2019 Kia Sportage Problems & Owner Complaints

Engine 35 3 fire

“The contact owned a 2019 Kia Sportage. The contact stated while driving 40 MPH, the vehicle started overheating and smoke started emitting smoke from the hood. No warning lights were illuminated. No injuries were reported. The vehicle was destroyed leaving only the framing. The fire department arrived on the scene and extinguished the fire. A fire department report was filed. A police report was not filed. The manufacturer was notified of the failure and the vehicle was inspected; however, the inspector did not find a defect in the vehicle. The vehicle was also inspected by the fire department…”
NHTSA complaint #11617339, 2024 · fire

“the continued to over heat smoke and has burning smell and seat belt stop tracting and retracting”
NHTSA complaint #11536626, 2022 · fire

“MY KIA SPORTAGE 2019 CAUGHT FIRE ON THE HIGHWAY IN NEW MARKET MD AT AROUND 10:30 AM 9/26/19. WE HAD PREVIOUSLY TAKEN THE CAR TO THE DEALERSHIP WHERE WE PURCHASED IT BACK IN 12/2019. IT HAD ONLY 3900+/- MILES ON IT. THE OIL, FILTER, TIRE ROTATION AND 27 POINT INSPECTION WAS DONE ON 9/19/19. AS I WAS IN THE LEFT LANE OF RTE 70 WB I NOTICED BLUE SMOKE COMING FROM THE BACK OF THE CAR. I PUT ON MY FLASHERS AND SIGNALED OVER TO THE RIGHT SHOULDER. I CALLED MY HUSBAND AND WAS QUITE HYSTERICAL BECAUSE NOW THE FRONT OF THE CAR WAS SMOKING A BROWNISH-BLACK. IT QUICKLY STARTED COMING IN THEY THE VENT…”
NHTSA complaint #11265476, 2019 · fire

Unknown Or Other 14

“Vehicle suddenly entered recall limp-mode due to the ongoing engine campaign. Prior to this, the vehicle had immaculate maintenance records and zero driveability issues. The franchise dealership performed a short-block engine replacement under the safety recall, rushing the complete powertrain swap in less than a single afternoon.The dealership subsequently returned the vehicle in a dangerously malfunctioning and incomplete repair state. At delivery, the Check Engine Light was actively illuminated, and the car exhibited severe acceleration stumbles, power loss under load, and engine misfires (…”
NHTSA complaint #11748827, 2026

“WHEN I PUSH ON THE GAS PEDAL SOME TIMES I GET NOTHING FOR A SHORT TIME WHEN STARTING FROM A STOP”
NHTSA complaint #11722182, 2026

“I have a 2019 Kia Sportage with 41k miles on it and the paint is peeling. As of now, the roof spoiler is completely peeled off. The side view mirrors, and the door handles, have paint peeling and bubbling. I have reported it to Kia and they are unwilling to stand by their product and extend the warranty on the paint. Kia is fully aware of the problem but is not willing to fix it.”
NHTSA complaint #11711162, 2025

Electrical System 10 1 crash 2 fire

“The contact owned a 2019 Kia Sportage. The contact stated while driving 40 MPH, the vehicle started overheating and smoke started emitting smoke from the hood. No warning lights were illuminated. No injuries were reported. The vehicle was destroyed leaving only the framing. The fire department arrived on the scene and extinguished the fire. A fire department report was filed. A police report was not filed. The manufacturer was notified of the failure and the vehicle was inspected; however, the inspector did not find a defect in the vehicle. The vehicle was also inspected by the fire department…”
NHTSA complaint #11617339, 2024 · fire

“MY KIA SPORTAGE 2019 CAUGHT FIRE ON THE HIGHWAY IN NEW MARKET MD AT AROUND 10:30 AM 9/26/19. WE HAD PREVIOUSLY TAKEN THE CAR TO THE DEALERSHIP WHERE WE PURCHASED IT BACK IN 12/2019. IT HAD ONLY 3900+/- MILES ON IT. THE OIL, FILTER, TIRE ROTATION AND 27 POINT INSPECTION WAS DONE ON 9/19/19. AS I WAS IN THE LEFT LANE OF RTE 70 WB I NOTICED BLUE SMOKE COMING FROM THE BACK OF THE CAR. I PUT ON MY FLASHERS AND SIGNALED OVER TO THE RIGHT SHOULDER. I CALLED MY HUSBAND AND WAS QUITE HYSTERICAL BECAUSE NOW THE FRONT OF THE CAR WAS SMOKING A BROWNISH-BLACK. IT QUICKLY STARTED COMING IN THEY THE VENT…”
NHTSA complaint #11265476, 2019 · fire

“I WAS RECENTLY INVOLVED IN A COLLISION WITH A DEER. I WAS TRAVELLING AT 55MPH WHEN I HIT THE DEER SQUARE ON AND MY AIR BAGS DID NOT DEPLOY. ALSO EVERY TIME I WASH MY CAR SOME OF THE ELECTRICAL COMPONENTS STOP WORKING FOR A FEW DAYS SUCH AS THE CLOCK. I HAVE TALKED TO KIA DEALERSHIP NEAR ME AND THEY CAN NOT EXPLAIN THE ISSUE OVER THE ELECTRICAL STUFF. ALSO THEY STATED I COULD START A CASE WITH THEM OVER THE AIRBAGS”
NHTSA complaint #11230258, 2019 · crash

Fuel/Propulsion System 7 1 fire

“MY KIA SPORTAGE 2019 CAUGHT FIRE ON THE HIGHWAY IN NEW MARKET MD AT AROUND 10:30 AM 9/26/19. WE HAD PREVIOUSLY TAKEN THE CAR TO THE DEALERSHIP WHERE WE PURCHASED IT BACK IN 12/2019. IT HAD ONLY 3900+/- MILES ON IT. THE OIL, FILTER, TIRE ROTATION AND 27 POINT INSPECTION WAS DONE ON 9/19/19. AS I WAS IN THE LEFT LANE OF RTE 70 WB I NOTICED BLUE SMOKE COMING FROM THE BACK OF THE CAR. I PUT ON MY FLASHERS AND SIGNALED OVER TO THE RIGHT SHOULDER. I CALLED MY HUSBAND AND WAS QUITE HYSTERICAL BECAUSE NOW THE FRONT OF THE CAR WAS SMOKING A BROWNISH-BLACK. IT QUICKLY STARTED COMING IN THEY THE VENT…”
NHTSA complaint #11265476, 2019 · fire

“The vehicle is experiencing excessive engine oil consumption. The engine was found by the dealership to be low by 3 quarts of oil after about 1000 miles during an oil consumption test, indicating abnormal oil loss. The suspected failure involves internal engine components, possibly piston rings, allowing oil to enter the combustion chamber and burn. This condition creates a safety risk because the engine can become critically low on oil, without warning, potentially leading to engine damage, loss of power, or engine failure while driving. The problem has been reproduced and documented by the d…”
NHTSA complaint #11726557, 2025

“The brake peddle keeps jamming and sticking . The steering wheel is now very lose and a lot of play . There is a steering wheel with exclamation point flashing on the dash . When the card turns off it makes electrical noises . It is consuming oil . A pint a week . It’s been towed twice in three weeks”
NHTSA complaint #11699997, 2025

Power Train 7 1 fire

“the continued to over heat smoke and has burning smell and seat belt stop tracting and retracting”
NHTSA complaint #11536626, 2022 · fire

“I did not have an incident yet. I was advised by my local State representative Jimmy Gordon's office. They stated were unable to help me get reimbursement for the $8000 I just paid my Kia dealer, but that I should make a complaint on this website. What happened is that I was hearing an odd noise and it was slipping. I went in thinking it was my tires and it needed alignment- so I had them replaced , etc in April. But the sound was still there so I went back in . Then the Kia St Cloud dealer diagnosed that the AWD transfer case was the cause (pd $4704 including $130 surcharge! ). When dealer c…”
NHTSA complaint #11743447, 2026

“This complaint is in reference to my vehicle which is involved with Federal Class Action Lawsuits and the fact that my engine was defective from the day it was built. My engine was consuming oil at a rate of 1 quart every 361.1 miles driven. I was advised to not put oil in it and drive it until it blows up. This would have put myself, my family, friends, or any other passengers or bystanders at risk. Kia is denying my claim solely on a non rod bearing failure.”
NHTSA complaint #11709880, 2025

Service Brakes 7 2 crash 2 injury

“[XXX], I was driving alone on [XXX] in McAllen, TX. & intersection of [XXX] St. Weather was sunny, hot, and dry. My car was 1st in middle lane, speed about 20 mph. I applied the brakes for a red traffic light. Instantly, the brakes locked and 3 air bags deployed -driver and passenger side + passenger side windows. The windshield was blocked but it seemed like the car swerved slowly, about 10-15 mph, to the right. My car sideswiped the Chevy Equinox stopped at red light in right lane. The car behind me, Toyota Corolla, hit my rear end. I didn't hear or feel either of these crashes. McAll…”
NHTSA complaint #11533483, 2023 · crash · 2 injury(ies)

“TL* THE CONTACT OWNED A 2019 KIA SPORTAGE. WHILE REVERSING THE VEHICLE OUT OF A SCHOOL PARKING LOT, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. AS A RESULT, THE VEHICLE CRASHED INTO THE SIDE OF THE SCHOOL BUILDING. THE AIRS BAGS DEPLOYED. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT AND DEEMED A TOTAL LOSS BY THE INSURANCE COMPANY. THE DEALER (FUCCILLO KIA, 3900 STATE ST, SCHENECTADY, NY 12304, (518)-847-0800) WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCULED IN ANY RECALLS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE…”
NHTSA complaint #11140692, 2018 · crash

“The contact owns a 2019 Kia Sportage. The contact received notifications of NHTSA Campaign Numbers: 22V703000 (Trail Hitches) and 21V137000 (Service Brakes, Hydraulic); however, the recall repair requests were denied by the manufacturer. The contact stated that while attempting to start the vehicle, it failed to start as intended. No warning light was illuminated. In addition, the contact stated that while her brother was driving at an undisclosed speed, there was an abnormal sound coming from under the hood. After restarting the vehicle, there was a burning odor coming from under the hood. Th…”
NHTSA complaint #11714237, 2025

Air Bags 3 2 crash 4 injury

“[XXX], I was driving alone on [XXX] in McAllen, TX. & intersection of [XXX] St. Weather was sunny, hot, and dry. My car was 1st in middle lane, speed about 20 mph. I applied the brakes for a red traffic light. Instantly, the brakes locked and 3 air bags deployed -driver and passenger side + passenger side windows. The windshield was blocked but it seemed like the car swerved slowly, about 10-15 mph, to the right. My car sideswiped the Chevy Equinox stopped at red light in right lane. The car behind me, Toyota Corolla, hit my rear end. I didn't hear or feel either of these crashes. McAll…”
NHTSA complaint #11533483, 2023 · crash · 2 injury(ies)

“The tire suddenly exploded and the curtain air bag on the drivers side exploded too for some reason. I have a huge black eye and a concussion.”
NHTSA complaint #11508465, 2023 · 2 injury(ies)

“I WAS RECENTLY INVOLVED IN A COLLISION WITH A DEER. I WAS TRAVELLING AT 55MPH WHEN I HIT THE DEER SQUARE ON AND MY AIR BAGS DID NOT DEPLOY. ALSO EVERY TIME I WASH MY CAR SOME OF THE ELECTRICAL COMPONENTS STOP WORKING FOR A FEW DAYS SUCH AS THE CLOCK. I HAVE TALKED TO KIA DEALERSHIP NEAR ME AND THEY CAN NOT EXPLAIN THE ISSUE OVER THE ELECTRICAL STUFF. ALSO THEY STATED I COULD START A CASE WITH THEM OVER THE AIRBAGS”
NHTSA complaint #11230258, 2019 · crash

Exterior Lighting 3

“The contact owns a 2019 Kia Sportage. The contact stated that the high beam headlights failed to illuminate as designed. The contact researched and learned of an undisclosed Technical Service Bulletin concerning the failure with the halogen bulbs on the 2020 Kia Telluride. The vehicle was taken to the dealer but was not diagnosed. The dealer confirmed that the VIN was not under recall or covered under warranty. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 65,000.”
NHTSA complaint #11686416, 2025

“DRIVING HOME NIGHT 9/4/19, NOTICED HEADLIGHTS HAVE PARTIAL OBSTRUCTION WITH SHADOW ON HORIZON MAKING IT DIFFICULT TO RECOGNIZE ANY OBJECTS IN THE SHADOW AREA. IF YOU TURN THE CAR OR TAKE A BEND IN THE ROAD OR DRIVE DOWN OR UP HILL THE DISTRACTION BECOMES A VERY BAD PROBLEM AS THE SHADOW CHANGES IN SIZE OR MOVES...MOSTLY ON LOW BEAMS BUT IS ALSO ON HIGH BEAMS BUT NOT AS NOTICEABLE....LIVE AND DRIVE IN THE NE GEORGIA MOUNTAINS, HAZARD IN DAYTIME AND MORE AT NIGHT..CALLED KIA NEXT AM, CAR SEEN DEALERSHIP 9/9/2019..ADJUSTED HEADLIGHTS...9/13/2019 DROVE NIGHT AGAIN, NO CHANGE...CALLED DEALERSHIP A…”
NHTSA complaint #11257846, 2019

“REAR TURN SIGNALS OF THE VEHICLE ARE BELOW THE LOWEST POINT OF THE LIFT GATE, ARE MOUNTED INSIDE THE BUMPER, AND ARE RECESSED IN THE BUMPER. WHEN TURN SIGNALS ARE USED, ONLY THE TURN BLINKERS IN THE BUMPER BLINK WHILE THE TRADITIONAL REAR BRAKE LAMPS ARE SOLID AND DO NOT INDICATE A TURN. THE TURN SIGNALS ARE TOO LOW FOR FOLLOWING VEHICLES TO SEE AND BECAUSE THEY ARE RECESSED, THE HOUSING GETS PACKED WITH SNOW, SLUSH AND DIRT, MAKING THE ACTIVATED SIGNALS INDISTINGUISHABLE. ALL 2019 KIA SPORTAGES HAVE THIS POORLY ENGINEERED FEATURE, WHICH MAY BE AS OUTSIDE COMPLIANCE AS AN EARLY 70S MALIBU, AND…”
NHTSA complaint #11185704, 2019

Trailer Hitches 3

“The contact owns a 2019 Kia Sportage. The contact received notifications of NHTSA Campaign Numbers: 22V703000 (Trail Hitches) and 21V137000 (Service Brakes, Hydraulic); however, the recall repair requests were denied by the manufacturer. The contact stated that while attempting to start the vehicle, it failed to start as intended. No warning light was illuminated. In addition, the contact stated that while her brother was driving at an undisclosed speed, there was an abnormal sound coming from under the hood. After restarting the vehicle, there was a burning odor coming from under the hood. Th…”
NHTSA complaint #11714237, 2025

“The contact owns a 2019 Kia Sportage. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.”
NHTSA complaint #11522526, 2023

“The contact owns a 2019 Kia Sportage. The contact stated that while driving at an undisclosed speed, she heard an unusual ticking sound coming from the engine. The vehicle was taken to the dealer where it was diagnosed with tow hitch wiring harness deficiency. The contact was informed that the tow hitch wiring harness needed to be replaced. The vehicle was not repaired. The contact had received an interim recall notification in November 2022. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches) in July 2023. The contact stated that the vehicle was stolen in A…”
NHTSA complaint #11542854, 2022

Engine And Engine Cooling 2

“The contact owns a 2019 Kia Sportage. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle went to LIMP Mode. The vehicle was towed to the dealer, who performed an oil change and updated the Knock Sensor Detection System(KSDS). The contact stated that later, while driving, the engine oil warning light illuminated. The contact checked the engine oil and discovered that the oil level was extremely low. The dealer was made aware of the failure and informed the contact that the pistons were faulty, and the engine needed to be re…”
NHTSA complaint #11683614, 2025

“The contact owns a 2019 Kia Sportage. The contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that the vehicle required 6 quarts of oil every 1,900 miles. The vehicle was recently taken to Valvoline, where an oil change was performed. The contact stated that while driving 60 MPH the following day, the vehicle started shuddering and misfiring, and the failure increased significantly while idling. The check engine warning light was illuminated. The contact stated that the failure persisted while driving at 60-65 MPH on the same day, and the engine stall…”
NHTSA complaint #11707973, 2024

Forward Collision Avoidance 2

“My cruise control works some times and then it doesn't. I was driving 80 mph with my cruise control on and couldn't shut it off. Finally stepping on the brake door work to shut it off. I can't see the mileage driven more than half the time, as well.”
NHTSA complaint #11538074, 2023

“When cruise control is in place and you brake for traffic, to resume cruise speed if you hold the resume button for more than standard the car resets speed to 20MPH and you have no control on gas pedal. The only fix is to turn off the card and restart. We are glad to have it inspected. This item has put our lives in danger about five times as we were using cruise on the highway traveling 65 plus mph and cars were coming upon us. We reported the issue back in March 2021 and several more times back into a KIA dealership. It took months but they duplicated the problem on our vehicle a…”
NHTSA complaint #11457313, 2021

Steering 2

“The brake peddle keeps jamming and sticking . The steering wheel is now very lose and a lot of play . There is a steering wheel with exclamation point flashing on the dash . When the card turns off it makes electrical noises . It is consuming oil . A pint a week . It’s been towed twice in three weeks”
NHTSA complaint #11699997, 2025

“The contact owns a 2019 Kia Sportage. The contact stated while driving 45 MPH, the electrical and mechanical systems became inoperable. The headlights, signal, and hazard lights became inoperable. The contact pulled over, placed the vehicle in park, and turned the vehicle off. After restarting the vehicle, an abnormal ticking sound was coming from the vehicle. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the radiator needed to be replaced and the tie rod had excessive play. The dealer denied repairing the vehicle due to sludge…”
NHTSA complaint #11583756, 2024

Structure 2

“CLEAR COAT PAINT IS PEELING. ON TOP OF HATCHBACK. I DON'T KNOW WHEN IT STARTED, I JUST NOTICED IT TODAY 9-29-25. iT IS AVAILABLE FOR INSPECTION UPON REQUEST. NO WARNING MESSAGE PRIOR TO THE PROBLEM. I WENT TO DEALER AND THEY SAID THE PAINT WARRANTY EXPIRED IN 1922 AND THERE ARE NO RECALLS AND NOT EXTENDED WARRANTIES FOR THIS AND KIA HAS NO RESPONSIBILITY THAT'S WHY THEY ONLY GIVE A 3 YEAR, 36,000 MILE WARRANTY ON PAINT.”
NHTSA complaint #11690286, 2025

“Paint is bubbling, chipping and peeling in mirrors, door handles and rear spoiler”
NHTSA complaint #11492723, 2022

Vehicle Speed Control 2

“My cruise control works some times and then it doesn't. I was driving 80 mph with my cruise control on and couldn't shut it off. Finally stepping on the brake door work to shut it off. I can't see the mileage driven more than half the time, as well.”
NHTSA complaint #11538074, 2023

“TL* THE CONTACT OWNS A 2019 KIA SPORTAGE. WHILE AT A STOP/STOP SIGN ON SEVERAL OCCASIONS, THE VEHICLE SPUTTERED. THE ACCELERATOR PEDAL WAS DEPRESSED IN THE ATTEMPT TO REGAIN SPEED BUT FAILED TO RESPOND. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO STEVENSON KIA OF JACKSONVILLE (500 W FAIRWAY RD, JACKSONVILLE, NC 28546 ( 910) 938-0555) BUT, WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND A CASE WAS FILED. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 2,000.”
NHTSA complaint #11299809, 2019

Seat Belts 1 1 fire

“the continued to over heat smoke and has burning smell and seat belt stop tracting and retracting”
NHTSA complaint #11536626, 2022 · fire

Tires 1

“I KEEP GETTING LOW AIR NOTIFICATIONS ON MY CAR. I TOOK IT IN ONCE AND THEY FOUND NOTHING WRONG WITH MY TIRES AND SENT ME ON MY WAY. WELL IT'S BACK AGAIN SO I'M TAKING MY CAR IN AGAIN. THIS IS A REAL PAIN BECAUSE I WORK 2 JOBS, 12 HOURS DAYS, NIGHT SHIFTS ETC. I DON'T HAVE TIME FOR THIS! ALSO MY BLUETOOTH SKIPS AND PAUSES A LOT SO I ALWAYS HAVE TO PLUG IN MY PHONE TO USE IT.”
NHTSA complaint #11279447, 2019

Wheels 1 2 injury

“The tire suddenly exploded and the curtain air bag on the drivers side exploded too for some reason. I have a huge black eye and a concussion.”
NHTSA complaint #11508465, 2023 · 2 injury(ies)