2018 Mazda CX-5 Problems & Owner Complaints

Engine 94

“The contact owns a 2018 Mazda CX-5. The contact stated that white smoke was coming from the engine compartment whenever the vehicle reached normal operating temperature. The contact stated that smoke entered the passenger’s side compartment through the air vents and was coming from underneath the hood. The contact stated that there was a burning odor coming from the engine compartment due to an oil leakage. The smoke impaired visibility while driving. The most recent failure had occurred while driving approximately 35 MPH on a city roadway. The vehicle was driven to an independent mechanic to…”
NHTSA complaint #11747961, 2026

“I am submitting this complaint regarding a cylinder head failure on my Mazda CX-5. The vehicle has approximately 53,000 miles and has been properly maintained throughout its service life. The vehicle developed a crack in the cylinder head, which was subsequently confirmed by an authorized Mazda dealership. Mazda has previously issued a Technical Service Bulletin (TSB) addressing cylinder head cracking on certain vehicles; however, my vehicle's VIN is not included in the covered range despite experiencing the same failure described in the TSB. The dealership initially provided a repair estima…”
NHTSA complaint #11744861, 2026

“Like many other complaints. My 2018 Mazda cx5 GT is having the same issue with the cracked cylinder head. I only have about 36-38k mileage on it ( I forgot the exact). Mazda dealership will not cover the cost. NEVER had an accident to the front and only one accident to the back when I got rear ended in 2019. If this is a wide spread issue, why is this not a recall? and why is it only the turbo engine gets extended warranty? The repair cost right now approximately $9,500. I never do any maintenance at Mazda so I doubt they will give me the good will assistance but I am still waiting for an answ…”
NHTSA complaint #11738405, 2026

Power Train 17

“My Mazda 2018, CX-5, Grand Touring, was diagnosed with a cracked cylinder head at 64,599 miles. This issue could posed a safety hazard for not only us but others on the road by: *Engine Failure / Sudden Loss of Power-A crack allows coolant and oil to mix or leak, leading to overheating and potential catastrophic engine seizure. A seized engine can cause sudden, unexpected loss of power — especially dangerous at highway speeds or during lane changes/merges. *Oil and Coolant on the Road-Leaking fluids drip onto the roadway, creating slick surfaces for motorcyclists and other vehicles — simila…”
NHTSA complaint #11747660, 2026

“Cylinder head suddenly cracked, causing heavy oil leakage onto hot exhaust manifold. Car started to smoke heavily. Vehicle turned off before potential engine fire.”
NHTSA complaint #11744932, 2026

“2018 Mazda CX-5 AWD with 2.5 L engine, non turbo. Car has 98,914 miles. Rear differential started leaking oil. Dealer stated that the differential needs to be replaced, for $5,003.33. Manual does not provide for oil change intervals. Lifetime oil. 98K must be the life expectancy. Has not been fixed yet. Sitting in the garage dripping oil onto a piece of cardboard. independent shop looking for a low mileage used differential.”
NHTSA complaint #11742164, 2026

Unknown Or Other 9 1 crash 1 injury

“Defect front doors the opening handle has a( trim metal plastic) section separates and the metal part is very sharp and my wife got hurt with the metal portion like I said it's very sharp. I need to cover the handle to prevent that. Now it's in the passenger side too.”
NHTSA complaint #11733874, 2026 · 1 injury(ies)

“Unintended acceleration incident. I entered the parking lot of a business where the Salvation Army is located to drop off a donation. The parking spaces were on the left side. As I pulled into a parking space and was in the process of parking, the vehicle suddenly lurched/accelerated forward unexpectedly and struck the concrete wall of the building. The airbags did not deploy despite the frontal impact. No one was seriously injured, but my husband, daughter, and I experienced soreness the following day from the impact. Thankfully, I had chosen a parking space in front of a concrete wall rathe…”
NHTSA complaint #11737223, 2026 · crash

“Sunroof blew out while driving down interstate highway. There was no impact that we are aware of, just a complete failure of the sunroof glass. The sunroof was closed, with the shade also closed, so no glass fell down into the vehicle. The glass blew out with a very loud explosion that startled and disoriented all within the vehicle causing us to swerve and look around for what had happened. The glass has been inspected and is being repaired by a local auto glass shop today. No warning lamps or otherwise. I have pictures of the glass if needed.”
NHTSA complaint #11737283, 2026

Engine And Engine Cooling 3

“The contact owns a 2018 Mazda CX-5. The contact stated that while his wife was driving at an undisclosed speed, there was smoke coming from under the hood. No warning light was illuminated. The contact's wife pulled over and discovered that there was oil leaking onto the ground. The vehicle was towed to the dealer, who determined that the #5 and #7 cylinder heads were cracked and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.”
NHTSA complaint #11752421, 2026

“The contact owns a 2018 Mazda CX-5. The contact stated that while driving the vehicle he could smell a burning odor, and added that he noticed a puddle of oil on his driveway. The vehicle was taken to an independent mechanic where it was diagnosed to have a cylinder crack causing the cylinder to leak oil all over the engine. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 104,000.”
NHTSA complaint #11742070, 2026

“The contact owns a 2018 Mazda CX-5. The contact stated that while driving at 45 MPH, there was smoke coming from the engine, and the contact smelled an oil-burning odor. No warning lights were illuminated. A dealer was contacted. The vehicle was towed to the dealer where it was diagnosed and determined that the cylinder head was damaged, causing oil to leak into the cylinders, and that the engine needed to be replaced. The manufacturer was notified of the failure, and promised to open a case and give the contact a callback within 24 to 48 hours. The approximate failure mileage was 59,000.”
NHTSA complaint #11694487, 2025

Forward Collision Avoidance 3

“I am reporting a safety issue involving engine failure and fumes entering the vehicle cabin as well as unintended braking post major engine repair at 75,000 miles on my 2018 Mazda CX5. My vehicle developed engine problems consistent with a cylinder head/coolant defect and began allowing fumes/smoke to enter the cabin while driving. This created a health and safety concern for occupants. I reported this to the dealership and was told the vehicle was safe to drive despite the presence of fumes in the cabin. A major engine repair was later performed. A few days following the repair, additional…”
NHTSA complaint #11730227, 2026

“The infotainment system consistently changes stations and volume on its own. Knob will not allow you to make adjustments . Contacted dealer and infotainment Is not covered under warranty , or extended warranty. Now the collision notification is not working. Warnings from system that it has failed and causes system to not Register any movement . This has been going on recently. Now have to drive it as it doesn’t have the system. And have to use my Apple play for radio as infotainment keeps failing to include radio and navigation Told by dealer that the infotainment system is not Mounted int…”
NHTSA complaint #11708847, 2025

“Multiple instances of phantom braking, which resulted in two instances where we were just inches from being rear-ended. The circumstances of the phantom braking are similar, and has occured many times. CIRCUMSTANCES OF PHANTOM BRAKING are as follows: vehicle in front in lane makes right hand turn from lane (with or without turn signal or braking). The vehicle in front typically has exited the lane, and the Mazda emergency brakes hard! Variable vehicle acceleration/deceleration dynamics factors: the Mazda could be coasting, decelerating with brake litely applied, accelerating in lane (because v…”
NHTSA complaint #11584189, 2024

Electrical System 2

“The cylinder head on my 2018 Mazda CX-5 developed cracks on the exhaust side, leading to significant oil leakage onto the exhaust manifold. This has caused engine damage and safety concerns. The vehicle is currently at a Mazda dealership, where the issue has been inspected and documented. The component is available for further inspection upon request. The oil leaking onto the exhaust manifold creates a serious fire hazard due to the high heat generated in this area. Additionally, the vehicle experienced burning smells and visible smoke coming through the air vents, which could impair visibili…”
NHTSA complaint #11631241, 2024

“Touch Screen and/or infotainment center causing ghost touch. Available for inspection. Ghost touch (known Mazda issue) with touch screen has been changing radio stations, increasing volume to max. Will go into user settings and change guidance voice to full volume, increasing bass to full volume, fast forward songs, mute phone call feature, randomly switch from bluetooth to handset of phone. All of this is done without the driver or anyone else in the car touching anything. When this happens there is no easy fix. I cannot just stop the song, mute the volume. We have to wait for it to decide to…”
NHTSA complaint #11740394, 2021

Fuel/Propulsion System 2

“Check engine light on when read it comes back with P0171 code”
NHTSA complaint #11750286, 2026

“The cylinder head and timing cover are leaking oil and need to be replaced. It is at the dealer and available for inspection. The car started smoking and lost oil obscuring my vision. The problem appears to be well known by the dealer and they were able to diagnose the issue. The vehicle has only been inspected by the dealer where I purchased it. There were no warning lamps, messages or other symptoms. This vehicle has had regular maintenance per the manufacturers specifications since it was purchased new.”
NHTSA complaint #11582466, 2024

Back Over Prevention 1

“Back up cameras fail infotainment system reboots and maps on the system inadvertently counts stops plus changes volume at loudspeaker telling me “this is the level “ and is on highest volume. Which you can’t turn down. All are dangerously interfering with driving. Please put pressure on Mazda to fix and not just update software when the problem has been fixed called CMU”
NHTSA complaint #11685123, 2025

Lane Departure 1

“Back up cameras fail infotainment system reboots and maps on the system inadvertently counts stops plus changes volume at loudspeaker telling me “this is the level “ and is on highest volume. Which you can’t turn down. All are dangerously interfering with driving. Please put pressure on Mazda to fix and not just update software when the problem has been fixed called CMU”
NHTSA complaint #11685123, 2025

Service Brakes 1 1 crash

“Unintended acceleration incident. I entered the parking lot of a business where the Salvation Army is located to drop off a donation. The parking spaces were on the left side. As I pulled into a parking space and was in the process of parking, the vehicle suddenly lurched/accelerated forward unexpectedly and struck the concrete wall of the building. The airbags did not deploy despite the frontal impact. No one was seriously injured, but my husband, daughter, and I experienced soreness the following day from the impact. Thankfully, I had chosen a parking space in front of a concrete wall rathe…”
NHTSA complaint #11737223, 2026 · crash

Steering 1

“We purchased this vehicle used from Mazda of Orange in July 2025 with 52,399 miles on it. After 6 months of ownership and approximately 3,000 miles there was a burning smell. We took it to our local mechanic and the following repairs were required: Replacement of cracked belts, Replacement of cracked axle boots, Replacement of an excessively loose front axle, Replacement of valve cover gasket. Cost was $3,000 and the dealer refused to reimburse us. Now the car is leaking oil and needs a new head gasket and cylinder head surface machined. Quote was approximately $3,500. We have requested…”
NHTSA complaint #11738202, 2026