2016 Toyota Avalon Problems & Owner Complaints

Unknown Or Other 5

“The manufacturer is no longer producing OEM windshield that comply with the a DAS features which are now in operable because my windshield will not calibrate after replacement because there is not an OEM windshield available. I have contacted Toyota. I have also searched everywhere in the states for an OEM windshield Toyota has tried to calibrate the replacement which is aftermarket, as well as the Auto Glass installer to no avail. Toyota is no longer manufacturing the OEM windshield which is needed for the safety features to function properly. The car should be recalled for a manufacturer def…”
NHTSA complaint #11576871, 2024

“MY CAR HAS AN SOS SYSTEM THAT NOTIFIES TOYOTA OR THEIR CONTRACTOR IF THE CAR HAS BEEN IN AN ACCIDENT, SUMMONS LAW ENFORCEMENT, TOW TRUCK, ETC. I DO NOT KNOW WHAT OTHER SAFETY ISSUES ARE WRAPPED INTO IT. IT HAS A RED WARNING LIGHT THAT GOES ON WHEN IT STOPS WORKING. IT HAS BEEN INTO MY LOCAL DEALER THREE TIMES TO BE REPAIRED AND EACH "REPAIR" HAS FAILED IMMEDIATELY UPON ME PICKING IT UP AGAIN. TODAY, AFTER THE DEALER WORKED ON IT, THE DECIDED THAT THE "CELL SYSTEM" THAT IS BUILT INTO THE CAR AND IS UNDER THE PASSENGER SEAT NEEDS TO BE REPLACED AND WILL COST $2200.00. I DON'T KNOW WHAT OTHER "SA…”
NHTSA complaint #11297466, 2019

“THE FRONT TO BACK SIDE RUBBER WEATHERSTRIPPING THAT MOVES WITH THE SUNROOF AS IT OPENS AND CLOSES CONTINUES TO FALL OFF. THERE ARE TWO PIECES LIKE THIS, ONE ON THE DRIVER'S SIDE THE OTHER ON THE PASSENGER'S SIDE. THE TWO PIECES, EACH ABOUT 18 INCHES LONG AND TWO INCHES WIDE, LOOK LIKE BLACK RUBBER SMALL ACCORDIONS. WHILE DRIVING AND OPENING OR CLOSING THE SUNROOF, THESE STRIPS FALL OFF. DEALER HAS REINSTALLED MULTIPLE TIMES, BUT THEY CONTINUE TO LOOSEN AND FALL OFF WITH THE MOVEMENT OF THE SUNROOF. SOMETIMES THIS WILL OCCUR WHILE DRIVING AT HIGH SPEEDS AND DISRUPT THE DRIVER, IN THE LAST…”
NHTSA complaint #11185484, 2019

Air Bags 4 1 crash 1 injury

“TRAVEL ON THE STREET AND MAY HIT AN OBJECT (COULD BE AN EMPTY TRASH CONTAINER. VEHICLE LEFT THE TRAVEL LANE, GOING UP ON THE SIDEWALK, STUCK 2 GARBAGE CANS AND THROUGH THE NUMEROUS BUSHES.”
NHTSA complaint #11362196, 2020 · crash · 1 injury(ies)

“RECALL OF 1/2020 STILL HAS NO REMEDY FROM MANUFACTURER AND NO ANTICIPATED DATE OF REMEDY AVAILABILITY (NHTSA RECALL NUMBER 20V024).”
NHTSA complaint #11322736, 2020

“"TAKATA RECALL" AIRBAG. I HAVE BEEN DEALING WITH MY AIRBAG LIGHT AND YELLOW TRIANGLE LIGHT COMING ON WHILE DRIVING FOR 3 DAYS. THE FIRST INCIDENT OCCURED WHILE I WAS DRIVING ON THE HIGHWAY DURING THE AFTERNOON AFTER DEALERSHIP HOURS. 2ND TIME WAS DRIVING ON THE HIGHWAY AND I IMMEDIATELY TOOK MY VEHICLE TO THE DEALERSHIP TO WHICH THEY TOLD ME MY BATTERY WAS DIRTY AND FAILING WAS THE REASON FOR THE AIRBAG LIGHT TO COME ON. 3RD TIME I WAS TOLD THAT MY CELL PHONE CHARGER WHICH WAS NEVER PLUGGED UP ON ANY OF THE TIMES THE LIGHT CAME ON WAS THE REASON. STILL DEALING WITH THE UNRESOLVED ISSUE.”
NHTSA complaint #11171952, 2019

Engine 4 1 fire

“TL* THE CONTACT OWNED A 2016 TOYOTA AVALON. APPROXIMATELY 30 MINUTES AFTER PARKING AND TURNING THE ENGINE OFF, FLAMES WERE DISCOVERED COMING FROM THE FRONT DRIVER'S SIDE CARPET. APPROXIMATELY 10 MINUTES LATER, THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN UNDISCLOSED LOCATION AND DEEMED DESTROYED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILA…”
NHTSA complaint #11097832, 2018 · fire

“ENGINE HESITATES FOR A FEW SECONDS WHEN STARTING FROM A STOP OR A SLOW SPEED IN CITY TRAFFIC. THE DEALER SAID IT WAS A COMPUTER LEARNING PROCESS AND IT SHOULD GO AWAY. PROBLEMS HAS BEEN AROUND SINCE NEW IN 2016.”
NHTSA complaint #11276855, 2019

“MY WIFE'S AVALON HESITATES FOR 3 OR 4 SECONDS INTERMITTENTLY DURING ACCELERATION WITHOUT WARNING. THE YELLOW TRIANGLE LIGHT COMES ON THE DASH BOARD DURING THE HESITATION. I SEEMS TO OCCUR MORE OFTEN AFTER TURNING LEFT AND ACCELERATING. I AM CONCERNED ABOUT HER SAFETY WHEN ENTERING TRAFFIC AND OR CROSSING A ROAD WITH AN UNEXPECTED HESITATION. OUR LOCAL TOYOTA DEALER SAYS THEY ARE NOT AWARE OF THIS KIND OF PROBLEM AND ARE NOT ABLE TO DIAGNOSE IT. WE WOULD LIKE TO KNOW IF THIS IS OCCURRING ELSE WHERE AND WHAT WE SHOULD DO ABOUT IT. PLEASE ADVISE.”
NHTSA complaint #11090804, 2018

Electrical System 3 1 crash 1 fire 1 injury

“TRAVEL ON THE STREET AND MAY HIT AN OBJECT (COULD BE AN EMPTY TRASH CONTAINER. VEHICLE LEFT THE TRAVEL LANE, GOING UP ON THE SIDEWALK, STUCK 2 GARBAGE CANS AND THROUGH THE NUMEROUS BUSHES.”
NHTSA complaint #11362196, 2020 · crash · 1 injury(ies)

“TL* THE CONTACT OWNED A 2016 TOYOTA AVALON. APPROXIMATELY 30 MINUTES AFTER PARKING AND TURNING THE ENGINE OFF, FLAMES WERE DISCOVERED COMING FROM THE FRONT DRIVER'S SIDE CARPET. APPROXIMATELY 10 MINUTES LATER, THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN UNDISCLOSED LOCATION AND DEEMED DESTROYED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILA…”
NHTSA complaint #11097832, 2018 · fire

“TOOK DELIVERY OF VEHICLE WITH 3 MILES ON JANUARY 27, 2016. VERY NEXT DAY THE VEHICLE WOULD NOT START WITHOUT SEVERAL ATTEMPTS. ON JANUARY 30 THE VEHICLE WAS STOPPED IN A PARKING LOT WHILE ON ERRANDS AND WOULD NOT START AFTER ATTEMPTING FOR 15 MINUTES. DEALER SERVICE DEPARTMENT ADVISES THAT THERE IS A DRAIN ON THE BATTERY WHEN THERE SHOULD NOT BE. VEHICLE HAS BEEN WITH SERVICE TECHNICIANS FOR THE 3RD DAY AND THEY HAVE YET TO IDENTIFY THE ROOT CAUSE. THE VEHICLE HAS 212 MILES AND I AM FEARFUL THAT AN ELECTRICAL PROBLEM WILL CAUSE FIRE AND SEVERE SAFETY ISSUES.”
NHTSA complaint #10823906, 2016

Structure 3 1 crash 1 injury

“ON OCTOBER 1, 2018, AT 8:25 A.M.I WAS PULLING INTO A PARKING SPACE AT WORK IN MY 2016 AVALON (12,141 MILES). I WAS 'RIDING THE BRAKE' TO PULL ALL THE WAY INTO THE PARKING SPACE. THE CAR TOOK OFF INTO LANDSCAPE, CROSSED A ROAD AND WENT DOWN A HILL. I HIT THE PARKING LOT AND WAS KNOCKED TO MY SIDE. THE CAR WENT BACK UP THE HILL AND CROSSED THE ROAD AGAIN, WENT THROUGH MORE LANDSCAPE, BUSHES, ETC. BACK INTO THE ROAD AGAIN AND STOPPED.THERE WAS OVER 11,000 DAMAGE TO MY CAR AND I HURT MY BACK AND NECK. TOYOTA EXAMINED THE BLACK BOX AND SAID THE GAS PEDAL WAS BEING STRONGLY DEPRESSED WITH NO BRA…”
NHTSA complaint #11187352, 2018 · crash · 1 injury(ies)

“THE MOON ROOF GLASS EXPLODED WHILE DRIVING DOWN THE HIGHWAY WITH ALL WINDOWS SHUT.”
NHTSA complaint #11192924, 2018

“TL* THE CONTACT OWNS A 2016 TOYOTA AVALON. WHILE THE VEHICLE WAS STOPPED AT AN INTERSECTION, A LOUD BOOM NOISE WAS HEARD AND THE SUN ROOF EXPLODED WITHOUT WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUN ROOF FAILED AND NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000.”
NHTSA complaint #10955045, 2017

Lane Departure 2

“The manufacturer is no longer producing OEM windshield that comply with the a DAS features which are now in operable because my windshield will not calibrate after replacement because there is not an OEM windshield available. I have contacted Toyota. I have also searched everywhere in the states for an OEM windshield Toyota has tried to calibrate the replacement which is aftermarket, as well as the Auto Glass installer to no avail. Toyota is no longer manufacturing the OEM windshield which is needed for the safety features to function properly. The car should be recalled for a manufacturer def…”
NHTSA complaint #11576871, 2024

Power Train 2

“INTERMITTENTLY THE CAR WILL NOT SHIFT FROM LOW GEAR. WHEN PLACING THE GEARSHIFT IN THE D POSITION IT WILL INDICATE EITHER D1 AND WILL NOT AUTOMATICALLY SHIFT TO A HIGHER GEAR. ONCE THE CAR COMES TO A COMPLETE STOP THE INDICATOR WILL BY ITSELF CHANGE TO D AND WILL SHIFT NORMALLY.”
NHTSA complaint #11066879, 2018

“TL* THE CONTACT OWNS A 2016 TOYOTA AVALON. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED AT LOW SPEEDS, THE VEHICLE HESITATED TO RESPOND AND SUDDENLY SURGED FORWARD. THE FAILURE OCCURRED WITHOUT WARNING. IN ADDITION, THE VEHICLE FELT AS THOUGH IT SHIFTED INDEPENDENTLY INTERMITTENTLY. THE DEALER DIAGNOSED THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.”
NHTSA complaint #10956795, 2017

Service Brakes 2 1 crash 1 injury

“ON OCTOBER 1, 2018, AT 8:25 A.M.I WAS PULLING INTO A PARKING SPACE AT WORK IN MY 2016 AVALON (12,141 MILES). I WAS 'RIDING THE BRAKE' TO PULL ALL THE WAY INTO THE PARKING SPACE. THE CAR TOOK OFF INTO LANDSCAPE, CROSSED A ROAD AND WENT DOWN A HILL. I HIT THE PARKING LOT AND WAS KNOCKED TO MY SIDE. THE CAR WENT BACK UP THE HILL AND CROSSED THE ROAD AGAIN, WENT THROUGH MORE LANDSCAPE, BUSHES, ETC. BACK INTO THE ROAD AGAIN AND STOPPED.THERE WAS OVER 11,000 DAMAGE TO MY CAR AND I HURT MY BACK AND NECK. TOYOTA EXAMINED THE BLACK BOX AND SAID THE GAS PEDAL WAS BEING STRONGLY DEPRESSED WITH NO BRA…”
NHTSA complaint #11187352, 2018 · crash · 1 injury(ies)

“The contact owns a 2016 Toyota Avalon. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop immediately and made an abnormal sound. Additionally, the center console was extremely hot, and the driver's side seat electric panel cover had detached. The contact inspected the driver's side seat and noticed there was rust on the seat. The vehicle was taken to the dealer where the brake pads were cleaned; however, the mechanic was unable to duplicate the failure for the center console. The vehicle was not repaired. The manuf…”
NHTSA complaint #11506672, 2022

Vehicle Speed Control 2 1 crash 1 injury

“ON OCTOBER 1, 2018, AT 8:25 A.M.I WAS PULLING INTO A PARKING SPACE AT WORK IN MY 2016 AVALON (12,141 MILES). I WAS 'RIDING THE BRAKE' TO PULL ALL THE WAY INTO THE PARKING SPACE. THE CAR TOOK OFF INTO LANDSCAPE, CROSSED A ROAD AND WENT DOWN A HILL. I HIT THE PARKING LOT AND WAS KNOCKED TO MY SIDE. THE CAR WENT BACK UP THE HILL AND CROSSED THE ROAD AGAIN, WENT THROUGH MORE LANDSCAPE, BUSHES, ETC. BACK INTO THE ROAD AGAIN AND STOPPED.THERE WAS OVER 11,000 DAMAGE TO MY CAR AND I HURT MY BACK AND NECK. TOYOTA EXAMINED THE BLACK BOX AND SAID THE GAS PEDAL WAS BEING STRONGLY DEPRESSED WITH NO BRA…”
NHTSA complaint #11187352, 2018 · crash · 1 injury(ies)

“TL* THE CONTACT OWNS A 2016 TOYOTA AVALON. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED AT LOW SPEEDS, THE VEHICLE HESITATED TO RESPOND AND SUDDENLY SURGED FORWARD. THE FAILURE OCCURRED WITHOUT WARNING. IN ADDITION, THE VEHICLE FELT AS THOUGH IT SHIFTED INDEPENDENTLY INTERMITTENTLY. THE DEALER DIAGNOSED THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.”
NHTSA complaint #10956795, 2017

Visibility 2

“The contact owns a 2016 Toyota Avalon. The contact stated that while driving approximately 70 MPH, the sunroof glass shattered. The contact stated that there was no glass inside the vehicle because the sunroof shade was in the closed position. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 95,500.”
NHTSA complaint #11691211, 2025

“TL* THE CONTACT OWNS A 2016 TOYOTA AVALON. WHILE THE VEHICLE WAS STOPPED AT AN INTERSECTION, A LOUD BOOM NOISE WAS HEARD AND THE SUN ROOF EXPLODED WITHOUT WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUN ROOF FAILED AND NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000.”
NHTSA complaint #10955045, 2017

Forward Collision Avoidance 1

“The manufacturer is no longer producing OEM windshield that comply with the a DAS features which are now in operable because my windshield will not calibrate after replacement because there is not an OEM windshield available. I have contacted Toyota. I have also searched everywhere in the states for an OEM windshield Toyota has tried to calibrate the replacement which is aftermarket, as well as the Auto Glass installer to no avail. Toyota is no longer manufacturing the OEM windshield which is needed for the safety features to function properly. The car should be recalled for a manufacturer def…”
NHTSA complaint #11576871, 2024

Seat Belts 1 1 crash 1 injury

“TRAVEL ON THE STREET AND MAY HIT AN OBJECT (COULD BE AN EMPTY TRASH CONTAINER. VEHICLE LEFT THE TRAVEL LANE, GOING UP ON THE SIDEWALK, STUCK 2 GARBAGE CANS AND THROUGH THE NUMEROUS BUSHES.”
NHTSA complaint #11362196, 2020 · crash · 1 injury(ies)

Tires 1

“The contact owns a 2016 Toyota Avalon equipped with Cooper Tires, Tire Line: CS5 Ultra Touring, Tire Size: 215/55/R17, DOT Number: U93R1CU1820. The contact stated that while driving at various speeds, the front end of the vehicle was shaking abnormally without warning. The contact took the vehicle to a tire shop and was informed that the tread on the driver’s and passenger’s side tires were separating. The contact's husband drove the vehicle to the original tire shop where the tires were purchased and was offered a store credit for the replacement tires. The manufacturer was not made aware of…”
NHTSA complaint #11520951, 2023

Visibility/Wiper 1

“REAR WINDOW IS DISTORTED. THE DISTORTION APPEARS ESPECIALLY ACUTE WHEN HIGHWAY DRIVING. THIS IS A KNOWN PROBLEM WITH AVALONS OVER MORE THAN ONE MODEL YEAR.”
NHTSA complaint #11019603, 2016