2012 Tesla Model S Problems & Owner Complaints

Electrical System 36

“I tried to start the car and got the “Center Display unavailable” message. Reset the computer doesn’t help. I have to wait for more than 5 minutes for the system to be on.”
NHTSA complaint #11495377, 2022

“I charge my Model S on a 30 amp circuit with the car location amperage set to 20 amps to avoid overheating the circuit. Around Sept 12 while plugged in to the 30 amp, the car pulled in 50 amps off the line causing a melting of the wires and a near fire based on the damages later found. The car is supposed to send charging error alerts or problems via the Tesla app. Instead it continued to try to pull power out of the burnt line for 11 days all the while further depleting the battery. I discovered my car a 0% battery range with a dead 12 volt as well just as it had depleted and discovered…”
NHTSA complaint #11488480, 2022

“Both the 12 volt system and High voltage battery system or a component communicating between the two failed. I received a warning message that my vehicle may not restart and within 30 seconds it completely shutdown while driving in the middle of the road. The vehicle was essentially dead weight at this point. None of its features worked, the ability to unlock it, the ability to use electronic doors and windows functions could not be performed. it could not even be jumped to start the computer enabling it to be towed or put in neutral to even remove the vehicle from the roadway. The manufact…”
NHTSA complaint #11468855, 2022

Unknown Or Other 11

“MCU failure after 12 months replacement that I paid for at time of replacement. Service center cannot schedule a service for 2 weeks.”
NHTSA complaint #11441219, 2021

“THERE IS A KNOW PROBLEM WITH THE TESLA INFOTAINMENT SYSTEM FAILING SO I HAD MINE UPGRADED. NOW THE REAR CAMERA IS NEARLY USELESS. IT IS SO DARK IT IS A SAFETY HAZARD. I HAVE CONTACTED TESLA AND THEY ARE AWARE AND HAVE NO PLANS TO FIX.”
NHTSA complaint #11389454, 2021

“THE HEATER AND DEFROSTER STOPPED WORKING IN THIS COLD WEATHER AS WE WERE DRIVING HOME WITH MY SONS. THEY WERE FREEZING AND COLD. I WAS NOT ABLE TO SEE CLEARLY RATHER VERY FOGGY WINDSHIELD DUE TO NON-WORKING CABIN HEATER AND DEFROSTER. THIS ISSUE HAD HAPPENED TO MANY MANY TESLA OWNERS, INFACT MODEL S LIKE MINE AND EVEN THE BRAND NEW TESLA MODEL 3 AND MODEL Y WITH JUST LESS THAN 10O MILES. THIS CLEARLY IS A HUGE NEGLIGENCE ON THE PART OF TESLA NOT WANTING TO FIX THE ISSUE. HOWEVER, NOW RIGHT AFTER GETTING THE CONTROL TOUCH SCREEN ISSUE ADDRESSED, THE SAME DAY TESLA TOLD ME THE CAR IS READY AN…”
NHTSA complaint #11385791, 2020

Suspension 9 3 crash 1 fire 6 injury 1 death

“THIS IS THE STOLEN CAR WHICH CRASHED IN HOLLYWOOD. PHOTOGRAPHS AT THE SCENE SHOW 3/4 OF A WHEEL AND THE TIRE LYING ON THE GROUND. HERE IS THE LISTING AT THE SALVAGE AUCTION SITE. HTTP://IMGUR.COM/A/H7ROA THE CRASH SITE IMAGES HOW THE FRONT WHEEL BROKEN LOOSE. THE SALVAGE YARD PHOTOGRAPHS SHOW THE OTHER 1/4 OF THE WHEEL STILL BOLTED TO THE BROKEN KINGPIN. THE WHEEL HAS BEEN SLICED IN TWO WHILE STILL ROLLING ON THE ROAD. IT WOULD BE IMPOSSIBLE FOR THAT SLICING TO HAVE OCCURRED POST IMPACT. THERE ARE 100,00 OF THESE CARS ON ROADS AROUND THE WORDLD. IF THIS WAS AN AIRCRAFT IT WOULD BE G…”
NHTSA complaint #10789052, 2014 · crash · fire · 1 death(s)

“HERE IS ANOTHER TESLA IN THE JUNKYARD. HTTPS://M.IAAI.COM/VEHICLEDETAILIMAGES.ASPX?IMAGEURL=2&ITEMID=23306666 THE PHOTOGRAPHS SHOW THAT THE FRONT STEERING KNUCKLE HAS SNAPPED IN HALF AND THE WHEEL IS HANGING SIDEWAYS OUT OF THE WHEEL WELL. THE CAR HAS NOT BEEN IN A CRASH. THE AIR-BAGS HAVE NOT DEPLOYED AND THERE IS NO SIGNIFICANT DAMAGE TO THE BODYWORK. THESE STEERING KNUCKLES ARE A MADE FROM LOW PRESSURE DIE CAST ALUMINIUM WHICH IS CLEARLY NOT STRONG ENOUGH FOR THE PURPOSE. THERE ARE MANY EXAMPLES WHERE THE KNUCKLE HAS SIMPLY SNAPPED COMPLETELY IN HALF JUST LIKE THIS ONE. PLEASE INVE…”
NHTSA complaint #10917208, 2016 · crash

“I AM FILING THESE COMPLAINTS IN THE PUBLIC INTEREST. I AM NOT A TESLA OWNER AND I HAVE NO INVESTMENT IN TESLA NOR DO I HOLD ANY SHARES IN THE STOCK-MARKET. THIS CAR IS IN THE WRECKING YARD. THE FRONT SUSPENSION HAS FAILED AND THE WHEEL IS PUSHED BACK AGAINST THE HIGH VOLTAGE CONTROLLER. HTTP://WWW.SALVAGERESELLER.COM/VEHICLES/DETAILS/32315405-2012-TESLA-MODEL-S-CA-SAN-DIEGO THERE IS NO OTHER DAMAGE THAT COULD ACCOUNT FOR THE SUSPENSION FAILURE. THERE WAS A CRASH BACK IN 2013 WHICH WAS BLAMED ON THE DRIVER OF THE OTHER CAR. HTTP://WWW.INAUTONEWS.COM/TESLA-MODEL-S-GETS-CRASHED-DR…”
NHTSA complaint #10785486, 2015 · crash

Exterior Lighting 5

“I tried to start the car and got the “Center Display unavailable” message. Reset the computer doesn’t help. I have to wait for more than 5 minutes for the system to be on.”
NHTSA complaint #11495377, 2022

“As the car drains the battery pretty quickly, I have turned on energy saving mode. In this mode the car enters a deeper sleep, consuming less power. Sometimes in this mode when starting the vehicle, the turn signals will not work (this appears to happen when the car sits for a while and the miles left on the battery is under 120 or so). After a quick stop (2 minutes out of the car), the turn signals will start working, and the driver display will show the blinking turn signal when they work, but it will not display when they do not work. Another issue is that after entering the car and "tu…”
NHTSA complaint #11435793, 2021

“The contact owns a 2012 Tesla Model S. The contact received notification of NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting). The contact stated that the center display screen failed to operate as needed. The dealer had been notified about the recall; however, the contact was informed that he did not qualify for the recall despite having received a letter for the recall. The manufacturer had not been notified of the issue. The contact stated that recently the center display screen started to operate as needed. The failure mileage was approximately 51,000.…”
NHTSA complaint #11434130, 2021

Visibility/Wiper 5

“I tried to start the car and got the “Center Display unavailable” message. Reset the computer doesn’t help. I have to wait for more than 5 minutes for the system to be on.”
NHTSA complaint #11495377, 2022

“The vehicle was not experiencing display or review view camera display issues but was out of caution serviced nuder Manufacturer Recall Number SB2121001 (NHTSA Recall Number 21V035) for no charge. The vehicle is not under warranty. There was no charge for the initial "repair". When the vehicle was returned, the rear view camera did not function (black screen and/or serious flicker when video was partially displayed). Also bubbles were introduced into the front display panel. On questioning the repair, I was strongly encouraged by technician and then by manager to get an updated "infotainmen…”
NHTSA complaint #11442524, 2021

“ON NOVEMBER 23RD 2020 I TOOK MY MODEL S ([XXX]) TO TESLA SERVICE CENTER LANCASTER, PA FOR THE TESLA WARRANTY ADJUSTMENT PROGRAM WHICH WAS ANNOUNCED ON NOVEMBER 9TH AND RELATED TO MALFUNCTIONING TOUCHSCREEN DUE TO A MALFUNCTIONING EMMC. THIS IS THE RESULT OF THE SERVICE VISIT; 1) TESLA LANCASTER, PA SERVICE CENTER TOLD ME MY VEHICLE IS NOT IN THE WARRANTY PARAMETERS (THE TESLA WARRANTY ADJUSTMENT PROGRAM STATED 8YEARS/100K MILES. MY CAR HAS LESS THAN 100K MILES AND INITIAL DELIVERY WAS NOVEMBER 24TH 2012 - SO TESLA LANCASTER, PA WAS WRONG ABOUT THIS AS SERVICE DATE WAS NOVEMBER 23RD, 2020)…”
NHTSA complaint #11397299, 2020

Power Train 4

“The drive unit has water damage from normal driving. The car never went through deep water or was flooded, but the tech at the service center is saying the units are sealed but still can get water in them and corrode. How can a vital sealed part of the vehicle be damaged by normal driving and claim water damage? The car operated just fine the day before. Please advise.”
NHTSA complaint #11510630, 2023

“The contact owns a 2012 Tesla Model S. The contact stated while driving 20 MPH, the vehicle independently shifted to neutral. An unknown warning light was illuminated. The vehicle was taken to the dealer who informed the contact that they could not duplicate the failure. The contact stated that the failure recurred daily while driving whenever he depressed the brake pedal. The vehicle was taken back to the same dealer. The dealer informed the contact that the failure could not be duplicated. The manufacturer was notified of the failure but provided no assistance. The vehicle was not repaired.…”
NHTSA complaint #11434069, 2021

“The contact owns a 2012 Tesla Model S. The contact stated while driving at various speeds, there was an abnormal humming sound detected coming from the drive unit. There was no warning light illuminated. The vehicle was taken to the local dealer and diagnosed that the drive unit needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure. The failure mileage was approximately 59,000.”
NHTSA complaint #11422548, 2020

Equipment 3

“TL* THE CONTACT OWNS A 2012 TESLA MODEL S. THE CONTACT STATED THAT THE MEDIA CONTROL UNIT WAS INOPERABLE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER TESLA SERVICE CENTER (11163 SANTA MONICA BLVD, LOS ANGELES, CA 90025, (310) 473-8337) WHERE IT WAS DIAGNOSED WITH NEEDING THE MEDIA CONTROL UNIT AND MOTHERBOARD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 21V035000 (EXTERIOR LIGHTING, VISIBILITY, BACK OVER PREVENTION) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND REFERRED THE…”
NHTSA complaint #11395449, 2020

“THE VEHICLE'S MAIN DISPLAY, WHICH SHOWS THE BACKUP CAMERA, FREEZES/LOCKS WHEN TURNING ON THE VEHICLE. THE ERROR MESSAGE ON THE DRIVERS DISPLAY IS THAT THE LARGE DISPLAY IS "UNRESPONSIVE". THEN, WHEN RESTARTING THE DISPLAY'S OPERATING SYSTEM (BY HOLDING THE TWO BUTTONS DOWN ON THE CAR'S STEERING WHEEL), THE SYSTEM REBOOTS AND THE DISPLAY GOES PERMANENTLY BLANK UNTIL THE VEHICLE IS PARKED, THE VEHICLE POWERS OFF. WHEN STARTING THE VEHICLE FOR A SECOND TIME, THE SAME ISSUE OCCURS. SO I NO LONGER HAVE A BACKUP CAMERA. GIVEN MY MODEL S YEAR DOES NOT HAVE ANY SENSORS OTHER THAN THE VISUAL BACKU…”
NHTSA complaint #11330877, 2020

“TL* THE CONTACT OWNS A 2012 TESLA MODEL S. THE CONTACT STATED THAT THERE WAS A STICKY SUBSTANCE COMING OUT OF THE CENTER DISPLAY WHETHER THE VEHICLE WAS TURNED ON OR OFF. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER TESLA (135 US-22, SPRINGFIELD, NJ 07081, (973)921-0925) WHERE IT WAS DIAGNOSED WITH NEEDING THE CENTER DISPLAY TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 21V035000 (BACK OVER PREVENTION, VISIBILITY, EXTERIOR LIGHTING) HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE.…”
NHTSA complaint #11397709, 2018

Back Over Prevention 2

“The contact owns a 2012 Tesla Model S. The contact received notification of NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting). The contact stated that the center display screen failed to operate as needed. The dealer had been notified about the recall; however, the contact was informed that he did not qualify for the recall despite having received a letter for the recall. The manufacturer had not been notified of the issue. The contact stated that recently the center display screen started to operate as needed. The failure mileage was approximately 51,000.…”
NHTSA complaint #11434130, 2021

“TL* THE CONTACT OWNS A 2012 TESLA MODEL S. THE CONTACT STATED THAT THERE WAS A STICKY SUBSTANCE COMING OUT OF THE CENTER DISPLAY WHETHER THE VEHICLE WAS TURNED ON OR OFF. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER TESLA (135 US-22, SPRINGFIELD, NJ 07081, (973)921-0925) WHERE IT WAS DIAGNOSED WITH NEEDING THE CENTER DISPLAY TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 21V035000 (BACK OVER PREVENTION, VISIBILITY, EXTERIOR LIGHTING) HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE.…”
NHTSA complaint #11397709, 2018

Fuel/Propulsion System 2

“Both the 12 volt system and High voltage battery system or a component communicating between the two failed. I received a warning message that my vehicle may not restart and within 30 seconds it completely shutdown while driving in the middle of the road. The vehicle was essentially dead weight at this point. None of its features worked, the ability to unlock it, the ability to use electronic doors and windows functions could not be performed. it could not even be jumped to start the computer enabling it to be towed or put in neutral to even remove the vehicle from the roadway. The manufact…”
NHTSA complaint #11468855, 2022

“eMMU seem to have caused "Console display not available error"”
NHTSA complaint #11417527, 2021

Structure 2

“SLOWLY BACKING UP AND REAR SUB FRAME MOTOR MOUNT BROKE. ON A CITY STREET UNDER 5MPH”
NHTSA complaint #11296639, 2019

“I HAVE A 2012 TESLA MODEL S P85 WITH 90,000 MILES. I NOTICED THE CAR FISHTAIL AGGRESSIVELY WHEN I ACCELERATED A FEW WEEKS AGO AT FREEWAY SPEEDS OF 55MPH AND ABOVE, TOOK IT IN TO TESLA SERVICE AND THEY EXPLAINED THAT I HAD A CRACK IN MY SUBFRAME. THE CAR HAS NEVER BEEN IN AN ACCIDENT, NEVER BOTTOMED OUT OR BEEN DRIVEN OFF-ROAD, JUST NORMAL STREETS AND HIGHWAYS. I WAS QUOTED $3,300 TO HAVE THIS FIXED, THEY WILL REPLACE WITH A NEW OR RE-MANUFACTURED SUBFRAME . I HAVE ATTACHED A PICTURE OF ANOTHER PERSONS SUBFRAME WHERE THE METAL SHEARED AWAY. THE AREA IN THE MIDDLE IS WHERE THE DRIVE UNIT IS PL…”
NHTSA complaint #11208159, 2019

Engine 1

“Motor is starting to make sounds and according to teslamotorsclub.com the motor will fail eventually. Many have to had to have the motor switched out multiple times. It is quite evident that there was a design flaw which Tesla corrected in later years.”
NHTSA complaint #11512319, 2021

Lane Departure 1

“ON NOVEMBER 23RD 2020 I TOOK MY MODEL S ([XXX]) TO TESLA SERVICE CENTER LANCASTER, PA FOR THE TESLA WARRANTY ADJUSTMENT PROGRAM WHICH WAS ANNOUNCED ON NOVEMBER 9TH AND RELATED TO MALFUNCTIONING TOUCHSCREEN DUE TO A MALFUNCTIONING EMMC. THIS IS THE RESULT OF THE SERVICE VISIT; 1) TESLA LANCASTER, PA SERVICE CENTER TOLD ME MY VEHICLE IS NOT IN THE WARRANTY PARAMETERS (THE TESLA WARRANTY ADJUSTMENT PROGRAM STATED 8YEARS/100K MILES. MY CAR HAS LESS THAN 100K MILES AND INITIAL DELIVERY WAS NOVEMBER 24TH 2012 - SO TESLA LANCASTER, PA WAS WRONG ABOUT THIS AS SERVICE DATE WAS NOVEMBER 23RD, 2020)…”
NHTSA complaint #11397299, 2020

Service Brakes 1

“The contact owns a 2012 Tesla Model S. The contact stated while driving 20 MPH, the vehicle independently shifted to neutral. An unknown warning light was illuminated. The vehicle was taken to the dealer who informed the contact that they could not duplicate the failure. The contact stated that the failure recurred daily while driving whenever he depressed the brake pedal. The vehicle was taken back to the same dealer. The dealer informed the contact that the failure could not be duplicated. The manufacturer was notified of the failure but provided no assistance. The vehicle was not repaired.…”
NHTSA complaint #11434069, 2021

Steering 1

“NOTICED THIS PROBLEM AFTER I WAS BACKING UP AND TURNING MY WHEELS AND WOULD HEAR A LOUD METAL ON METAL "CLUNK" OR "GRINDING" SOUND. IT WAS COMING FROM THE FRONT-LEFT SUSPENSION AND WOULD OCCUR CAUSING MY WHEEL AND STEERING TO FEEL LIKE IT WAS SKIPPING. I NOTICED AND MY STEERING FELT "LOOSE" OVER BUMPS AND WOULD PULL TO THE LEFT. AGAIN THE VEHICLE IS IN MOTION AND THIS WAS FELT THE MOST WHEN TURNING FULL MOTION AND/OR BACKING UP AND TURNING. WHEN LOOKING AT ONE OF THE CONTROL-ARM JOINTS AFTER I NOTICED A VERY LOUD CLUNK AND COMPARING IT TO THE OTHER SIDE OF OF THE SUSPENSION, IT LOOKS L…”
NHTSA complaint #10885723, 2016

Vehicle Speed Control 1 1 crash

“CAUSE UNKNOWN. THE VEHICLE WAS STOPPED JUST BEFORE ENTERING INTO A HEAD IN PARKING SPACE WHEN WITH THE BRAKE DEPRESSED, THE VEHICLE ACCELERATED SUDDENLY AND UNCONTROLLABLY CAUSING IT TO JUMP THE CURB AND TAKE DOWN A RETAINING WALL. IT CONTINUED THROUGH THE WALL UNTIL IT WAS STOPPED BY A TREE. VEHICLE WAS A TOTAL LOSS. VEHICLE SETTINGS AT THE TIME OF INCIDENT WERE AS FOLLOWS: THERE IS NO AUTOPILOT ON THIS MODEL S AND CRUISE CONTROL WAS OFF. ADDITIONALLY, THE CAR WAS SET WITH CREEP MODE OFF. HVAC WAS ON.”
NHTSA complaint #11300279, 2019 · crash

Visibility 1

“The contact owns a 2012 Tesla Model S. The contact received notification of NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting). The contact stated that the center display screen failed to operate as needed. The dealer had been notified about the recall; however, the contact was informed that he did not qualify for the recall despite having received a letter for the recall. The manufacturer had not been notified of the issue. The contact stated that recently the center display screen started to operate as needed. The failure mileage was approximately 51,000.…”
NHTSA complaint #11434130, 2021