTER SCREEN THE L…”
NHTSA complaint #11288430, 2019

Interior Lighting 1

“EXTERIOR HEADLIGHTS ARE INADEQUATE AS THE ILLUMINATION IS INADEQUATE AND DOESN'T MEET MINIMUM SAFETY STANDARDS FOR A VEHICLE ON COUNTRY ROADS. THE INTERIOR SWITCHES ARE NOT ILLUMINATED AND DURING EVENING OPERATION MAKING SAFE ADJUSTMENTS AN IMPOSSIBILITY. AUTO-DIM OVERRIDES NORMAL SAFE HIGH BEAM OPERATION AS SENSOR IS ACTIVATED FROM ANY ROADSIDE REFLECTIVE SURFACE WHILE VEHICLE IS IN MOTION. THE PROBLEM ALMOST MANIFESTED IN SEVERAL NEAR ACCIDENTS. THIS IS A MAJOR LATENT DESIGN AND EQUIPMENT DEFECT AND IS UNSAFE IN NIGHTTIME OPERATION. *JS THE CONSUMER STATED THAT ON THE COMPUTER SCREEN THE L…”
NHTSA complaint #11288430, 2019

Lane Departure 1

“This describes false alarms by the vehicle electronics. About once every four to six months, the center display on the dash says, "BRAKE," and a Sonalert-type steady beep comes out of the dash. This happens with cruise control on. In two cases, there was no vehicle in front of me on the road. I could not see any source of radio signal or radar interference (EMI) in the area or nearby. In one case, there were no vehicles nearby, no weather or other radars nearby, only a television translator station about two miles away. The brakes may have been applied in some cases but generally are not. We…”
NHTSA complaint #11557768, 2023

Seats 1

“DUE TO THE FACT THAT WE NEVER TEST DROVE THE 2019 TOYOTA TACOMA THAT WE WERE GIVEN TO PURCHASE, AND MY HUSBAND DROVE THE VEHICLE HOME I DID NOT HAVE THE CHANCE TO TRY THE VEHICLE UNTIL WE ARRIVED HOME. THE FIRST TIME THAT I SAT IN THE VEHICLE, I FELT EXTREME DISCOMFORT AND ELECTRIC SHOCKS FROM THE VEHICLE, VERY SIMILAR TO THE ELECTRIC SHOCKS THAT I RECEIVED FROM THE 2017 TOYOTA PRIUS. MY HUSBAND THOUGHT THAT IT WAS CAUSED FROM MY HEALTH CONDITION FROM MY CAR ACCIDENT AND HE AGREED THAT, SINCE I DID NOT FEEL ANY DISCOMFORT DRIVING THE SIENNA, HE WOULD BE THE ONLY THAT WOULD DRIVE THE TACOMA A…”
NHTSA complaint #11319902, 2020