2014 Toyota Highlander Problems & Owner Complaints

Electrical System 35 1 fire

“I noticed the smell of wires burning, a billow of smoke started emitting from the two levers used to heat the seats near the gear shift area. I was on the freeway and immediately pulled to the side of the road, turned off the car and called 911 before any flames were seen. There were no warning signs, lamps or other symptoms until the smell of burning wires and the smoke.”
NHTSA complaint #11735704, 2026 · fire

“The radio keeps freezing up all the time along with the back tail light area going in and out. I keep smelling like burnt wire smell. Engine sound really rough.”
NHTSA complaint #11750492, 2026

“The contact owns a 2014 Toyota Highlander. The contact stated that a hybrid system warning alert was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the windshield wiring system had failed and that the windshield needed to be replaced. The vehicle was not repaired. The mechanic informed the contact that the windshield failure was associated with NHTSA Campaign Number: 18E107000 (Electrical System, Visibility). The dealer was not contacted. The vehicle was not diagnosed or repaired. The windshield manufacturer was made aware of the failure…”
NHTSA complaint #11715109, 2026

Unknown Or Other 33 2 injury

“REAR LIFT DOOR (HATCHBACK) DOES NOT STOP IF AN ARM OR BODY PART IS IN THE WAY ONCE THE BUTTON TO CLOSE IS PUSHED. MY HAIR GOT CAUGHT IN THE LOCK AND THE DOOR WAS CLOSING SO I TRIED TO STOP IT WITH MY ARM AND IT KEPT CLOSING ON MY ARM WITH MY HAIR CAUGHT AND MY ARM IS SEVERELY BRUISED. THE VEHICLE WAS IN PARK AND SHUT OFF IN MY DRIVEWAY”
NHTSA complaint #10901965, 2016 · 1 injury(ies)

“WHEN DRIVING ON THE HIGHWAY THERE IS LOUD WIND NOISE WITH WINDOW SHUT. ALSO IF ONE WINDOW IS DOWN THERE IS A AWFUL NOISE THAT HURTS THE EARS.”
NHTSA complaint #10776448, 2015 · 1 injury(ies)

“The lift gate will not open and close properly. It only works about 5% of the time.”
NHTSA complaint #11559809, 2023

Structure 32 1 crash 1 injury

“I WAS T BONED ON PASSENGER SIDE, SIDE IMPACT AIR BAG DID NOT DEPLOY. I WAS PUSHED INTO ONCOMING TRAFFIC, FRONT AIRBAGS DID NOT DEPLOY IN HEAD ON COLLISION. SEAT BELT DID NOT TIGHTEN- I INITIALLY HIT DRIVERS SIDE WINDOW, WHEN T-BONED, THEN WITH FRONT IMPACT HIT STEERING WHEEL, ROOF AND CENTER CONSOLE. *TT *TR”
NHTSA complaint #11085042, 2018 · crash · 1 injury(ies)

“The driver’s-side rear spoiler on my 2014 Toyota Highlander Limited AWD has melted, bubbled, and warped. The vehicle has been stored 100% of the time in a fully enclosed garage with no windows since new. It has only 65,000 miles and has received all service exclusively at authorized Toyota dealerships. There has been no direct sun exposure, accident, or misuse. Toyota dealer and Corporate attributed this to “solar convergence” and denied any repair assistance or goodwill coverage. This explanation does not match the facts given the garage setup and minimal outdoor time. This appears to be a…”
NHTSA complaint #11735785, 2026

“Was driving 70 mph on nj 287 when all sudden I hear something that sounded like implosion and air was coming from sunroof. Ended up being sun roof glass flew out of car sunroof frame. Toyota knew it was a defect as they did inspection but did not want to cover it because they said it’s out of warranty. Thankfully no one was driving behind me at that time”
NHTSA complaint #11712555, 2026

Power Train 8

“SHARDS OF METAL INSIDE TRANSMISSION PAN AT 74K MILES. WHILE DRIVING AT DIFFERENT MPH, THE VEHICLES FEELS LIKE IT'S SLIPPING INTO NEUTRAL. *TR”
NHTSA complaint #11329475, 2020

“WITHIN THE PAST MONTH OR SO THERE WERE A FEW SEPARATE/SPORADIC OCCASIONS WHEN THE TRANSMISSION OF MY 2014 HIGHLANDER WITH 82,344 GENTLE MILES ON IT SEEMED TO SLIP/NOT ENGAGE FOR A MOMENT WHEN FIRST STARTING TO TRAVEL AT A LOW RATE OF SPEED. WHEN THE TRANSMISSION DID ENGAGE DURING THESE EPISODES IT WAS ABRUPT AND NOTICEABLE CREATING AN AUDIBLE NOISE AND JERKED THE VEHICLE. THIS PAST WEEKEND THE SAME THING HAPPENED EXCEPT THAT THIS TIME THE CHECK ENGINE LIGHT CAME ON AND THE MESSAGES "TRAC OFF" AND "CHECK AWD SYSTEM" WERE DISPLAYED. I BROUGHT THE VEHICLE IMMEDIATELY TO THE DEALERSHIP I BOUGHT…”
NHTSA complaint #11268639, 2019

“2014 TOYOTA HIGHLANDER. CONSUMER WRITES IN REGARDS TO VEHICLE WHEELS LOCKING UP WHILE DRIVING. *LD THE CONSUMER STATED THE TRANSMISSION WAS DEFECTIVE. THE TRANSMISSION STOPS, PULLS, THEN SLAMS INTO GEAR. A WARNING MESSAGE APPEARS STATING 'CHECK ALL WHEEL DRIVE TRACK OFF'. THE SOLENOID FAILED. *JS”
NHTSA complaint #11207776, 2018

Visibility/Wiper 6 1 crash 1 injury 1 death

“I WAS DRIVING MY VEHICLE ON OUR STREET, WHICH IS CONSIDERED A PRIVATE ROAD, WHILE PREPARING TO TURN AROUND A BEND IN THE ROAD, A 94YR OLD WOMAN WALKED IN FRONT OF MY CAR, WAS STRUCK, AND DIED. AT NO TIME DURING MY TURN DID I SEE THE WOMAN AS SHE STEPPED IN FRONT OF MY CAR. RESEARCH OF THE 2014 HIGHLANDER REVEALED MANY OWNERS HAD DIFFICULTY SEEING ANY OBJECT OR PERSON DUE TO THE BLIND SPOT OF THE LEFT SIDE MIRROR. RESEARCH AT TOYOTA NATION FORUM, REVEALED ALL OWNERS HAD BLIND SPOTS DUE TO THE SIZE AND POSITION OF THE LEFT SIDE MIRROR. MOST WERE RELATED TO DRIVERS 5'2" IN HEIGHT, BUT 6FT DRIVER…”
NHTSA complaint #11203156, 2019 · crash · 1 death(s)

“The radio keeps freezing up all the time along with the back tail light area going in and out. I keep smelling like burnt wire smell. Engine sound really rough.”
NHTSA complaint #11750492, 2026

“The glass from the panoramic sunroof detached from the vehicle while traveling approximately 60 MPH.”
NHTSA complaint #11513770, 2023

Seat Belts 5 2 crash 2 injury

“I WAS T BONED ON PASSENGER SIDE, SIDE IMPACT AIR BAG DID NOT DEPLOY. I WAS PUSHED INTO ONCOMING TRAFFIC, FRONT AIRBAGS DID NOT DEPLOY IN HEAD ON COLLISION. SEAT BELT DID NOT TIGHTEN- I INITIALLY HIT DRIVERS SIDE WINDOW, WHEN T-BONED, THEN WITH FRONT IMPACT HIT STEERING WHEEL, ROOF AND CENTER CONSOLE. *TT *TR”
NHTSA complaint #11085042, 2018 · crash · 1 injury(ies)

“TO AVOID TWO DEER CROSSING ROAD (BULL BRIDGE ROAD, SOUTH KENT, CT) ON CURVE, LOST CONTROL ON RIGHT SHOULDER, HIT STRAIGHT ON THE UTILITY WOOD POLE. MY SPEED WAS IN BETWEEN 25 AND 30 MPH. DURING THE ACCIDENT, ALL AIRBAGS DID NOT GO OFF AND THE SEAT BELT DID NOT LOCK ME UP. THE IMPACT CAUSED MY CHEST, BACK, NECK AND HEAD INJURIES.”
NHTSA complaint #10881808, 2016 · crash · 1 injury(ies)

“PASSENGER FRONT SEAT BELT WILL NOT RETRACT, WHEN I GOT OUT OF VEHICLE TODAY. DINGING SOUND COMING FROM SOMEWHERE WHEN WE DROVE IT LAST NIGHT.”
NHTSA complaint #11385249, 2020

Vehicle Speed Control 5 1 crash 1 injury

“WHILE BACKING OUT OF MY DRIVEWAY, THERE WAS A SOUND, AND THE CAR SUDDENLY ACCELERATED AND COULD NOT STOP WHEN PRESSED THE BRAKE AND THE PARKING BRAKE. CRASHED INTO THE NEIGHBOR'S YARD WITH SUCH FORCE THAT THE CAR ROLL OVER. IT COULD HAVE CAUSED SERIOUS INJURY TO ME, A PASSERBY, OR NEIGHBOR'S CHILDREN.”
NHTSA complaint #11110937, 2018 · crash · 1 injury(ies)

“ON CITY STREET DRIVING ABOUT 37 MPH. ADAPTIVE SPEED CONTROL ENGAGED. I APPROACH A CAR GOING THE SAME DIRECTION SLIGHTLY SLOWER, ABOUT 35 MPH. THAT SLOWER CAR IS FOLLOWING ANOTHER CAR ABOUT 2 CAR LENGTHS IN FRONT. MY CAR GENTLY BREAKS TO BRING MY SPEED BACK TO 35 MPH. MY 35 MPH IS BEING MAINTAINED AT A FIXED DISTANCE FROM THE CAR IN FRONT OF ME. THE CAR DIRECTLY IN FRONT OF ME CHANGES LANE OPENING UP A GAP OF ABOUT 3-4 CAR LENGTHS TO THE CAR IN FRONT OF ME. MY CAR NOW SPEEDS UP AGGRESSIVELY BECAUSE THERE IS NO CAR DIRECTLY IN FRONT OF ME. INSTEAD OF BREAKING WHEN MY CAR GETS CLOSER TO THE REA…”
NHTSA complaint #11115422, 2018

“WHEN USING THE ADAPTIVE CRUISE CONTROL IT MAINTAINS A USER SPECIFIED TRAVELLING DISTANCE BEHIND THE VEHICLE IN FRONT. WHEN THE VEHICLE CHANGES LANES, OR IS TURNING OFF, THE VEHICLE IS BARELY OFF THE LANE, BUT THE ADAPTIVE CRUISE CONTROL STILL REACTS TO THE CAR THAT HAS EXITED THE LANE. THIS CAUSES MY TOYOTA TO REACT TO THE SLOWED VEHICLE THAT HAS JUST EXITED MY LANE BY SLOWING UNNECESSARILY, AND CAUSING VEHICLES BEHIND ME TO HAVE TO SLOW AND SOME TIMES GET IRRITATED BY THIS ACTION. I TOLD TOYOTA ABOUT THIS. I WAS TOLD THERE IS A FIX ON THE WAY, BUT NO ACTION HAS TAKEN PLACE IN THE PAST 3 Y…”
NHTSA complaint #11002035, 2017

Steering 4

“Steering column locked on several occasions while driving. Electrical systems blink on and off. Exactly as described in NHTSA recall #15V144000 and as far I can tell the exact same part number.”
NHTSA complaint #11493822, 2022

“MY TOYOTA HIGHLANDER 2014 HAS A HUGE SECURITY AND SAFETY ISSUE. ITS STEERING WHEEL JAMMED AND IT BECOME COMPLETELY DISABLED WHILE I WAS DRIVING AND THE ENGINE WONT START AGAIN. IT HAS THE FOLLOWING MESSAGES IN THE DASHBOARD. 1- 'EPS FAILURE. STEERING WHEEL IS HARDER TO TURN'. 2- 'THE ENGINE HAS STOPPED. PLEASE PUT THE SHIFT LEVER TO P'. 3- 'TRAC OFF' 4- 'BRAKE OVERRIDE SYSTEM FAILURE'. MY CAR HAD SAME ISSUE BACK AUG 2017 BUT THE TOYOTA DEALERSHIP CLAIMED THAT THEY DIDN'T SEE SUCH ISSUE AND THE CAR STARTED NORMAL. I DON'T KNOW WHAT KIND OF DIAGNOSTICS THEY PERFORMED BECAUSE I AM HAVING THE SA…”
NHTSA complaint #11046014, 2017

“VEHICLE SHUT OFF DURING DRIVING, CAUSING ALL ELECTRICAL SYSTEMS TO FAIL INCLUDING THE ELECTRONIC STEERING, WHICH SINCE VEHICLE ALSO TURNED OFF, CAUSED THE STEERING COLUMN TO LOCK UP. SINCE THE PROBLEM OCCURRED AT SPEED AND INFACT WHILE MAKING A TURN, A NEAR COLLISION OCCURED. THE PROBLEM OCCURED MULTIPLE TIMES IN SUCCESSION AND WAS ALSO INTERMITTENT WITH MUCH TIME ELAPSING BETWEEN EPISODES. TWO OTHER TYPES OF RELATED OCCURRENCES DURING THIS TIMEFRAME WERE THE (1) VEHICLE ALSO CYCLING OFF AND ON AND (2) WOULD ALSO TURN ON ITSELF IF THE KEY WAS IN THE VICINITY OF THE VEHICLE. TOYOTA OF SEATTLE E…”
NHTSA complaint #10874448, 2016

Suspension 4

“TL* THE CONTACT OWNS A 2014 TOYOTA HIGHLANDER. THE CONTACT STATED THAT AN ABNORMAL SQUEAKING NOISE WAS HEARD COMING FROM THE REAR DRIVER SIDE OF THE VEHICLE. THE NOISE OCCURRED INTERMITTENTLY WHILE MAKING TURNS. THE DEALER WAS NOT CONTACTED. THE CONTACT RESEARCHED THE FAILURE ONLINE AND FOUND THAT THE FAILURE WAS DUE TO A DAMAGED REAR SUSPENSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 46,000. *TT”
NHTSA complaint #11101441, 2018

“I'VE PURCHASED 2014 HIGHLANDER ON JAN 2014. I HAVE COMPLAINED TO THE DEALERS ABOUT THE REAR NOISE STARTING IN 2014 AND ALL THEY COULD SAID WAS TO MAKE SURE THE JACK TOOL IS SECURED IN THE BACK. THEY COULDN'T IDENTIFIED THE ISSUE. TODAY I FOUND SB0016-16 AND HAD A DEALER CONFIRMED THE TRAILING ARM ISSUE. THIS IS PART OF THE REAR SUSPENSION SYSTEM. I CONTACTED TOYODA WITH CASE #1708260897 AND THEY SAID MINE IS OUT OF WARRANTY AND WON'T PAY FOR THE REPAIR. IT DIDN'T MATTER IF THE ISSUE WAS IDENTIFIED BEFORE THE WARRANTY HAS EXPIRED AND BEFORE THIS BULLETIN SB0016-16 CAME OUT. THE REPAIR COST IS…”
NHTSA complaint #11022368, 2017

“GPS/RADIO OFTEN TURNS OFF WHILE DRIVING. SCREEN COMPLETELY GOES BLANK AND KEEPS TRYING TO RESET ITSELF. VOICE COMMANDS OFTEN DON'T WORK WHILE DRIVING OR STATIONARY. BLUE TOOTH OFTEN DOESN'T CONNECT WHILE DRIVING OR STATIONARY. TAILGATE OFTEN DOESN'T CLOSE AND TAKES MULTIPLE TRIES TO GET TO WORKING AGAIN WHEN STATIONARY. SPONGY/BROKEN SPRING SOUND COMING FROM THE REAR OF THE CAR AS I DROVE OVER UNEVEN ROAD. REAR LEFT TAIL LIGHT ALWAYS FOGGY AND CONTAINS MOISTURE EVEN AFTER REPLACING IT. CHIRPING SOUND COMING FROM RIGHT SIDE OF CAR WHEN DRIVING ON HIGHWAY ON WINDY DAYS. WHEEL AND CAR SHA…”
NHTSA complaint #11104631, 2016

Tires 4

“Installed (4) Firestone Destination Le3 tires in March 2022. All four tires became dry rot in just over 2 years, failed inspection at 2 1/2 years. 70,000 mile tires with roughly 28,000 miles left of the warranty.”
NHTSA complaint #11639254, 2024

“The tires have worn down to needing replacing after only 27,308 miles on them, these tires are rating and warrantied for 60,000 miles. Reviews online show other owners complaining about the same issue with premature wear and safety issues. When it rains, the vehicle will slip when attempting to drive, slide when stopping, and hydroplaning at less than normal road speeds.”
NHTSA complaint #11428998, 2021

“SPARE TIRE WAS FOUND TO BE CRACKED AND UNUSABLE WHEN NEEDED. IT WAS NEVER USED BEFORE. TECHNICIAN CHANGING TIRE SAID IT WAS UNSAFE.”
NHTSA complaint #11121013, 2018

Visibility 4

“The contact owns a 2014 Toyota Highlander. The contact stated that a hybrid system warning alert was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the windshield wiring system had failed and that the windshield needed to be replaced. The vehicle was not repaired. The mechanic informed the contact that the windshield failure was associated with NHTSA Campaign Number: 18E107000 (Electrical System, Visibility). The dealer was not contacted. The vehicle was not diagnosed or repaired. The windshield manufacturer was made aware of the failure…”
NHTSA complaint #11715109, 2026

“The contact owns a 2014 Toyota Highlander. The contact stated while driving approximately 40 MPH, the moon roof detached from the vehicle. There was no warning light and there was no impact to have caused the failure. There were no reported injuries. The local dealer had previously replaced a piece on the moon roof. The vehicle was taken to the local dealer, where it was diagnosed that the moon roof glass needed to be replaced. The vehicle was repaired. The manufacturer was contacted, but no additional assistance was provided. The approximate failure mileage was 99,000.”
NHTSA complaint #11631027, 2024

“The contact owns a 2014 Toyota Highlander. The contact stated while driving approximately 70 mph, there was a loud wind sound present. After opening the interior sun roof sliding shade, it was discovered that the glass sun roof had detached from the vehicle. The cause of the failure was not determined. The vehicle was repaired at a local repair center. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 168,000.”
NHTSA complaint #11418319, 2021

Engine 3

“While driving car started singing and message came on dashboard about idling will cause the engine to turn off then the car turned off while I was driving it has happened multiple other times even after taking it to the dealership twice and then doing an update on it”
NHTSA complaint #11505234, 2022

“NEAR THE END OF A 180 MILE TRIP, VEHICLE WAS ON HIGHWAY TRAVELING AT APPROXIMATELY 60 MPH WHEN LIGHT CAME ON SAYING ENGINE HAD STOPPED. ENGINE WAS SMOKING AND WAS COMPLETELY OUT OF OIL DESPITE IT BEING FULL AT THE START OF THE TRIP. MECHANIC FOUND THAT ENGINE HAD SEIZED AND HAD TO BE REPLACED IN FULL. UPPER MANIFOLD ALSO HAD TO BE REPLACED DUE TO PRESENCE OF METAL SHAVINGS. TRANSMISSION WAS LATER FOUND TO BE LEAKING OIL AND AT THIS TIME APPEARS UNFIXABLE. CAR HAS BEEN VERY WELL MAINTAINED WITH REGULAR MAINTENANCE AND OIL CHANGES AND THERE WERE NO WARNING SIGNS OF ANY ISSUES - CAR RAN SMOOTHLY…”
NHTSA complaint #11364190, 2020

“PURCHASED VEHICLE 5/26/14. AT FIRST HAD A POPPING NOISE FROM RIGHT REAR BREAK; TOOK TO DEALERSHIP STATING COULD FIND PROBLEM, SO LIVED WITH IT. AT 10,000 + MILES DEALER FOUND FRONT BREAKS WARPED, SO HAD THEM REPLACED. AROUND SAME 10K + MILES DEALER HAD TO DROP ENGINE TO REPLACE LEAKING OIL FOUND AROUND TIMING COVER AREA, STATING FACTORY INSTALL DID NOT ALLOW PROPER SEALING. ON 7/22/15, @ 12,748 MILES NOTICED OIL LEAK SAME AREA, AND INFORMED BY DEALER THAT ENGINE HAS TO BE DROPPED FOR THE 2ND TIME TO REPAIR OIL LEAK. ABOVE DOES NOT INCLUDE OTHER ISSUES SUCH AS REPLACING MIDDLE ROW CUP HOLDER…”
NHTSA complaint #10735889, 2015

Service Brakes 3 1 crash

“I WAS DRIVING MY CAR ON THE RIGHT ONLY LANE AND SEE THE RED LIGHT ON THE TRAFFIC SIGNAL. IT IS NOT A BUSY STREET. AND THERE IS A CAR IN FRONT OF MINE. I APPLIED BRAKES AND THE BRAKES MALFUNCTIONED. THE CAR DID NOT STOP AND TRIED BY PUSHING THE BRAKES IN FULL THROTTLE. IT DID NOT WORK AND MY CAR BUMPED INTO THE CAR IN FRONT OF ME. I TOWED MY CAR AND HAD MY CAR INSPECTED AT DEALERSHIP. THE REPORT WAS GREEN AND SO NO ISSUES. AND FILED A CASE WITH TOYOTA TO HAVE THE BLACK BOX REVIEWED. TOYOTA REPORTED NO ISSUES. AT THIS TIME I AM HELPLESS AND HAVE A SERIOUS CONCERN OF RUNNING INTO THE SAME ISSUE…”
NHTSA complaint #11139742, 2018 · crash

“POPPING NOISE FROM REAR BREAK FREQUENTLY WHEN I DISENGAGE THE EMERGENCY BRAKE LEVER. WHENEVER THIS HAPPENS THE VEHICLE IS STATIONARY AND NOT BEEN USED FOR 3 HOURS ON; TOOK TO DEALERSHIP STATING COULD FIND PROBLEM, BUT DEALER SAYS IT DIDN'T FIND ANYTHING ABNORMAL. DEALER'S MECHANIC SUGGESTED RELEASING THE EMERGENCY BRAKE BEFORE RELEASING PRESSURE FROM BRAKE PEDAL AS A RECOMMENDATION. I TOLD THEM THIS IS NOT THE ORDER OF STEPS RECOMMENDED BY MANUFACTURER (TOYOTA) IN THE OWNER'S MANUAL. THEY CONTESTED MY STATEMENT TELLING THTA THEIR MECHANICS ARE SPECIALIZED TECHNICAL PERSONNEL WHICH THEY TRUST…”
NHTSA complaint #10821432, 2015

“POPPING NOISE FROM REAR BREAK FREQUENTLY WHEN I DISENGAGE THE EMERGENCY BRAKE LEVER. WHENEVER THIS HAPPENS THE VEHICLE IS STATIONARY AND NOT BEEN USED FOR 3 HOURS ON; TOOK TO DEALERSHIP STATING COULD FIND PROBLEM, BUT DEALER SAYS IT DIDN'T FIND ANYTHING ABNORMAL.”
NHTSA complaint #10785091, 2015

Wheels 3

“The radio keeps freezing up all the time along with the back tail light area going in and out. I keep smelling like burnt wire smell. Engine sound really rough.”
NHTSA complaint #11750492, 2026

“2014 TOYOTA HIGHLANDER. CONSUMER WRITES IN REGARDS TO VEHICLE WHEELS LOCKING UP WHILE DRIVING. *LD THE CONSUMER STATED THE TRANSMISSION WAS DEFECTIVE. THE TRANSMISSION STOPS, PULLS, THEN SLAMS INTO GEAR. A WARNING MESSAGE APPEARS STATING 'CHECK ALL WHEEL DRIVE TRACK OFF'. THE SOLENOID FAILED. *JS”
NHTSA complaint #11207776, 2018

“SPARE TIRE WAS FOUND TO BE CRACKED AND UNUSABLE WHEN NEEDED. IT WAS NEVER USED BEFORE. TECHNICIAN CHANGING TIRE SAID IT WAS UNSAFE.”
NHTSA complaint #11121013, 2018

Air Bags 2 2 crash 2 injury

“I WAS T BONED ON PASSENGER SIDE, SIDE IMPACT AIR BAG DID NOT DEPLOY. I WAS PUSHED INTO ONCOMING TRAFFIC, FRONT AIRBAGS DID NOT DEPLOY IN HEAD ON COLLISION. SEAT BELT DID NOT TIGHTEN- I INITIALLY HIT DRIVERS SIDE WINDOW, WHEN T-BONED, THEN WITH FRONT IMPACT HIT STEERING WHEEL, ROOF AND CENTER CONSOLE. *TT *TR”
NHTSA complaint #11085042, 2018 · crash · 1 injury(ies)

“TO AVOID TWO DEER CROSSING ROAD (BULL BRIDGE ROAD, SOUTH KENT, CT) ON CURVE, LOST CONTROL ON RIGHT SHOULDER, HIT STRAIGHT ON THE UTILITY WOOD POLE. MY SPEED WAS IN BETWEEN 25 AND 30 MPH. DURING THE ACCIDENT, ALL AIRBAGS DID NOT GO OFF AND THE SEAT BELT DID NOT LOCK ME UP. THE IMPACT CAUSED MY CHEST, BACK, NECK AND HEAD INJURIES.”
NHTSA complaint #10881808, 2016 · crash · 1 injury(ies)

Equipment 2

“WE PURCHASED A 2014 TOYOTA HIGHLANDER LIMITED ON AUG 9, 2014. AFTER DRIVING THE VEHICLE FOR ABOUT 150 MILES THE PERSON IN THE RIGHT FRONT PASSENGER SEAT EXPERIENCES SEVERE BACK AND DISCOMFORT IN THE AREA OF THE TAILBONE. THERE IS SOMETHING VERY HARD TOWARDS THE BACK OF THE SEAT. I COMPLAINED TO THE SELLING DEALER AND THEY RECOMMENDED COMING BACK WHEN THE ZONE REP WAS IN AREA. I RETURNED A WEEK LATER AND MET WITH THE ZONE REP. SHE HAD ME SIT IN ANOTHER HIGHLANDER LIMITED AND ASKED IF IT FELT DIFFERENT, IT DID FEEL THE SAME. HER REPLY WAS "DIDN'T YOU SIT IN THE CAR BEFORE YOU BOUGHT I…”
NHTSA complaint #10715184, 2015

“FACTORY INSTALLED GPS SYSTEM WHEN SET TO A DESTINATION WILL TAKE YOU OFF THE MAIN ROAD JUST PRIOR TO YOUR DESTINATION AND DIRECT YOU IN CIRCLES THEN TELL YOU TO GET BACK ON THE MAIN ROAD THAT YOU JUST GOT OFF OF. THIS CREATES AN ISSUE AS ONE TIME IT TOOK US IN A UNDESIRABLE NEIGHBORHOOD; BUT MORE OFTEN THAN NOT WILL TAKE YOU CRUISING IN UNKNOWN NEIGHBORHOOD'S BEFORE IT TELLS YOU TO GET BACK ON THE MAIN ROAD YOU WERE JUST ON. ON OTHER OCCASIONS IT WILL TELL YOU TO TAKE SAY A RIGHT TURN THEN A FEW SECONDS LATER TELL YOU TO TAKE A LEFT TURN CAUSING YOU TO ERRATICALLY CHANGE LANES AND MAKE TURNS.…”
NHTSA complaint #10632114, 2014

Exterior Lighting 2

“Rear lights located both on the tailgate and body of the vehicle. The lights covers failed to remain adhered to the lights themselves and fell off and are partially adhered as a result of what appears to be a failure of the adhesion material . Two light covers may have been lost while driving. Unknown if their loss resulted in damage(s) to others. Without the outer cover results in the exposure of the lights to weather and potential failure. Review with Toyota of Orange service manager confirm the failure of adhesive/ manufacturing process of the lights”
NHTSA complaint #11664729, 2025

“THE LOW BEAM HEADLIGHTS ARE MELTING THE PLASTIC COVER ON THE HEADLIGHT ASSEMBLIES. BOTH SIDES ARE MELTING FROM THE HEAT OF THE LOW BEAM LIGHT BULBS. IT WAS FIRST NOTICED AT 37,000 MILES, AT 3 YEARS OLD. FACTORY INSTALLED PARTS, NO MODIFICATIONS HAVE BEEN DONE TO THE VEHICLE. THE LOW BEAM LIGHTS ARE ONLY OPERATING AT NIGHT, ABOUT 25% OF THE DRIVING TIME ON THE VEHICLE, SO THE MELTING OCCURRED WITHIN APPROXIMATELY 10,000 MILES OF DRIVING TIME. THE VEHICLE WAS OUT OF WARRANTY WHEN IT WAS REPORTED TO TOYOTA, BUT THIS MELTING HAS BEEN OCCURRING SINCE DAY ONE. THIS DEFECT WILL AFFECT THE SA…”
NHTSA complaint #11021275, 2017

Seats 2

“WE PURCHASED A 2014 TOYOTA HIGHLANDER LIMITED ON AUG 9, 2014. AFTER DRIVING THE VEHICLE FOR ABOUT 150 MILES THE PERSON IN THE RIGHT FRONT PASSENGER SEAT EXPERIENCES SEVERE BACK AND DISCOMFORT IN THE AREA OF THE TAILBONE. THERE IS SOMETHING VERY HARD TOWARDS THE BACK OF THE SEAT. I COMPLAINED TO THE SELLING DEALER AND THEY RECOMMENDED COMING BACK WHEN THE ZONE REP WAS IN AREA. I RETURNED A WEEK LATER AND MET WITH THE ZONE REP. SHE HAD ME SIT IN ANOTHER HIGHLANDER LIMITED AND ASKED IF IT FELT DIFFERENT, IT DID FEEL THE SAME. HER REPLY WAS "DIDN'T YOU SIT IN THE CAR BEFORE YOU BOUGHT I…”
NHTSA complaint #10715184, 2015

“I PURCHASED MY 2014 TOYOTA HIGHLANDER ON 4/24/14. I NOTICE A FEW DAYS LATER THAT THEIR WAS A CHIRP NOISE IN THE PASSENGER 2ND ROW WHILE DRIVING ( VERY ANNOYING). I TOOK IT TO DEALER AND IT WAS DIAGNOSIS THAT THE RAIL RACK SHOWS SIGN OF FRICTION AND POSSIBLE CAUSING IT CREATE THE CHIRP NOISE. *TR”
NHTSA complaint #10586699, 2014

Electronic Stability Control (Esc) 1

“MY COMPLAINT CONCERNS THE SAFETY OF THE WELLBEING OF MYSELF AND PASSENGERS IN MY VEHICLE. THE REAR AUTOMATUC DOOR LOCK ON MY PASSENGER SIDE OF MY HIGHLANDER WENT OUT FIRST. THEN THE DRIVER DOOR AT ANY GIVEN TIME MAY OR MAY NOT OPEN. NOT EVEN WITH THE KEY. I HAVE TO GO TO THE PASSENGER SIDE AND CLIMB OVER AND UNLOCK THE DOOR AND GO BACK AROUND TO GET IN. MY CONCERN IS BEING IN A WRECK AND THE DOOR NOT OPENING. NOT BEING ABLE TO GET A CHILD OUT OF THE CARSEAT IN THE BACK BECAUSE THE DOOR WON'T OPEN. YES. IT MAY BE THE ACTUATORS AND I HAVE READ THE EXPENSIVE REVIEWS OF GETTING THOSE FIXED ONLY TO…”
NHTSA complaint #11187290, 2019

Latches/Locks/Linkages 1

“The contact owns a 2014 Toyota Highlander. The contact stated that the tailgate failed to open and close properly or as needed. The vehicle was taken to an independent mechanic, who referred the contact to file a complaint with the NHTSA Hotline. The manufacturer was made aware of the failure. The failure mileage was approximately 87,000.”
NHTSA complaint #11517033, 2022